Beruflich Dokumente
Kultur Dokumente
ViewSonic VX2835wm-1
Model No. VS11531 28 wide Color TFT LCD Display
ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583
Copyright Copyright 2007 by ViewSonic Corporation. All rights reserved. No part of this publication may be reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any language or computer language, in any form or by any means, electronic, mechanical, magnetic, optical, chemical, manual or otherwise, without the prior written permission of ViewSonic Corporation. Disclaimer ViewSonic makes no representations or warranties, either expressed or implied, with respect to the contents hereof and specifically disclaims any warranty of merchantability or fitness for any particular purpose. Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes. Trademarks Optiquest is a registered trademark of ViewSonic Corporation. ViewSonic is a registered trademark of ViewSonic Corporation. All other trademarks used within this document are the property of their respective owners. Product disposal at end of product life The lamp in this product contains mercury. Please dispose of in accordance with local, state or federal laws.
Revision History
Revision
1a 1b
SM Editing Date
5/21/2007 6/25/2007
ECR Number
Description of Changes
Initial Release
Replaced the photo of Step 2 in Section DDCKey
Editor
Jamie Chang Jamie Chang
ViewSonic Corporation
VX2835wm-1
TABLE OF CONTENTS
1. Precautions and Safety Notices ......................................................................................... 1 2. Specification ....................................................................................................................... 5 3. Front Panel Function Control Description ..................................................................... 35 4. Circuit Description ............................................................................................................. 40 5. Adjusting Procedure .......................................................................................................... 41 6. Trouble Shooting Flow Chart ............................................................................................ 62 7. Block Diagrams ................................................................................................................ 68 8. Schematic Diagrams ........................................................................................................ 69 9. PCB Layout Diagrams ...................................................................................................... 81 10. Exploded Diagram And Spare Parts List........................................................................ 90 11. Recommended Spare Parts List .................................................................................... 92
ViewSonic Corporation
VX2835wm-1
VX2835wm-1
(11)
(12) (13)
(14)
the Interface Connector of the TFT Module. After installation of the TFT Module into an enclosure (LCD monitor housing, for example), do not twist nor bend the TFT Module even momentary. At designing the enclosure, it should be taken into consideration that no bending/twisting forces are applied to the TFT Module from outside. Otherwise the TFT Module may be damaged. Cold cathode fluorescent lamp in LCD contains a small amount of mercury. Please follow local ordinances or regulations for disposal. Small amount of materials having no flammability grade is used in the LCD module. The LCD module should be supplied by power complied with requirements of Limited Power Source, or be applied exemption. The LCD module is designed so that the CFL in it is supplied by Limited Current Circuit Do not connect the CFL in Hazardous Voltage Circuit.
ViewSonic Corporation
VX2835wm-1
5.2 handling and placing procedure 1. Open the carton box, before you remove anything from the carton box, check all the accessory listed in the packing list. Remember the position of the left and right poly foams to avoid any problem when packing them.
2.
When removing the LCD monitor, make sure that you are holding from the back side of the LCD monitor and not the front side of the LCD monitor.
ViewSonic Corporation
VX2835wm-1
3.
Place the LCD monitor on a flat table and remove the plastic bag.
4.
When placing the LCD screen on the table, you need to make sure there are no object underneath to avoid any damage on the LCD screen. It is not advisable to wear any jewelry like rings, bracelet or watch to avoid any scratch on the LCD screen, or casing when doing the service.
ViewSonic Corporation
VX2835wm-1
2. Specification
Introduction
FEATURES Size Luminance (Typ) TFTLCD PANEL 1st Contrast Ratio (Typ) Colors Response Time Viewing Angle (H/V) Recommend resolution Input Signal Analog Digital Separate Sync Sync Compatibility Composite Sync Sync on Green PC Compatibility Power Mac TV Box Power Voltage AC 100-240V, 50/60Hz On Mode Power Consumption ( Max. for Energy star) Off Mode (Max) Audio 3W / THD 10% (Max) Tilt ( 20 - -5 ) Ergonomics Swivel Pivot Height Adjust OSD Control Operating Condition [ 1 ] [ 2 ] [ ][] [] Temperature (/) Humidity (%) Temperature (/) Humidity (%) Global: CB, TCO06,WEEE,ROHS VSA:UL, cUL, FCC-B, IRAM, NOM, Energy Star, ICES-003 Regulation VSE:,NEMKO/ERGO, CE GOST-R+Hygienic ,SASO , ENERGY, UkrSEPRO VSI: BSMI, PSB, C-TICK, EK, VCCI, VSCN:CCC VX2835wm 27.54 " wide 500 cd/ 800:1 16.7 M 5 ms(on/off) / 3ms (G to G) 160 / 160 1920x1200@60Hz Yes (75ohms, 0.7/1.0 Vp-p) Yes Yes Yes( No Guarantee image Quality) Yes( No Guarantee image Quality) Yes Yes Yes Yes < 64.5W 1 W Yes Yes No No No Yes 32-104/+0-+40 10 % - 90 % -4-140/-20-60 10 % - 80 %
Storage Condition
ViewSonic Corporation
VX2835wm-1
Product definition and specification Region Product Name Model Number OSD Languages TFT LCD Panel and Model # Scalar Input Signal Sync Compatibility Audio Power Consumption Power Cable Analog Cable (1.8 m, color : black), with PC
2001 and Hot Plug Detect &DDC VSA (M) VSAP (A)/(P)/(J)/(S)/(K) VSE (E)/(U) VSCN (G)
VX2835wm VS11531
English, French, German, Italian, Spanish, Finnish, Russian, Japanese, Traditional Chinese, Simplified Chinese
HSD 280MUW1-A Mstar, Model # :MST 6251DA-205LF D-Sub / HDMI / YPbPr / CVBS / S-Video Separate / [Composite / SOG(image quality no
guarantee )]
3W Built-in/ under 64.5W (max , Energy Star Standard@175nits) / 130 W(max @500nits) Refer to Appendix G YES YES
Arabic, English, Finnish, Spanish, German, Italian, Japanese, Swedish, Polish, Korean, Portuguese, Russian, French, Simplified Chinese, Traditional Chinese, Czech, Hungarian, Greek, Dutch, Turkish
Screen Protector Mylar Extrme Label (?ms) Service Insert (new version) Warranty Sticker Warranty Card Carton Sticker PE bag of Carton Energy Star Sticker(Upper Right corner) Hi-pot label (Back cover) QC pass label(Back cover) NO YES NO NO NO NO YES YES NO NO NO NO NO NO NO YES YES NO
YES NO NO NO NO NO NO YES YES NO NO NO YES YES YES YES YES YES YES
ViewSonic Corporation
VX2835wm-1
Video Compatibility Video timing support (CVBS / S-Video) Video timing support (HDMI / YPbPr) Resolution Compatibility
ViewSonic Corporation
VX2835wm-1
The image vertical size might not be full screen. But the image vertical position should be at the center. Exclusions Not compatible with interlaced video Video input Audio / Video Action CVBS S-Video YPbPr D-sub DVI-D via HDMI X HDMI
RCA (white + red) with CVBS Audio input RCA (white + red) with YPbPr 3.5mm phone jack Audio in HDMI
Video OVERSCAN Component over scan: 5~8% AV over scan: 5~8%
X X X
X X X
X X
X X
X X
X X
HDMI over scan: No over scan for PC input, 5~8% for video source. PC: No over scan
ViewSonic Corporation
VX2835wm-1
Shall be able to withstand 1.5 times nominal line voltage for one cycle with no damage Shall be able to function properly, without reset or visible screen artifacts, when cycle of AC power is randomly missing at nominal input The power supply shall not produce audible noise that would be detectable by the
user. Audible shall define to be in compliance with ISO 7779 (DIN EN27779:1991) Noise measurements of machines acoustics. Power Switch noise shall not be considered
US Type Power Cable Color = Black European Type Power Cable Color = Black CCC Type Power Cable Color = Black PSE Type Power Cable Color = Black Power Saving Operation(Method)
Separate 3-prong NEMA 5-15P type plug. Length = 1.8m. Connects to display.
Schuko CEE7-7 type plug. Length = 1.8m, Connects to display. Separate 3-prong type plug. Length = 1.8m. Connects to display. Separate 2-prong NEMA 1-15P type plug. Length = 1.8m. Connects to display. VESA DPMS Signaling On Mode <60 W (Typ) / under 64W (Max for Energy Star) Max power output :130W(Max. @500nits)
Power Consumption
Saving Mode < 2 W@230VAC 50Hz Off Mode < 1 W @230VAC 50Hz (DC Power Off; Meet to Energy Star Ver4.0 Tier2)
Recovery Time
ViewSonic Corporation
VX2835wm-1
Timing Table
Analog Composite Separated Item 1 2 3 4 5 Timing SOG Digital - TMDS S-Video YPbPr CVBS
Remark
For Composite and SOG, the image vertical size image will be not full 640 x 350 @ 70 Hz, 32 KHz X X X screen (Still at the center), And the OSD will be 640x350/640x400/720x400 (promary= 640x400). For Composite and SOG, the image vertical size image will be not full 640 x 350 @ 85 Hz, 38 KHz X X X screen (Still at the center), And the OSD will be 640x350/640x400/720x400 (promary= 640x400). For SOG sync, switch 640 x 400 @ 60 Hz, 32 KHz X X X 640x400@60Hz and 640x480@60Hz by [1]+[2] short cut key (primary = 640x480@60Hz) For Composite and SOG, the image vertical size image will be not full 640 x 400 @ 70 Hz, 32 KHz X X X screen (Still at the center), And the OSD will be 640x350/640x400/720x400 (promary= 640x400). For Composite and SOG, the image vertical size image will be not full 640 x 400 @ 85 Hz, 38 KHz X X X screen (Still at the center), And the OSD will be 640x350/640x400/720x400 (promary= 640x400).
