Beruflich Dokumente
Kultur Dokumente
ratio is 0.3. The displacement fields with respect to each frequency are to be
PROBLEM: Consider the circular hollow shaft of uniform thickness with dimensions shown in the figure below. The thickness of the hollow shaft is 5mm, the youngs module E=21000 N/mm2 and the Poisson ratio is 0.3. Shaft is subjected to compressive load of 100 N acts through its major axis. The stress and displacement fields are to be determined using ANSYS.
Analyze the thermal stresses induced in the given cantilever 2-D square plate by using ANSYS software. (coupled feild analysis)
PROBLEM: Consider the corner angle bracket, the upper left-hand pin hole is constrained (welded) around its entire circumference, and a tapered pressure load is applied to the bottom of the lower right-hand pin hole
PROBLEM:1
Find stress and displacement of the given cantilever beam subjected to end point load by using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given cantilever beam subjected to uniformly distributed load by using ANSYS software.
PROBLEM:1
Find stress and displacement of the given cantilever beam subjected to end point load using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given fixed beam subjected to uniformly distributed load by using ANSYS software.
PROBLEM:1
Consider the square plate of uniform thickness with a circular hole with dimensions shown in the figure below. The thickness of the plate is 1mm. the youngs module E=107 Mpa and the Poisson ratio is 0.3. A uniform pressure P=1Mpa acts on the boundary of the hole. Assume that plan stress conditions prevail. The stress and displacement fields are to be determined using ANSYS.
PROBLEM:2 Find stress and bending moment of the given simply supported beam subjected to uniformly distributed point load by using ANSYS software.
PROBLEM:1 Analyze the frequency response of a Cantilever beam using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given cantilever beam subjected to uniformly distributed load by using ANSYS software.
PROBLEM:1 Analyze the frequency response of a simply supported beam using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given simply supported beam subjected to uniformly distributed point load by using ANSYS software.
PROBLEM:1 Analyze the frequency response of a fixed beam using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given fixed beam subjected to uniformly distributed load by using ANSYS software.
PROBLEM:1 Analyze the frequency response of cantilever 2-D plate as using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given cantilever beam subjected to uniformly distributed load by using ANSYS software.
PROBLEM:1
Analyze the temperature distribution of given 2-D square plate by using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given simply supported beam subjected to uniformly distributed point load by using ANSYS software.
PROBLEM:1 Find stress and bending moment of the given cantilever beam subjected to uniformly distributed point load by using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given cantilever beam subjected to uniformly distributed load by using ANSYS software.
PROBLEM:1 Find stress and displacement of the given simply supported beam subjected to mid point load by using ANSYS software.
PROBLEM:2 Find stress and bending moment of the given simply supported beam subjected to uniformly distributed point load by using ANSYS software.
PROBLEM:1 Consider the square plate of uniform thickness with a circular hole with dimensions shown in the figure below. The thickness of the plate is 1mm, the youngs module E=107 Mpa and the Poisson ratio is 0.3. Plate is subjected to uniformly distributed load of 1000 N/m acts on the one side of the plate. Assume that plan stress conditions prevail. The stress and displacement fields are to be determined using ANSYS.
PROBLEM:2 Analyze the frequency response of a Cantilever beam using ANSYS software.