ViewSonic Corporation
VX2835wm-1
8 9 10 11 12
640 x 480 @ 67 Hz, 35 KHz 640 x 480 @ 70 Hz, 35 KHz 640 x 480 @ 72 Hz 38 KHz 640 x 480 @ 75 Hz, 38 KHz 640 x 480 @ 85 Hz, 43 KHz
X X X X X
X X X X X
X X X X X
Mac Timing
For Composite and SOG, the image vertical size image will be not full 13 720 x 400 @ 70 Hz, 32 KHz X X X screen (Still at the center), And the OSD will be 640x350/640x400/720x400 (promary= 640x400). For Composite and SOG, the image vertical size image will be not full 14 720 x 400 @ 85 Hz, 38 KHz X X X screen (Still at the center), And the OSD will be 640x350/640x400/720x400 (promary= 640x400). 15 16 17 18 19 20 21 720 x 480 @ 60 Hz, 32 KHz 800 x 600 @ 60 Hz, 38 KHz 800 x 600 @ 70 Hz, 43 KHz 800 x 600 @ 72 Hz, 48 KHz 800 x 600 @ 75 Hz, 47 KHz 800 x 600 @ 85 Hz, 54 KHz 832 x 624 @ 75 Hz, 50 KHz X X X X X X X X X X X X X X X X X X X X X For Separated and Composite sync, Switch 1024x768@50Hz and 22 1024 x 768 @ 50 Hz, 40 KHz X X X 1280x768@50Hz by [1]+[2] short cut key (primery = 1024x768@50Hz) 23 1024 x 768 @ 60 Hz, 48 KHz 24 1024 x 768 @ 70 Hz, 57 KHz 25 1024 x 768 @ 72 Hz, 58 KHz 26 1024 x 768 @ 75 Hz, 60 KHz 27 1024 x 768 @ 75 Hz, 60 KHz X X X X X X X X X X X X X X X For Analog sync, the information OSD shows 640x480
ViewSonic Corporation
VX2835wm-1
28 1024 x 768 @ 85 Hz, 69 KHz 29 1152 x 864 @ 75 Hz, 68 KHz 30 1152 x 870 @ 75 Hz, 69 KHz 31 1280 x 720 @ 50 Hz, 38 KHz 32 1280 x 720 @ 60 Hz, 38 KHz X X X X
X X X X X
X X X X X
34 1280 x 768 @ 60 Hz, 47 KHz 35 1280 x 768 @ 60 Hz, 48 KHz 36 1280 x 768 @ 75 Hz, 60 KHz 37 1280 x 768 @ 85 Hz, 69 KHz 38 1280 x 960 @ 50 Hz, 49 KHz 39 1280 x 960 @ 60 Hz, 60 KHz 40 1280 x 960 @ 75 Hz, 75 KHz 41 1280 x 960 @ 85 Hz, 86 KHz 42 1280 x 1024 1280 x 1024 1280 x 1024 1280 x 1024 1280 x 1024 @ 50 Hz, 53 KHz
X X X X X X X X X
X X X X X X X X X
X X X X X X X X X
43
@ 60 Hz, 64 KHz
44
@ 70 Hz, 75 KHz
45
@ 75 Hz, 80 KHz
46
@ 85 Hz, 91 KHz
X X X
X X X
49
1400 x 1050
1400x1050@60Hz and @ 60 Hz, 65 KHz X X X X 1680x1050@60Hz by [1]+[2] short cut key (primary = 1400x1050@60Hz) For Separated and Composite sync,
50
1400 x 1050
@ 60 Hz, 65 KHz
ViewSonic Corporation
VX2835wm-1
52 1440 x 900 @ 60 Hz, 56 KHz 53 1440 x 900 @ 60 Hz, 60 KHz 54 1440 x 900 @ 75 Hz, 75 KHz 55 1440 x 900 @ 85 Hz, 85 KHz 56 1600 x 1200 1600 x 1200 @ 50 Hz, 62 KHz
57
@ 60 Hz, 75 KHz
58
1680 x 1050
1400x1050@60Hz and @ 60 Hz, 65 KHz X X X X 1680x1050@60Hz by [1]+[2] short cut key (primary = 1400x1050@60Hz) For Separated and Composite sync,
59
1680 x 1050
Switch 1400x1050@60Hz and @ 60 Hz, 65 KHz X X X X 1680x1050@60Hz by [1]+[2] short cut key (primary = 1400x1050@60Hz)
60 61 62 63 64 65 66 67 68 69 70 71 72 73 74
1920 x 1200 480p 480p 480i 480i 576i 576i 576p 576p 720p 720p 1080i 1080i 1080p 1080p
@ 60 Hz, 74 KHz @ 50 Hz @ 60 Hz @ 50 Hz @ 60 Hz @ 50 Hz @ 60 Hz @ 50 Hz @ 60 Hz @ 50 Hz @ 60 Hz @ 50 Hz @ 60 Hz @ 50 Hz @ 60 Hz X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X
X X X
X X X
Unable Test
X X X X X X X X X X
ViewSonic Corporation
VX2835wm-1
4-5 FRONT PANEL CONTROLS AND INDICATORS Front Panel Hardware Controls Power Switch (Front Head) Power LED (Front Head) Power Control, soft Power Switch. Blue ON Orange Active Off Dark = Soft Power Switch OFF [ 1 ] BUTTON 1 [ 2 ] Button 2 [ ] Power [] DOWN ARROW BUTTON [] UP ARROW BUTTON Note: Power Button, Button 1 and Button 2 must be one-shot logic operation. (i.e. there should be no cycling) Reaction Time OSD must fully appear within 0.5s after pressing Button 1
Short Cuts Function from the button(s) [1] [2] [ ] [] +[] [1] + [2] [1] + [] + [] (Keep pressing 3 sec) [1] + [] [1] + [] [ ] [2] + [] [2] + [] [] +[] + [ ] Main Menu Input toggle (D-sub / HDMI / YPbPr / S-Video / CVBS) To immediately audio menu. Contrast & Brightness page (Recall both of audio to default under Audio page) Toggle 720x400 and 640x400 mode when input 720x400 or 640x400 mode White Balance. (Not shown on users guide) Power Lock OSD Lock
Essential mode switch Standard ->Text -> Cinema -> Game -> Portrait -> Scenery -> Vivid Skin tone switch Nature -> Reddish -> yellowish
DDC/CI
Factory Mode
Remark : All the short cuts function are only available while OSD off
ViewSonic Corporation
VX2835wm-1
Manual Image Adjust Horizontal Size*1, H/V. Position*1, Fine Tune*1, Sharpness*3 , Tint, Color Opticolor [Standard, Text , Cinema, Game, Portrait, Scenery, Vivid ], Opticolor Skin Tone[Nature, reddish ,yellowish], Aspect radio [1:1 / 4:3 / 16:9 / full screen] , PIP [position 1,2,3,4 / Size 1, 2 / Source1,2], PBP [Source1,2] Setup Menu Language [English, French, German, Italian, Spanish, Finnish, Russian, Japanese, Simplified Chinese, Traditional Chinese] Resolution Notice, OSD Position, OSD Timeout, OSD Background Sleep [30,45,60,120,off] Memory Recall
*1 These functions are not available in Digital Mode *2 These functions are not available under SRGB Mode, Opticolor On, and Opticolor Skin Tone On *3 These functions are not available under Native Resolution Mode *4 These functions setting can be recalled to default value under certain page by pressing []+[] *5 The audio functions should be transfer to RCA type from mini phone jack type when work under YPbPr mode. *6 The audio functions should be transfer to HDMI type from mini phone jack type (or RCA type) when work under HDMI mode with audio input [Remark] Please refer to the detail in the Appendix C
ViewSonic Corporation
VX2835wm-1
Function descriptions OSD Lock short cuts function for the buttons The OSD lock will be activated by pressing the front panel control buttons "(1), & ()" for 10 seconds. If the user then tries to access the OSD by pressing any of the buttons "1", "", "", "2" a message will appear on the screen for 3 seconds showing "OSD Locked". The OSD lock will be deactivated by pressing the front panel control buttons "(1), & ()" again for 10 seconds.
Note1: When the OSD is locked will lock all functions, including Volume and Mute Note2: Locked Note3: OSD Lock should not lock Power Button and Power Lock function Status bar indicating OSD Lock or Unlock is in progress and when complete it will indicate OSD
Power Lock short cuts function for the buttons The power button lock will be activated by pressing the front panel control buttons "(1), & ()" for 10 seconds. Locking the power button means that the user won't be able to turn off the LCD while the power button is locked. If the user presses the power button while it is locked, a message will appear on the screen for 3 seconds showing "Power Button Locked". It also means that with the power button locked, the LCD would automatically turn back "On" when power is restored after a power failure. If the power button is not in the locked mode, then power should return to it's previous state when power is restored after a power failure. The power button lock will be deactivated by pressing the front panel control buttons "(1), & ()" again for 10 seconds. Note 1: Status bar indicating Power Button lock or unlock is in progress and when complete it will indicate Power Button Locked Note 2: Power should only be lockable in the On State
Memory Recall Actions Memory Recall action on the analog and digital mode as below 1. Set the factory defaults as shown in Section 4-8 2. Clean all the mode setting buffer 3. Execute Auto Image Adjust Note: Memory Recall should have no effect for Language, Power Lock, User Color Settings or Input Priority
Resolution Notice Actions 1. Resolution Notice OSD should show on screen after changing to non-native mode for 30 sec 2. The OSD should disappear after 10 sec or by pressing button [1] or [2]
16 Confidential - Do Not Copy
ViewSonic Corporation
VX2835wm-1
Resolution Notice function should be disabled when press button [2] under Resolution Notice OSD
0-Touch Function Actions 1. Execute Auto Image Adjust when new mode detected, and save the settings to buffer for further use 2. It should be reset by Memory Recall function (Should not reset by power off, power unplug and others)
OSD Auto Save The OSD shall save new settings when it is turned off by the user or when it times out. There shall not be a separate save
Input Priority This function is defined the auto detect priority when the display has several inputs. Please refer to the detail flow chart as the appendix D
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
4-7 TFT LCD PANEL Panel Source Identify The panel code T for HannStar panel should be shown on the position 1. Lower right side of ID label. (See Figure 2) 2. Lower right side of UPC label . (See Figure 3) 3. The F/W version sticker or silkscreen Main board. Panel Characteristics: 1st Source Panel
Model number Type Active Size Pixel Arrangement Pixel Pitch Glass Treatment # of Backlights Backlight Life Luminance (5-point) Condition: CT = User Color, Contrast = Max, Brightness = Max Brightness Uniformity Contrast Ratio Color Depth Viewing Angle (Horizontal) TN type Viewing Angle (Vertical) TN type Response Time 10%-90% @ Ta=25C Panel Defects 75% Entire Area (min) 800:1 (typ), 600:1(min) 16.7 million colors @ CR>10 Typical: @ CR>10 Typical: 160 Minimum: 150 Typical = 5ms (on/off) / 3ms (G to G) Maxmum = 10 ms (on/off) / 7ms (G to G) Please see Panel Quality Specifications. 160 Minimum: 150 500 cd/m2 (Typ after 30 minute warm up) 400 cd/m2 (Min after 30 minute warm up) HSD280MUW1-A TN type with RSDS interface 27.5 wide; 593.28 (H) x 370.8 (V) RGB Vertical Stripe 0.309 (H) x 0.309 (H) mm Anti Glare (Hard coating 3H) 14 CCFL w/ Inverter / direct type 50000Hours (Min) at 6mA
ViewSonic Corporation
VX2835wm-1
EDID DATA
VX2835wm-a Time: 14:26:31 Date: Wed Jan 17, 2007 ______________________________________________________________________ ______________________________________________________________________ VIEWSONIC CORPORATION EDID Version # 1, Revision # 3 DDCTest For: ViewSonic VX2835wm ______________________________________________________________________ ______________________________________________________________________ EDID Block 0, Bytes 0-127 128 BYTES OF EDID CODE: 0 0 | 00 10 | 1F 20 | 6E 30 | 9F 40 | B3 50 | 81 60 | 23 70 | 00 80 | 30 90 | 00 100 | 00 1 2 3 4 5 6 7 8 9 ________________________________________ FF FF FF FF FF FF 00 5A 63 0F 01 01 01 01 01 11 01 03 3B 25 78 2E 9E 71 A6 54 4C 24 10 51 57 BF EF 80 D1 00 00 A9 40 95 00 90 40 81 80 40 71 4F 28 3C 80 A0 70 B0 40 30 20 36 00 51 73 21 00 1A 00 00 00 FF 00 51 46 47 37 30 31 30 30 30 30 31 0A 00 00 FD 00 32 4C 1E 52 11 0A 20 20 20 20 20 20 00 00
110 | 00 FC 00 56 58 32 38 33 35 77 120 | 6D 0A 20 20 20 20 00 5F ______________________________________________________________________ (08-09) ID Manufacturer Name ________________ = VSC (11-10) Product ID Code _____________________ = 0F1F (12-15) Last 5 Digits of Serial Number ______ = Not Used (16) (17) (18) (19) (20) Week of Manufacture _________________ = 01 Year of Manufacture _________________ = 2007 EDID Version Number _________________ = 1 EDID Revision Number ________________ = 3 VIDEO INPUT DEFINITION: Analog Signal 0.700, 0.000 (0.700 Vp-p) Separate Syncs, Composite Sync, Sync on Green
ViewSonic Corporation
VX2835wm-1
Maximum Horizontal Image Size ________________ Maximum Vertical Image Size __________________ Display Gamma ________________________________ Power Management and Supported Feature(s):
Active Off/Very Low Power, Standard Default Color Space, Preferred Timing Mode Display Type = R/G/B Color (25-34) CHROMA INFO: Red X - 0.650 Green X - 0.300 Blue X - 0.142 White X - 0.316 Red Y - 0.329 Green Y - 0.623 Blue Y - 0.065 White Y - 0.341 (35) ESTABLISHED TIMING I: 720 X 400 @ 70Hz (IBM,VGA) 640 X 480 @ 60Hz (IBM,VGA) 640 X 480 @ 67Hz (Apple,Mac II) 640 X 480 @ 72Hz (VESA) 640 X 480 @ 75Hz (VESA) 800 X 600 @ 56Hz (VESA) 800 X 600 @ 60Hz (VESA) (36) ESTABLISHED TIMING II: 800 X 600 @ 72Hz (VESA) 800 X 600 @ 75Hz (VESA) 832 X 624 @ 75Hz (Apple,Mac II) 1024 X 768 @ 60Hz (VESA) 1024 X 768 @ 70Hz (VESA) 1024 X 768 @ 75Hz (VESA) 1280 X 1024 @ 75Hz (VESA) (37) Manufacturer's Reserved Timing: 1152 X 870 @ 75Hz (Apple,Mac II) (38-53) Standard Timing Identification: 1920 X 1200 @60Hz 1680 X 1050 @60Hz 1600 X 1200 @60Hz 1440 X 900 @60Hz 1400 X 1050 @60Hz 1280 X 1024 @60Hz 1280 X 960 @60Hz 1152 X 864 @75Hz ______________________________________________________________________ (54-71) Detailed Timing / Descriptor Block 1: 1920x1200 Pixel Clock: 154.00 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Vertical Image Size: 371 mm
21 Confidential - Do Not Copy
ViewSonic Corporation
VX2835wm-1
Refreshed Mode: Non-Interlaced Horizontal: Active Time: 1920 pixels Sync Offset: 48 pixels Border: 0 pixels Vertical: Active Time: 1200 lines Sync Offset: 3 lines Border: 0 lines
Normal Display - No Stereo Blanking Time: 160 pixels Sync Pulse Width: 32 pixels Frequency: 74.04 KHz Blanking Time: 35 lines Sync Pulse Width: 6 lines Frequency: 59.95 Hz
Digital Separate, Horizontal Polarity (+) Vertical Polarity (-) ______________________________________________________________________ (72-89) Detailed Timing / Descriptor Block 2: Monitor Serial Number: QFG070100001 ______________________________________________________________________ (90-107) Detailed Timing / Descriptor Block 3: Monitor Range Limits: Min Vertical Freq - 50 Hz Max Vertical Freq - 76 Hz Min Horiz. Freq - 30 KHz Max Horiz. Freq - 82 KHz Pixel Clock - 170 MHz Secondary GTF - Not Supported ______________________________________________________________________ (108-125) Detailed Timing / Descriptor Block 4: Monitor Name: VX2835wm (126) (127) No Extension EDID Block(s) CheckSum OK
ViewSonic Corporation
VX2835wm-1
VX2835wm-HDMI Time: 16:22:30 Date: Wed Jan 17, 2007 ______________________________________________________________________ ______________________________________________________________________ VIEWSONIC CORPORATION EDID Version # 1, Revision # 3 DDCTest For: ViewSonic VX2835wm ______________________________________________________________________ ______________________________________________________________________ EDID Block 0, Bytes 0-127 128 BYTES OF EDID CODE: 0 0 | 00 10 | 1F 20 | 80 30 | 9F 40 | B3 50 | 81 60 | 23 70 | 00 80 | 30 90 | 00 100 | 00 1 2 3 4 5 6 7 8 9 ________________________________________ FF FF FF FF FF FF 00 5A 63 0F 01 01 01 01 01 11 01 03 3B 25 78 2E 9E 71 A6 54 4C 24 10 51 57 BF EF 80 D1 00 00 A9 40 95 00 90 40 81 80 40 71 4F 28 3C 80 A0 70 B0 40 30 20 36 00 51 73 21 00 1A 00 00 00 FF 00 51 46 47 37 30 31 30 30 30 30 31 0A 00 00 FD 00 32 4C 1E 52 11 0A 20 20 20 20 20 20 00 00
110 | 00 FC 00 56 58 32 38 33 35 77 120 | 6D 0A 20 20 20 20 01 4C ______________________________________________________________________ (08-09) ID Manufacturer Name ________________ = VSC (11-10) Product ID Code _____________________ = 0F1F (12-15) Last 5 Digits of Serial Number ______ = Not Used (16) (17) (18) (19) (20) Week of Manufacture _________________ = 01 Year of Manufacture _________________ = 2007 EDID Version Number _________________ = 1 EDID Revision Number ________________ = 3 VIDEO INPUT DEFINITION: Digital Signal Non - VESA DFP 1.x Compatible (21) (22) Maximum Horizontal Image Size ________________ Maximum Vertical Image Size __________________
23 Confidential - Do Not Copy
= 590 mm = 370 mm
ViewSonic Corporation
VX2835wm-1
(23) (24)
Display Gamma ________________________________ Power Management and Supported Feature(s): Active Off/Very Low Power, Standard Default Color Space, Preferred Timing Mode Display Type = R/G/B Color
= 2.20
(25-34) CHROMA INFO: Red X - 0.650 Green X - 0.300 Blue X - 0.142 White X - 0.316 Red Y - 0.329 Green Y - 0.623 Blue Y - 0.065 White Y - 0.341 (35) ESTABLISHED TIMING I: 720 X 400 @ 70Hz (IBM,VGA) 640 X 480 @ 60Hz (IBM,VGA) 640 X 480 @ 67Hz (Apple,Mac II) 640 X 480 @ 72Hz (VESA) 640 X 480 @ 75Hz (VESA) 800 X 600 @ 56Hz (VESA) 800 X 600 @ 60Hz (VESA) (36) ESTABLISHED TIMING II: 800 X 600 @ 72Hz (VESA) 800 X 600 @ 75Hz (VESA) 832 X 624 @ 75Hz (Apple,Mac II) 1024 X 768 @ 60Hz (VESA) 1024 X 768 @ 70Hz (VESA) 1024 X 768 @ 75Hz (VESA) 1280 X 1024 @ 75Hz (VESA) (37) Manufacturer's Reserved Timing: 1152 X 870 @ 75Hz (Apple,Mac II) (38-53) Standard Timing Identification: 1920 X 1200 @60Hz 1680 X 1050 @60Hz 1600 X 1200 @60Hz 1440 X 900 @60Hz 1400 X 1050 @60Hz 1280 X 1024 @60Hz 1280 X 960 @60Hz 1152 X 864 @75Hz ______________________________________________________________________ (54-71) Detailed Timing / Descriptor Block 1: 1920x1200 Pixel Clock: 154.00 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Vertical Image Size: 371 mm Normal Display - No Stereo
ViewSonic Corporation
VX2835wm-1
Active Time: 1920 pixels Sync Offset: 48 pixels Border: 0 pixels Vertical: Active Time: 1200 lines Sync Offset: 3 lines Border: 0 lines
Blanking Time: 160 pixels Sync Pulse Width: 32 pixels Frequency: 74.04 KHz Blanking Time: 35 lines Sync Pulse Width: 6 lines Frequency: 59.95 Hz
Digital Separate, Horizontal Polarity (+) Vertical Polarity (-) ______________________________________________________________________ (72-89) Detailed Timing / Descriptor Block 2: Monitor Serial Number: QFG070100001 ______________________________________________________________________ (90-107) Detailed Timing / Descriptor Block 3: Monitor Range Limits: Min Vertical Freq - 50 Hz Max Vertical Freq - 76 Hz Min Horiz. Freq - 30 KHz Max Horiz. Freq - 82 KHz Pixel Clock - 170 MHz Secondary GTF - Not Supported ______________________________________________________________________ (108-125) Detailed Timing / Descriptor Block 4: Monitor Name: VX2835wm (126) (127) Extension EDID Block(s): 1 CheckSum OK
ViewSonic Corporation
VX2835wm-1
Time: 16:22:30 Date: Wed Jan 17, 2007 ______________________________________________________________________ ______________________________________________________________________ VIEWSONIC CORPORATION EDID CEA-861B Timing Extension Version 3 ______________________________________________________________________ ______________________________________________________________________ EDID Block 1, Bytes 128-255 Block Type: CEA EDID Timing Extension 0 0 | 02 10 | 0E 20 | 03 30 | 38 40 | 00 50 | 20 60 | 9E 70 | 3E 80 | 1D 90 | 00 100 | 00 120 | 00 1 2 3 4 5 6 7 8 9 ________________________________________ 03 19 F1 46 90 04 05 07 03 23 09 07 07 83 01 00 00 65 0C 00 10 00 02 3A 80 18 71 2D 40 58 2C 45 00 51 73 21 00 1F 01 1D 80 18 71 1C 16 58 2C 25 00 51 73 21 00 00 8C 0A D0 8A 20 E0 2D 10 10 96 00 51 73 21 00 00 18 01 00 72 51 D0 1E 20 6E 28 55 51 73 21 00 00 1E 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 33
110 | 00 00 00 00 00 00 00 00 00 00 ______________________________________________________________________ (2)Detailed Timing Start at - 25 (3)DTV Supports Underscan, DTV Supports Basic Audio , DTV Supports YCbCr 4:4:4, DTV Supports YCbCr 4:2:2 , Native Format: 1 (4)Video Data Block/Short Video Descriptors, (5) (6) (7) (8) (9) (10) (12) (13) (14) 1920x1080p 59.94/60Hz 16:9 New 1280x720p 59.94/60Hz 16:9 861 1920x1080i 59.94/60Hz 16:9 861 720(1440)x480i 59.94/60Hz 16:9 New 720x480p 59.94/60Hz 16:9 861 640x480p 59.94/60Hz 4:3 861 Number of Data Byte to Follow: 3, Uncompressed Audio Channels: 2, Linear PCM (IEC60958) Sampling Frequency: 32KHz, 44.1KHz, 48KHz, Sampling bit rate: 16 bit, 20 bit, 24 bit, Number of Data Byte to Follow: 3
26 Confidential - Do Not Copy
ViewSonic Corporation
VX2835wm-1
FL/FR, Number of Data Byte to Follow: 5 Vendor IEEE Registration ID: 000C03 Hexadecimal Vendor Specific Data: 1000 Hexadecimal
______________________________________________________________________ (25-42) Detailed Timing / Descriptor Block 1: 1920x1080p Pixel Clock: 148.50 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Active Time: 1920 pixels Sync Offset: 88 pixels Border: 0 pixels Vertical: Active Time: 1080 lines Sync Offset: 4 lines Border: 0 lines Blanking Time: 45 lines Sync Pulse Width: 5 lines Frequency: 60.00 Hz Blanking Time: 280 pixels Sync Pulse Width: 44 pixels Frequency: 67.50 KHz Vertical Image Size: 371 mm Normal Display - No Stereo
Digital Separate, Horizontal Polarity (+) Vertical Polarity (+) ______________________________________________________________________ (43-60) Detailed Timing / Descriptor Block 2: 1920x1080i Pixel Clock: 74.25 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Interlaced Horizontal: Active Time: 1920 pixels Sync Offset: 88 pixels Border: 0 pixels Vertical: Active Time: 540 lines Sync Offset: 2 lines Border: 0 lines Blanking Time: 22 lines Sync Pulse Width: 5 lines Frequency: 60.05 Hz Blanking Time: 280 pixels Sync Pulse Width: 44 pixels Frequency: 33.75 KHz Vertical Image Size: 371 mm Normal Display - No Stereo
Digital Separate, Horizontal Polarity (+) Vertical Polarity (+) ______________________________________________________________________ (61-78) Detailed Timing / Descriptor Block 3: 720x480p Pixel Clock: 27.00 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Vertical Image Size: 371 mm Normal Display - No Stereo
ViewSonic Corporation
VX2835wm-1
Active Time: 720 pixels Sync Offset: 16 pixels Border: 0 pixels Vertical: Active Time: 480 lines Sync Offset: 9 lines Border: 0 lines
Blanking Time: 138 pixels Sync Pulse Width: 62 pixels Frequency: 31.47 KHz Blanking Time: 45 lines Sync Pulse Width: 6 lines Frequency: 59.94 Hz
Digital Separate, Horizontal Polarity (-) Vertical Polarity (-) ______________________________________________________________________ (79-96) Detailed Timing / Descriptor Block 4: 1280x720p Pixel Clock: 74.25 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Active Time: 1280 pixels Sync Offset: 110 pixels Border: 0 pixels Vertical: Active Time: 720 lines Sync Offset: 5 lines Border: 0 lines Blanking Time: 30 lines Sync Pulse Width: 5 lines Frequency: 60.00 Hz Blanking Time: 370 pixels Sync Pulse Width: 40 pixels Frequency: 45.00 KHz Vertical Image Size: 371 mm Normal Display - No Stereo
Digital Separate, Horizontal Polarity (+) Vertical Polarity (+) ______________________________________________________________________ (97-114) Detailed Timing / Descriptor Block 5: No Data: (115-126) No Data: (127) CheckSum OK
ViewSonic Corporation
VX2835wm-1
VX2835wm-E_HDMI Time: 17:19:17 Date: Wed Jan 17, 2007 ______________________________________________________________________ VIEWSONIC CORPORATION EDID Version # 1, Revision # 3 DDCTest For: ViewSonic VX2835wm ______________________________________________________________________ EDID Block 0, Bytes 0-127 128 BYTES OF EDID CODE: 0 0 | 00 10 | 1F 20 | 80 30 | 9F 40 | B3 50 | 81 60 | 23 70 | 00 80 | 30 90 | 00 100 | 00 1 2 3 4 5 6 7 8 9 ________________________________________ FF FF FF FF FF FF 00 5A 63 0F 01 01 01 01 01 11 01 03 3B 25 78 2E 9E 71 A6 54 4C 24 10 51 57 BF EF 80 D1 00 00 A9 40 95 00 90 40 81 80 40 71 4F 28 3C 80 A0 70 B0 40 30 20 36 00 51 73 21 00 1A 00 00 00 FF 00 51 46 47 37 30 31 30 30 30 30 31 0A 00 00 FD 00 32 4C 1E 52 11 0A 20 20 20 20 20 20 00 00
110 | 00 FC 00 56 58 32 38 33 35 77 120 | 6D 0A 20 20 20 20 01 4C ______________________________________________________________________ (08-09) ID Manufacturer Name ________________ = VSC (11-10) Product ID Code _____________________ = 0F1F (12-15) Last 5 Digits of Serial Number ______ = Not Used (16) (17) (18) (19) (20) Week of Manufacture _________________ = 01 Year of Manufacture _________________ = 2007 EDID Version Number _________________ = 1 EDID Revision Number ________________ = 3 VIDEO INPUT DEFINITION: Digital Signal Non - VESA DFP 1.x Compatible (21) (22) (23) (24) Maximum Horizontal Image Size ________________ Maximum Vertical Image Size __________________ Display Gamma ________________________________ Power Management and Supported Feature(s):
29 Confidential - Do Not Copy
ViewSonic Corporation
VX2835wm-1
Active Off/Very Low Power, Standard Default Color Space, Preferred Timing Mode Display Type = R/G/B Color (25-34) CHROMA INFO: Red X - 0.650 Green X - 0.300 Blue X - 0.142 White X - 0.316 Red Y - 0.329 Green Y - 0.623 Blue Y - 0.065 White Y - 0.341 (35) ESTABLISHED TIMING I: 720 X 400 @ 70Hz (IBM,VGA) 640 X 480 @ 60Hz (IBM,VGA) 640 X 480 @ 67Hz (Apple,Mac II) 640 X 480 @ 72Hz (VESA) 640 X 480 @ 75Hz (VESA) 800 X 600 @ 56Hz (VESA) 800 X 600 @ 60Hz (VESA) (36) ESTABLISHED TIMING II: 800 X 600 @ 72Hz (VESA) 800 X 600 @ 75Hz (VESA) 832 X 624 @ 75Hz (Apple,Mac II) 1024 X 768 @ 60Hz (VESA) 1024 X 768 @ 70Hz (VESA) 1024 X 768 @ 75Hz (VESA) 1280 X 1024 @ 75Hz (VESA) (37) Manufacturer's Reserved Timing: 1152 X 870 @ 75Hz (Apple,Mac II) (38-53) Standard Timing Identification: 1920 X 1200 @60Hz 1680 X 1050 @60Hz 1600 X 1200 @60Hz 1440 X 900 @60Hz 1400 X 1050 @60Hz 1280 X 1024 @60Hz 1280 X 960 @60Hz 1152 X 864 @75Hz ______________________________________________________________________ (54-71) Detailed Timing / Descriptor Block 1: 1920x1200 Pixel Clock: 154.00 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Active Time: 1920 pixels Sync Offset: 48 pixels Blanking Time: 160 pixels Sync Pulse Width: 32 pixels
30 Confidential - Do Not Copy
ViewSonic Corporation
VX2835wm-1
Border: 0 pixels Vertical: Active Time: 1200 lines Sync Offset: 3 lines Border: 0 lines
Frequency: 74.04 KHz Blanking Time: 35 lines Sync Pulse Width: 6 lines Frequency: 59.95 Hz
Digital Separate, Horizontal Polarity (+) Vertical Polarity (-) ______________________________________________________________________ (72-89) Detailed Timing / Descriptor Block 2: Monitor Serial Number: QFG070100001 ______________________________________________________________________ (90-107) Detailed Timing / Descriptor Block 3: Monitor Range Limits: Min Vertical Freq - 50 Hz Max Vertical Freq - 76 Hz Min Horiz. Freq - 30 KHz Max Horiz. Freq - 82 KHz Pixel Clock - 170 MHz Secondary GTF - Not Supported ______________________________________________________________________ (108-125) Detailed Timing / Descriptor Block 4: Monitor Name: VX2835wm (126) (127) Extension EDID Block(s): 1 CheckSum OK
ViewSonic Corporation
VX2835wm-1
Time: 17:19:17 Date: Wed Jan 17, 2007 ______________________________________________________________________ ______________________________________________________________________ VIEWSONIC CORPORATION EDID CEA-861B Timing Extension Version 3 ______________________________________________________________________ ______________________________________________________________________ EDID Block 1, Bytes 128-255 Block Type: CEA EDID Timing Extension 0 0 | 02 10 | 16 20 | 65 30 | 72 40 | 21 50 | 16 60 | 00 70 | B8 80 | 8C 90 | 55 100 | 00 120 | 00 1 2 3 4 5 6 7 8 9 ________________________________________ 03 1A F1 47 9F 14 13 12 1E 01 23 09 07 07 83 01 00 00 0C 03 00 10 00 02 3A 80 D0 38 2D 40 10 2C 45 80 51 73 00 00 1F 01 1D 80 D0 72 1C 20 10 2C 25 80 51 73 21 00 9E 01 1D 00 BC 52 D0 1E 20 28 55 40 51 73 21 00 00 1E 0A D0 90 20 40 31 20 0C 40 00 51 73 21 00 00 18 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 25
110 | 00 00 00 00 00 00 00 00 00 00 ______________________________________________________________________ (2)Detailed Timing Start at - 26 (3)DTV Supports Underscan, DTV Supports Basic Audio , DTV Supports YCbCr 4:4:4, DTV Supports YCbCr 4:2:2 , Native Format: 1 (4)Video Data Block/Short Video Descriptors, (5) (6) (7) (8) (9) (10) (11) (13) (14) (15) 1920x1080p 50Hz 16:9 New 1920x1080i 50Hz 16:9 861A 1280x720p 50Hz 16:9 861A 720x576p 50Hz 16:9 861A 1440x576p 50Hz 16:9 New 720(1440)x576i 50Hz 16:9 861A Optional 640x480p 59.94/60Hz 4:3 861 Number of Data Byte to Follow: 3, Uncompressed Audio Channels: 2, Linear PCM (IEC60958) Sampling Frequency: 32KHz, 44.1KHz, 48KHz, Sampling bit rate: 16 bit, 20 bit, 24 bit,
32 Confidential - Do Not Copy
Native
ViewSonic Corporation
VX2835wm-1
Vendor IEEE Registration ID: 00030C Hexadecimal Vendor Specific Data: 1000 Hexadecimal
______________________________________________________________________ (26-43) Detailed Timing / Descriptor Block 1: 1920x1080p Pixel Clock: 148.50 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Active Time: 1920 pixels Sync Offset: 528 pixels Border: 0 pixels Vertical: Active Time: 1080 lines Sync Offset: 4 lines Border: 0 lines Blanking Time: 45 lines Sync Pulse Width: 5 lines Frequency: 50.00 Hz Blanking Time: 720 pixels Sync Pulse Width: 44 pixels Frequency: 56.25 KHz Vertical Image Size: 371 mm Normal Display - No Stereo
Digital Separate, Horizontal Polarity (+) Vertical Polarity (+) ______________________________________________________________________ (44-61) Detailed Timing / Descriptor Block 2: 1920x1080i Pixel Clock: 74.25 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Interlaced Horizontal: Active Time: 1920 pixels Sync Offset: 528 pixels Border: 0 pixels Vertical: Active Time: 540 lines Sync Offset: 2 lines Border: 0 lines Blanking Time: 22 lines Sync Pulse Width: 5 lines Frequency: 50.04 Hz Blanking Time: 720 pixels Sync Pulse Width: 44 pixels Frequency: 28.13 KHz Vertical Image Size: 371 mm Normal Display - No Stereo
Digital Separate, Horizontal Polarity (+) Vertical Polarity (+) ______________________________________________________________________ (62-79) Detailed Timing / Descriptor Block 3: 1280x720p Pixel Clock: 74.25 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Vertical Image Size: 371 mm Normal Display - No Stereo
ViewSonic Corporation
VX2835wm-1
Active Time: 1280 pixels Sync Offset: 440 pixels Border: 0 pixels Vertical: Active Time: 720 lines Sync Offset: 5 lines Border: 0 lines
Blanking Time: 700 pixels Sync Pulse Width: 40 pixels Frequency: 37.50 KHz Blanking Time: 30 lines Sync Pulse Width: 5 lines Frequency: 50.00 Hz
Digital Separate, Horizontal Polarity (+) Vertical Polarity (+) ______________________________________________________________________ (80-97) Detailed Timing / Descriptor Block 4: 720x576p Pixel Clock: 27.00 MHz ______________________________________________________________________ Horizontal Image Size: 593 mm Refreshed Mode: Non-Interlaced Horizontal: Active Time: 720 pixels Sync Offset: 12 pixels Border: 0 pixels Vertical: Active Time: 576 lines Sync Offset: 5 lines Border: 0 lines Blanking Time: 49 lines Sync Pulse Width: 5 lines Frequency: 50.00 Hz Blanking Time: 144 pixels Sync Pulse Width: 64 pixels Frequency: 31.25 KHz Vertical Image Size: 371 mm Normal Display - No Stereo
Digital Separate, Horizontal Polarity (-) Vertical Polarity (-) ______________________________________________________________________ (98-115) Detailed Timing / Descriptor Block 5: No Data: (116-126) No Data: (127) CheckSum OK
ViewSonic Corporation
VX2835wm-1
REMARK: There may need manual adjustment of phase for optimized performance for various VGA tolerance. Contrast /Brightness: To adjust the Contrast and Brightness of the LCD monitor.
Input Select : toggles between inputs if you have more than one computer connected to the VX2835wm. Please press the power on/off key to restart monitor when changing the HDMI input device.
ViewSonic Corporation
VX2835wm-1
Audio Adjust : Volume increases the volume, decreases the volume, and mutes the audio. Adjust Base and Treble level. Balance adjust left and right speaker.
Color Adjust: Provides several selection on color adjustment, including preset color temperatures and a User Color mode which allows independent adjustment of red (R), green (G), and blue (B). The factory setting for this product is 6500K.
Information: displays the timing mode (video signal input) coming from the graphics card in the computer, the LCD model number, the serial number, and the ViewSonic website URL.
ViewSonic Corporation
VX2835wm-1
Manual Adjust : Horizontal Size: To adjust the horizontal pixel clock of the video. H./V. Position: To adjust the horizontal and vertical position of the video. Fine Tune: To adjust the delay time of data and clock. Sharpness: To select the picture sharpness of display. Tint : sharpens the focus by aligning text and/or graphics with pixel boundaries. Color : Adjusts the saturation level of image. (It's inactive in D-SUB mode only) Aspect Ratio : Selects the image size for 1:1, 4:3, 16:9 & full screen OptiColor Mode : provides an optimum display environment depending on the contents displayed. It contains 7 user-selectable presets. These 7 presets are easily accessible from the short cut keys OptiColor Skin Tone : includes 3 presets (Natural / Red Tone / Yellow Tone) which user can select according to user's preference. PIP : Auto detection when the display has several inputs.
(I)When the display power on, the auto detect priority shall be as following:
Display Power
No
Input
Yes
Yes
No
No
Input signal
End
Yes
Go to next input [Do not update the Last Active Input Display Update the Last Active Input (flag A)
End
ViewSonic Corporation
VX2835wm-1
II) When the active input is disconnected, the auto detect priority shall be as follows :
Disconnect
No
Input
Yes
Input signal
Yes No
No Over 5 Yes
End
End
Setup Menu::
Language Select: allows the user to choose the language used in the menus and control screens.
ViewSonic Corporation
VX2835wm-1
OSD Position: allows the user to move the OSD menus and control screen.
OSD Timeout: To set the displaying time of OSD menu in the screen.
Memory Recall: Restore default settings of Clock, H./V. Position, Phase, Contrast, Brightness, Color temperature, OSD position, OSD timeout and Sharpness, Volume.
ViewSonic Corporation
VX2835wm-1
4. Circuit Description
Internal Power Supply Input Voltage Range Input Frequency Range Short Circuit Protection Over Current Protection Leakage Current Efficiency Fuse Power Dissipation Max Input AC Current Inrush Current (Cold Start) Power Supply Cold Start Power Supply Transient Immunity Power Supply Line Surge Immunity Power Supply Missing Cycle Immunity Part Number: 71-Y2831200G001 AC90~264 (Worldwide) 47 to 64 Hertz Output can be shorted without damage 3.3~4.5A typ. at 5 VDC ( Protect when short circuit ) 3.5mA (Max) at 264VAC / 50Hz 80 % typical at 115VAC Full Load Internal and not user replaceable < 130 Watts (typ) 1.6A (max) 80 A Max./ 240VAC / 50Hz (Cold Start at 25,Full Load) Shall start and function properly when under full load, with all combinations of input voltage, input frequency, and operating temperature Shall be able to withstand an ANSI/IEEE C62.41-1980 6000V 200 ampere ring wave transient test with no damage Shall be able to withstand 1.5 times nominal line voltage for one cycle with no damage Shall be able to function properly, without reset or visible screen artifacts, when cycle of AC power is randomly missing at nominal input The power supply shall not produce audible noise that would be detectable Power Supply Acoustics by the user. Audible shall define to be in compliance with ISO 7779 (DIN EN27779:1991) Noise measurements of machines acoustics. Power Switch noise shall not be considered US Type Power Cable Color = Black European Type Power Cable Color = Black CCC Type Power Cable Color = Black PSE Type Power Cable Color = Black Power Saving Operation(Method) Separate 3-prong NEMA 5-15P type plug. Length = 1.8m. Connects to display. Schuko CEE7-7 type plug. Length = 1.8m, Connects to display. Separate 3-prong type plug. Length = 1.8m. Connects to display. Separate 2-prong NEMA 1-15P type plug. Length = 1.8m. Connects to display. VESA DPMS Signaling On Mode <60 W (Typ) / under 64W (Max for Energy Star) Max power output :130W(Max. @500nits) Power Consumption Saving Mode < 2 W@230VAC 50Hz Off Mode < 1 W @230VAC 50Hz (DC Power Off; Meet to Energy Star Ver4.0 Tier2) Recovery Time On Mode = N/A, Active Off < 3 sec
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
5.3 Function Test and Alignment Procedure 5.3.1 All Modes Reset You should do All Mode Reset first. This action will allow you to erase all end-users settings and restore the factory defaults. 5.3.2 Auto Image Adjust Please select and enter Auto Image Adjust function on Main Menu to see if it is workable. The Auto Image Adjust function is aimed to offer a better screen quality by built-in ASIC. For optimum screen quality, the user has to adjust each function manually. 5.3.3 Firmware Test Pattern: Burn In Mode (Refer to Chapter III-3. Hot Keys for Function Controls) - Make sure the F/W is the latest version. 5.3.4 DDC Test Pattern: EDID program - Make sure it can pass test program. 5.3.5 Fine Tune and Sharpness Test Signal: 1280*1024@60Hz Test Pattern: Line Moire Pattern - Check and see if the image has noise and focus performs well. Eliminate visual line bar. - If not, readjust by the following steps: (a) Select and enter Fine Tune function on Manual Image Adjust to adjust the image to eliminate visual wavy noise. (b) Then, select and enter Sharpness function to adjust the clarity and focus of the screen image. 5.3.6 Boundary Test Signal: 1280*1024@60Hz Test Pattern: Horizontal & Vertical Line Thickness Pattern - Check and see if the image boundary is within the screen frame. - If not, readjust by the following steps: (a) Select and enter Manual Image Adjust function on OSD Main Menu. (b) Then, select and enter Horizontal Size or Horizontal/Vertical Position function to adjust the video boundary to be full scanned and within screen frame. 5.3.7 White Balance Test Signal: 1280*1024@60Hz Test Pattern: White and Black Pattern
ViewSonic Corporation
VX2835wm-1
5.3.8 R, G, B, Colors Contrast Test Signal: 1280*1024@60Hz Test Pattern: R, G, B, Color Intensities Pattern and 16 Gray Scale Pattern - Check and see if each color is normal and distinguishable. - If not, please return the unit to repair area. 5.3.9 Screen Uniformity and Flicker Test Signal: 1280*1024@60Hz Test Pattern: Full White Pattern - Check and see if it is in normal condition. 5.3.10 Dead Pixel and Line Test Signal: 1280*1024@60Hz Test Pattern: Dark and White Screen Pattern - Check and see if there are dead pixels on LCD panel with shadow gauge and filter film. - The total numbers and distance of dead pixels should be compliant with the spec. 5.3.11 Mura Test Pattern: White, RGB, Black, & Grey Test Tool: 8% ND Filter - Check if the Mura can pass 8% ND Filter. 5.3.12 Audio Test Signal: Voice signal (optional, depend on model) Test Pattern: liberty - Make sure there is audio output. - Make sure that audio function (volume80%) is working without noise and resonance. - Make sure that the sound of right and left speakers are in balance. 5.3.13 Check for Secondary Display Modes Test Signal: Analog: 640*350@70Hz; 640*480@60HZ 720*400@70Hz; 800*600@60HZ/70HZ/75HZ 832*624@75Hz, 1024*768@60HZ/70HZ/75HZ 1280*1024@60/75Hz - Normally when the primary mode 1280*1024@60Hz is well adjusted and compliant with the specification, the secondary display modes will be great possible to be compliant with the spec. But we still have to check with the general test pattern to make sure every secondary is compliant with the specification.
ViewSonic Corporation
VX2835wm-1
5.3. 14 All Modes Reset After final QC step, we have to erase all saved changes again and restore the factory defaults. You should do All Mode Reset again. 5.3.15 Power Off Monitor Turn off the monitor by pressing Power button.
ISP connection
ViewSonic Corporation
VX2835wm-1
5.4.4
47
ViewSonic Corporation
VX2835wm-1
3. Click the connection icon and the LED should 4. 1. Mstar Chip set - Select 5151A series
turn to GREEN color ( means connected) 2. Debug Interace - Select COMPORT 3. COM Port - you need to check the assigned COM Port under Control Panel Device Manager Com Port 4. Com Port Protocol select TV
Start to do firmware BIN update 5. On the top menu, click VIEW Direct SPIU Flash Management 6. Click Load
48
ViewSonic Corporation
VX2835wm-1
7.
8.
9. Click RUN
49
ViewSonic Corporation
VX2835wm-1
Start to do firmware HEX update ( you need to follow set up procedure 1 to 4 before proceeding to this step ) 1. Click ISP, on the top menu, select configuration ISP Setting File Path of external ISP tool 2. Locate the file for 8051ISP writer
3. Select the correct chip (W79E632) and select the hex file.
50
ViewSonic Corporation
VX2835wm-1
7. Check the com port setting (Control PanelSystemDevice ManagerCOMP PORT. Click Connect Next Chip Click Program All
8. Program OK
- Done
51
ViewSonic Corporation
VX2835wm-1
5.5 .6
Note: 1. Every time after replacing the main board, you have to do the DDC key in. 2. If you find the DDC does not conform to the monitor, you have to do the DDC key in. Equipment Needed - VX2835 LCD Monitor - DDC Card - PC - RS232 cable - HDMI Cable
RS-232 Cable
VGA Cable
ViewSonic Corporation
VX2835wm-1
Step 1 : Select VX2835 on Working Model column to show EDID data on left
Step 2 : Modify the column of Week of Manufacture and Year of Manufacture and ID serial Number then press 2B button for changing serial number data.
ViewSonic Corporation
VX2835wm-1
2. Follow step 1, press both sides of the hinge cover, then proceed to step 2, pull out the left cover to remove.
3. Follow step 1, press both sides of the hinge cover, then proceed to step 2, pull out the right cover to remove.
ViewSonic Corporation
VX2835wm-1
4. Unfasten eight (8) screws ojn both sides of the ARM hinge.
5. Gently remove the base stand assembly to separate from the LCD monitor.
6. Unfasten seven (7) pcs screws on the back cover of the LCD monitor.
7. To remove the back cover, start from the lower left corner. Use a plastic tool ( flat) and insert on the opening on the lower left corner. Follow the number.
STEP 1
ViewSonic Corporation
VX2835wm-1
STEP 2
STEP 3
9. You can now remove the left speaker. Disconnect the speaker cable from the connector.
10. You can now remove the right speaker. Disconnect the speaker cable from the connector.
ViewSonic Corporation
VX2835wm-1
11. Remove the black insulation tape along the left, right and upper sides of the LCD panel.
ViewSonic Corporation
VX2835wm-1
15. Step 1 - Disconnect the cable from the connector. Step 2 - Gently lift up the shielding half way, and disconnect the cable underneath. To disconnect the cable, hold and press the end cable and gently pullout from the connector to disconnect.
16. Unfasten two (2) screws on the upper and bottom sides of the LCD module.
17. Release all the snap locks along the four sides of the LCD screen.
ViewSonic Corporation
VX2835wm-1
18. When removing the LCD module, you need to pull out both side at the same time to avoid any obstruction.
21. Unfasten all screws on the MB and Power Board and grounding.
ViewSonic Corporation
VX2835wm-1
NOTE :
23. The disassembly procedure is done. There might be some additional aluminum foils for EMI solution that are not shown in this procedure.
ViewSonic Corporation
VX2835wm-1
7
10
11
12
1 4
8 9
13
14
Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 VX2835wm-1
ViewSonic Corporation
NO POWER
YES
IS THERE A POWER ?
NO
NO
IS THERE A POWER ?
YES
END
ViewSonic Corporation
VX2835wm-1
NO DISPLAY
NO DISPLAY
1. Press power button 2. check sub-cable if connected properly 3. Check all cables inside the monitor
YES
IS THERE A DISPALY?
NO
Replace MB Board
YES
IS THERE A DISPLAY ?
NO
Replace Panel
NO
IS THERE A DISPLAY ?
YES
END
ViewSonic Corporation
VX2835wm-1
1. Check if sub-cable is OK and connected properly 3. Check all cables inside the monitor
YES
NO
Replace PANEL
NO
IS THERE A DISPLAY ?
YES
END
ViewSonic Corporation
VX2835wm-1
1. Check inverter cable if connected properly 2. Check for any damage on inverter cable
YES
Is display backlight ON ?
NO
YES
Is display backlight ON ?
NO
Replace Panel
NO
Is display backlight ON ?
YES
END
ViewSonic Corporation
VX2835wm-1
1. Check if sub-cable is OK and connected properly 3. Check all cables inside the monitor
YES
NO
Replace PANEL
NO
IS THE DISPALY GOOD ?
YES
END
ViewSonic Corporation
VX2835wm-1
NO AUDIO
NO Audio
1. Check if audio cable is connected properly 2. Check OSD and check if MUTE IS set to OFF or ON
YES
NO
NO
IS THE AUDIO GOOD ?
YES
END
ViewSonic Corporation
VX2835wm-1
R+-/G+-/B+-
DDCD 24C02
POWER
RGB I2C
7. Block Diagram
ViewSonic Corporation
DDCA 24C02
YPbPr
S/CVBS
LVDS Output
68
DDR EM6A9320
FLASH PM25LV010
MCU
W79E633A40
Audio S/W
MTS_O R/L
PT2134A
VX2835wm-1
Speaker
8. Schematic Diagrams
POWER
BL_EN
5V 3V3 AUDIO_12V
3V3 VCC_LCD
OUTPUT INTERFACE DDR FSADDR[0..11] /FSWE /FSCAS /FSRAS FSCKE FSBKSEL0 FSBKSEL1 FSCLK+ FSCLKFSDQM1 FSDQM0 FSDQS3 FSDQS2 FSDQS1 FSDQS0 FSDATAU[0..31] FSADDR[0..11] /FSWE /FSCAS /FSRAS FSCKE FSBKSEL0 FSBKSEL1 FSCLK+ FSCLKFSDQM1 FSDQM0 FSDQS3 FSDQS2 FSDQS1 FSDQS0 FSDATAU[0..31] FSADDR[0..11] /FSWE /FSCAS /FSRAS FSCKE FSBKSEL0 FSBKSEL1 FSCLK+ FSCLKFSDQM1 FSDQM0 FSDQS3 FSDQS2 FSDQS1 FSDQS0 FSDATAU[0..31] DDR MCU AUDIO MUTE# DCR IR_SW BL_EN PWR_EN 5151A_RST INT WR RD ALE AD[0..3] BLUE ORANGE AUDIO MUTE# DCR IR_SW BL_EN PWR_EN 5151A_RST INT WR RD ALE AD[0..3] BLUE ORANGE ST_DET HPDCTRL IR_CARD DDCCI_VGA_TXD DDCCI_VGA_RXD DVI_SCL DVI_SDA SCL_5V SDA_5V SCL_3V3 SDA_3V3 TX_SCL RX_SDA RESET# EAR_DET SPK_L+ SPK_LSPK_R+ SPK_RJP1 1 2 JP2 1 2 3 MCU SPK_L+ SPK_LPH_2 SPK_R+ NC SPK_R-
GNDD
Video Decoder
D[0..7] D_CLK
D[0..7] D_CLK
IR_CARD
LCD_PWR S_ADJ_PWM AUWS AUSCK AUSD AUMCK AUMUTE AUWS AUSCK AUSD AUMCK AUMUTE
ST_DET HPDCTRL IR_CARD DDCCI_VGA_TXD DDCCI_VGA_RXD DVI_SCL DVI_SDA SCL_5V SDA_5V SCL_3V3 SDA_3V3 TX_SCL RX_SDA RESET#
5V_STBY
5V 2V5_STBY
DDCCI_VGA_RXD DDCCI_VGA_TXD
DDCCI_VGA_RXD DDCCI_VGA_TXD
GNDD
INPUT INTERFACE
12V 5V AUDIO_5V
MTS_O_R MTS_O_L
MTS_O_R MTS_O_L
SPK_R-
PH_3
4 5 6
MTG1 ID3.5/OD7.0 4 5 6
MTG2 ID4.5/OD7.0
3 2 1
3 2 1
SCL_5V SDA_5V
AUDIO_5V 5V_STBY
7 8 9
4 5 6
MTG4 ID3.5/OD7.0 4 5 6
3 2 1
3 2 1
7 8 9 MTG6 ID4.5/OD8.0
ViewSonic Corporation
Model Title Date
7 8 9
GNDD
7 8 9
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
AUDIO_12V 10 AUDIO_12V 5V_STBY AUDIO_12V AUDIO_5V 3 AUDIO_5V GNDD 1 2 D15 MEZ05-9.1-D1/NC GNDD GNDD U1 TDA7297D 15 6 C3 0.1uF 2 + L40 10uH CHK_0403 C2 470uF/16V/NC ECD_D10_5 1 MTS_O_R C1 MTS_O_L C4 10uF 10uF
AUDIO_5V
AUDIO_5V
5,6,8,10,11 5V_STBY
R1 47k B
R2 47k C Q1 E MMBT3904L B
1,3,4,5,6,7,8,9,10,11,12
GNDD R3 OUT1+ OUT12 5 B1 B2 0 0 SPK_R+ SPK_R1 1 GNDD GNDD GNDD GNDD 47k R4 1k R5 47k R6 1k
VCC
R9 1K/NC 5V_STBY GNDD R339 8 AUDIO MUTE# AUDIO MUTE# R12 10K
R10 1K/NC
OUT2+ OUT2-
19 16
B3 B4
0 0 C7 C8 C9 C10
SPK_L+ SPK_L-
1 1
100pF 100pF 100pF 100pF GNDD STBY MUTE 10K/NC C12 C13 9 8 12 ST BY GND_AUDIO N.C MUTE SGND N.C N.C N.C N.C PW GND PW GND PW GND PW GND 1 10 11 20 sound_R sound_L R324 R325 0 0 R323 GNDD U2 2 GNDD 3 5 6 IN1IN1+ VOUT2 IN2+ IN21 0 C11 1 + 100uF/25V 2 ECD_D6.3_2.5 AUDIO_5V VDD 8 C14 0.1uF VSS 4 100uF/25V GNDD GNDD R326 0 1 + C16 2 ECD_D6.3_2.5 HP_L C15 10uF/16V HP_R
10uF/16V/NC 1uF
17 18
GNDD
0 13
3 4
10K B
R231
10K
MUTE
R17
R18
10K GNDD
10K GNDD GNDD 1K GNDD 8 EAR_DET HP_R EAR_DET HP_L R20 0 R21 R23 R25 R26 120k/NC H PLUG L NO PLUG C18 330pF C19 330pF 0 0 0 C20 C21 C22 1 4 3 2 1 5 B5 10pF/NC 10pF/NC 10pF/NC 0/R0805 B0805 2 Headphone_OUT CN1
R24
PT2308-S
OUT1
ViewSonic Corporation
Model Title Date
GNDD
GNDD GNDD
GNDD GNDD
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
12V
R314100
9V C337 D14 MEZ05-9.1-D1 U8 1 GNDD 11 RIN1 10 9 8 16 15 14 13 19 20 4 3 7 12 28 RIN2 RIN3 RIN4 LIN1 LIN2 LIN3 LIN4 BIN_L BOUT_L TREB_R TREB_L LOUD_R LOUD_L REF PT2134A OUT_R ROUT RIN LOUT LIN BOUT_R BIN_R DATA DGND AGND CLK 23 6 5 18 17 22 21 26 27 C290 C292 C287 C284 C41 10uF MTS_O_R 2 C322 100uF/25V ECD_D6.3_2.5 GNDD 0.1uF GNDD C338 10uF GNDD 5V R28333/NC U34 MM1117STA 3 10uF MTS_O_L 2 C321 0.1uF 1 VIN ADJ VOUT1 VOUT2 2 4 R274 220 GNDD R275 1.2K
12V R273100
7 7 5
R232 R233 R234 HDMI_R R235 R236 R237 R238 HDMI_L R239
2.2uF 2.2uF 2.2uF 2.2uF 2.2uF 2.2uF 2.2uF 2.2uF 0.1uF 0.1uF
VDD
AUDIO_5V
OUT_L
24
C37
7 7 5
2.2uF
2.2uF
GNDD GNDD
R240
5.6K
0.1uF 0.1uF
R242 R243
33 33
C291
R241
5.6K
C297
25
C298 2 22pF
22uF
GNDD
GNDD
GNDD
7,8,9,10,11,12 5V 2 U5 1,2,4,5,6,7,8,9,10,11,12 11 11 11 11 AUMUTE AUSCK AUSD AUWS R271 R47 AUSCK AUSD AUWS NC
0
AUDIO_5V GNDD
0 0 0 0 0 0
1 2 3 15 14 13 16 12
VOUT/L
R224
HDMI_L GNDD
VOUT/R
R225
HDMI_R
11
AUMCK
AUMCK
R49
C273 C274 NC NC
11 10
GNDD
GNDD
ViewSonic Corporation
Model Title Date
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
2V5_DMQ 2V5_STBY L41 600Z/100MHz L0805 C52 47uF/25V ECD_D5_2 2V5_STBY L42 2V5_DMC 600Z/100MHz L0805 C65 47uF/25V ECD_D5_2
C53 0.1uF
C54 0.1uF
C55 0.1uF
C56 0.1uF
C57 0.1uF
C58 0.1uF
C59 0.1uF
C60 0.1uF
C61 0.1uF
C62 0.1uF
C63 0.1uF
C66 0.1uF
C67 0.1uF
C68 0.1uF
C69 0.1uF
C70 0.1uF
GNDD
GNDD 2V5_DMC
FSVREF
U9
FSDATA[0..31]
VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ VDDQ
FSADDR0 FSADDR1 FSADDR2 FSADDR3 FSADDR4 FSADDR5 FSADDR6 FSADDR7 FSADDR8 FSADDR9 FSADDR10 FSADDR11 FSBKSEL0 FSBKSEL1 FSCLKFSCLK+ FSCKE /FSRAS /FSCAS /FSWE 33 33 33 33 33 33 33 33
A0 A1 A2 A3 A4 A5 A6 A7 A8/AP A9 A10 A11 BA0 BA1 CK# CK CKE CS# RAS# CAS# WE# DQS0 DQS1 DQS2 DQS3 DM0 DM1 DM2 DM3
DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 DQ16 DQ17 DQ18 DQ19 DQ20 DQ21 DQ22 DQ23 DQ24 DQ25 DQ26 DQ27 DQ28 DQ29 DQ30 DQ31 VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ VSSQ
A6 B5 A5 A4 B1 C2 C1 D1 J12 J11 H12 H11 F12 F11 E12 E11 E2 E1 F2 F1 H2 H1 J1 J2 D12 C12 C11 B12 A9 A8 B8 A7 A3 A10 C3 C4 C5 C8 C9 C10 D5 D8 E4 E9 F4 F9 G4 G9 H4 H9 J4 J9
FSDATA0 FSDATA1 FSDATA2 FSDATA3 FSDATA4 FSDATA5 FSDATA6 FSDATA7 FSDATA16 FSDATA17 FSDATA18 FSDATA19 FSDATA20 FSDATA21 FSDATA22 FSDATA23 FSDATA8 FSDATA9 FSDATA10 FSDATA11 FSDATA12 FSDATA13 FSDATA14 FSDATA15 FSDATA24 FSDATA25 FSDATA26 FSDATA27 FSDATA28 FSDATA29 FSDATA30 FSDATA31
RP1
4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1
5 33FSDATAU0 FSDATAU1 6 FSDATAU2 7 FSDATAU3 8 5 33FSDATAU4 FSDATAU5 6 FSDATAU6 7 FSDATAU7 8 5 33FSDATAU8 FSDATAU9 6 FSDATAU10 7 FSDATAU11 8 5 33FSDATAU12 FSDATAU13 6 FSDATAU14 7 FSDATAU15 8 5 33FSDATAU16 FSDATAU17 6 FSDATAU18 7 FSDATAU19 8 5 33FSDATAU20 FSDATAU21 6 FSDATAU22 7 FSDATAU23 8 5 33FSDATAU24 FSDATAU25 6 FSDATAU26 7 FSDATAU27 8 5 33FSDATAU28 FSDATAU29 6 FSDATAU30 7 FSDATAU31 8 FSDATAU0 FSDATAU1 FSDATAU2 FSDATAU3 FSDATAU4 FSDATAU5 FSDATAU6 FSDATAU7 FSDATAU8 FSDATAU9 FSDATAU10 FSDATAU11 FSDATAU12 FSDATAU13 FSDATAU14 FSDATAU15 FSDATAU16 FSDATAU17 FSDATAU18 FSDATAU19 FSDATAU20 FSDATAU21 FSDATAU22 FSDATAU23 FSDATAU24 FSDATAU25 FSDATAU26 FSDATAU27 FSDATAU28 FSDATAU29 FSDATAU30 FSDATAU31
FSDATAU[0..31]
FSDATAU[0..31]
11
RP2
FSDATA8 RP3 FSDATA9 FSDATA10 FSDATA11 FSDATA12 RP4 FSDATA13 FSDATA14 FSDATA15 FSDATA16 RP5 FSDATA17 FSDATA18 FSDATA19 FSDATA20 RP6 FSDATA21 FSDATA22 FSDATA23 FSDATA24 RP7 FSDATA25 FSDATA26 FSDATA27 FSDATA28 RP8 FSDATA29 FSDATA30 FSDATA31
2V5_DMQ
NC NC NC NC NC NC NC NC NC NC NC NC VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS
1K
D4 D6 D7 D9 E5 E6 E7 E8 F5 F6 F7 F8 G5 G6 G7 G8 H5 H6 H7 H8 J5 J6 J7 J8 K4 K9
GNDD
ViewSonic Corporation
GNDD
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
VGA_TX
11 12 13
14 15 DSUB-15
J1 1 6 2 7 3 8 4 9 5 10
33 33 33 470
11 11 11 11
75 75 75
REDGREENBLUE-
11 11 11
GNDD
GNDD
D5 MLL5232B 5.6V
D6 MLL5232B 5.6V
R82
100R
ST_DET
ST_DET
14
GNDD GNDD
U36A 2 74LVC14/NC 3
14
U36B 4 74LVC14/NC
R83
100/NC
R294
22/NC
HS_RGB
HS_RGB
11
C267
68pF
GNDD
7 U36C 6 74LVC14/NC 7 9
14
U36D 8
VSI 5V_STBY D7 MLL5232B 5.6V D9 GNDD VGA5V BAT54C C80 0.1uF/16V 1 2 3 4 GNDD U10 NC NC NC GND 24C02 VCC VCLK SCL SDA 8 7 6 5 R244 10K GNDD R94 100R R95 100R D8 MLL5232B 5.6V R86 10K
R85
R296
22/NC
VS_RGB
VS_RGB
11
5V_STBY
R88 4.7K
R87 4.7K
DDCCI_VGA_TXD 8 DDCCI_VGA_RXD 8
74LVC14/NC
C268
68pF
GNDD
C335 C336
VGA_TX VGA_RX
R335 R336
0 0
TX_SCL RX_SDA
TX_SCL RX_SDA
8 8
GNDD J2 4 3 2 1 5 1 R100 47K R101 47K C83 330pF C84 330pF R97 R99 1K 1K PC_R PC_L PC_R PC_L 3 3
GNDD
GNDD
GNDD
GNDD
GNDD
ViewSonic Corporation
Model Title Date
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
1,2,3,4,5,7,8,9,10,11,12 J3 GND GND GND GND +5V CEC/DDC GND DDC SCL DDC SDA CEC HPD Dat2 shield Dat1 shield Dat0 shield clk shield DAT0+ DAT0DAT1+ DAT1DAT2+ DAT2-
D10 BAT54C R104 R105 10K 1K R102 10K R106 10K GNDD R107 R108 0 0 8 7 6 5 R103 NC U11 VCC WP SCL SDA 24C02 NC NC NC GND 1 2 3 4 HD_+5V
HD5V
GNDD
DDC_SDA R109 DDC_SCL R110 R111 R112 R113 R114 R115 R116
5,8,11 5,8,11 11 11 11 11 11 11
10 12
RXC+ RXC-
R117 R118
10R 10R
DVI_CK+ DVI_CK-
DVI_CK+ DVI_CK-
11 11
U12 HD_+5V RXCRXC+ RX0RX0+ RX1RX1+ RX2RX2+ DDC_SCL DDC_SDA HPD GNDD 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 5V_SUPPLY NC LV_SUPPLY ESD_BYP GND GND TMDS_D2+ TMDS_D2+ TMDS_GND TMDS_GND TMDS_D2TMDS_D2TMDS_D1+ TMDS_D1+ TMDS_GND TMDS_GND TMDS_D1TMDS_D1TMDS_D0+ TMDS_D0+ TMDS_GND TMDS_GND TMDS_D0TMDS_D0TMDS_CK+ TMDS_CK+ TMDS_GND TMDS_GND TMDS_CKTMDS_CKCE_REMOTE_IN CE_REMOTE_OUT DDC_CLK_IN DDC_CLK_OUT DDC_DAT_IN DDC_DAT_OUT HOTPLUG_DET_IN HOTPLUG_DET_OUT CM2021 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 C86 0.1uF RXCRXC+ RX0RX0+ RX1RX1+ RX2RX2+ DDC_CLK_IN DDC_DAT_IN HPD_IN GNDD GNDD HPD C E QA1 B R119 MMBT3904 4.7K HPDCTRL 8
R120
R121R122
GNDD
ViewSonic Corporation
Model Title Date
IC
ViewSonic Corporation
74
CONNECTOR
VX2835wm-1
SCALER
Rev:
L52 L53
0 0 0
5V
3,8,9,10,11,12 5V 12 1,2,3,4,5,6,8,9,10,11,12 P_A3.3V GNDD
L39
P_A3.3V
A_GNDD
GNDD
CON2 1 2 5V GNDD
GNDD
CON2
CARD SLOT
5V
IR_CARD 8 R249 R250 0/NC 0
Close Scalar
R123 L3 1 D11 V100K_V05/NC 0 R124 C89 75 R126 0 A_GNDD R127 C92 75 R129 0 A_GNDD R130 C95 75 R132 75 C96 47nF PR33 C94 47nF PR+ PR+ 11 75 C93 47nF PB33 C91 47nF PB+ PB+ 11 75 C90 47nF Y470 33 C87 C88 1nF 47nF SOG_Y Y+ SOG_Y Y+ 11
CON3 1 2 3 CON3 GNDD 11 CON4 1 2 3 4 5 6 7 CON7 PB11 C301 C302 C303 22pF IR_CARD
P_A3.3V
R125 33pF
0 0 80ohm/100MHz 80ohm/100MHz C305 22pF C306 22pF C307 470pF C308 470pF
CARD_SY 12 CARD_SC 12
Y-
11
2 A_GNDD 1 D12
A_GNDD L4 R128
V100K_V05/NC 33pF 2
C304 22pF
R251 R252 75 75
22pF/NC 22pF/NC
CN2 RJ-1182Q 16
A_GNDD 1 D13
A_GNDD L5 R131
GNDD
GNDD
GNDD
Pr
2
V100K_V05/NC 33pF
PR-
11
A_GNDD Y 15
oo oo
A_GNDD L6 80z/100MHz
A_GNDD
12
AV2_SY
12
Pb
L7 C 13
80z/100MHz AV2_SC 12
L8
80z/100MHz AV2_CVBS 12
R220 R221
0 0
AV
C97 C98 C99 22pF/NC 22pF/NC 22pF/NC
C100 22pF
U27
GNDD
GNDD
AOUT
Y/C_L
Y/C_L
R
C275 C276 NC
L9 L10
80ohm/100MHz
CARD_R C266
BOUT
Y/C_R
Y/C_R
80ohm/100MHz
P_A3.3V
VCC GND 10 5 GNDD
C103 470pF
NC 2 GNDD A_GNDD
IR_SW
R278
0 R279
8 7 NC
1 4 7 10 11 14
GNDD L11 L12 80ohm/100MHz 80ohm/100MHz C105 470pF Y/Pb/Pr_L Y/Pb/Pr_R C106 470pF
Y/Pb/Pr_L 3 Y/Pb/Pr_R 3
GNDD
C277 NC
C278 NC
ViewSonic Corporation
Model Title Date
GNDD
GNDD
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
5V
5V_STBY 5V_STBY 5 6 7 8 RP9 10Kx4 4 3 2 1 4 3 2 1 5 6 7 8 RP10 10Kx4 L AD0 AD1 AD2 AD3 AD[0..3] 11 L AUDIO_MUTE (F/W) H H EAR_DET(H/W) AUDIO_MUTE#
H(OFF) L(ON) L(ON) L(ON) NC 4 5 3 5V_STBY C111 0.1uF GNDD AUDIO MUTE# 2
C108 0.1uF C109 22pF EA/VP 35 Y1 24.576MHz C110 22pF GNDD INT IR_IN UCLK 21 20 10 14 15 16 17 2 3 4 5 6 7 8 9 1 12 GNDD P0.0 P0.1 P0.2 P0.3 P0.4 P0.5 P0.6 P0.7 P2.0 P2.1 P2.2 P2.3 P2.4 P2.5 P2.6 P2.7 RD/P3.7 WR/P3.6 PSEN ALE/P P4.0 P4.1 GND TXD/P3.1 RXD/P3.0 43 42 41 40 39 38 37 36 24 25 26 27 28 29 30 31 19 18 32 33 23 34 13 11 TXD RXD
EA/VP X1 X2 RESET INT0/P3.2 INT1/P3.3 T0/P3.4 T1/P3.5 P1.0 P1.1 P1.2 P1.3 P1.4 P1.5 P1.6 P1.7 P4.2 P4.3/ISP 80C51_PLCC
1,2,3,4,5,6,7,9,10,11,12
GNDD GNDD
VCC
8.2K
U13
44
9,10,12
3V3
R137
GNDD
R315
0 DDC_SW
11
INT
Debug port
5V_STBY CON1 RXD TXD 1 2 3 4 HEADER4X1 Debug port Pitch 2.54mm 9 11 10 10 6 5 DCR ST_DET AUDIO_MUTE Skin Tone
R253 33 SCL_5V SDA_5V R257 R259 R340 R144 R260 R147 R148 R149 33 33 33 33 33 33 33 33
R299 R300
DDCCI_VGA_TXD 5 DDCCI_VGA_RXD 5
R350 U37
0/NC FSA4157 B1 1
DDCCI_SCL 5V_STBY
4 5 2
B0 S
3 6 DDC_SW
R329
0 DVI_SCL
DVI_SCL
5,6,11
GNDD
5V_STBY POWER
22
GNDD
0/NC
5V 5V_STBY 3V3 R347 R348 R156 3K3 12 SDA_3V3 R157 3K3 G S Q4 D 2N7002 3V3 Q6 D D Q7 D Q5 G S 2N7002 2 0 1 1 0/NC
GNDD
10K/NC 10K/NC
5V_STBY
4 5 2
B1
B0 S
3 6 DDC_SW
R330
0 DVI_SDA
DVI_SDA
5,6,11
R158 4.7K 2
3V3 3V3 C112 0.1uF GNDD RESET# R160 GNDD 100K GNDD GNDD C309 RESET# 12 0.1uF 10K 8 7 3 4 R261 U29
GNDD
5V_STBY U35 PM25LV010 SDO 2 CE# 1 SCK 6 SDI 5 1 2 3 4 8 7 6 5 C310 0.1uF VCC WP SCL SDA GNDD R263 R264 100R 100R SCL_5V SDA_5V
GND
2N7002
AAT3522GY-3.08-200-T1 SOT_23_123
A0 A1 A2 GND 24C32
GNDD
GNDD
CON5 1 2 3 4 5 6 7 8 9 10 11 12 CON12
GNDD R284 R285 R286 R287 R288 R289 R290 R291 R292 5V_STBY
0 0 0 0 0 0 0 0 0
GNDD
BLUE 11 ORANGE 11
CON6 1 2 3 4 5 6 7 8 CON8 GNDD 5V_STBY U30 R297 5V_STBY 5V IR_IN 5V_STBY 4 5 2 A VCC GND FSA4157 GNDD 5V_STBY GNDD B1 1 0 IR_CARD IR_CARD 7
B0 S
3 6 IR_SW IR_SW 11
R298 NC
USB POWER
C324 0.1uF
C325 0.1uF
C326 0.1uF
C327 0.1uF
C328 0.1uF
C329 0.1uF
C330 0.1uF
C331 0.1uF
IR SW-->HI(CARD)
R322 U28 4.7K NC NC NC GND 1 2 3 4 GNDD
IR SWITCH
GNDD
SCL_5V SDA_5V
R312
100R
R313 100R
ViewSonic Corporation
Model Title Date
HDMI EDID
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
R173 NC
R174 NC PWM
R175 NC
R176 NC
RXE0RXE0+ RXE1RXE1+ RXE2RXE2+ RXECRXEC+ RXE3RXE3+ RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ RXOCRXOC+ RXO3RXO3+
RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ RXE0+ RXE1+ RXE2+ RXEC+ RXE3+
RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ RXE0+ RXE1+ RXE2+ RXEC+ RXE3+
11 11 11 11 11 11 11 11 11 11
GNDD
GNDD
5V R341 U42 B1 1 P_ADJ_PWM R342 1K/NC R343 C341 0.1uF/NC 0/NC C E MMBT3904L/NC GNDD Q19 B 47K/NC PWM
32 31 GNDD GNDD
Model Title Date
30
10
ADJ_PWM 4 5 2
5V
A VCC GND
B0 S
3 6 DCR
S_ADJ_PWM 11 DCR 8
ADJ_PWM
R344
S_ADJ_PWM
ViewSonic Corporation
SCALER
ViewSonic Corporation
VX2835wm-1
5V Q14 VCC_LCD 9 VCC_LCD AUDIO_12V 2 AUDIO_12V 12V 3 12V 5V 0.1uF 3,7,8,9,11,12 5V 5V_STBY 2,5,6,8,11 5V_STBY GNDD J4 3 2 1 1 2 3 4 S S S G D D D D 8 7 6 5 3 C124 470uF/16V VCC_LCD 1 C128 S Q10 G AOS3401 D GNDD 2 C125 0.1uF 1 U16 AIC1084-ADJ VIN GND 1 R177 100R VOUT0 2
3V3
FDS4435
5V 12V
3 2 1
+ 1
C127 0.1uF
R178 10K 2
R179 165R
R180 10K 3V3 R181 6.8K G 1 Q11 D S 2N7002 C130 10uF GNDD GNDD R182 0 2
C129 100uF/25V
C269 0.1uF
GNDD
8,9,12
3V3
11
LCD_PWR
LCD_PWR
1,2,3,4,5,6,7,8,9,11,12
GNDD
GNDD
GNDD
ECD_D6.3_2.5
GNDD
12V JP3 1 2 3 4 5 6 7 8 9 10 11 COND_H_2.5_11 GNDD 12V_IN L13 CHOKE 5V_STBY L14 5V_STBY_IN L15 5V_IN CHOKE CHOKE 5V 5V_STBY 5V_STBY R280 20K R184 10K C E GNDD Q12 B MMBT3904 GNDD GNDD R185 4.7K PWR_EN 8 R281 68K 12V R349 S Q15 G AOS3401 0/NC D AUDIO_12V
R183 GNDD_IN L16 CHOKE C132 0.1uF C270 C271 C272 10K PWR_O
C B E
PWR_O R282 0 G Q16 D S 2N7002
CN5
GND GND BL_EN BL_PWM
1 2 3 4
2 GNDD
R186 R187
0 0
BL_EN ADJ_PWM
BL_EN 8 ADJ_PWM 9
C134 NC
GNDD
ViewSonic Corporation
Model Title Date
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
L17
5V_STBY U41 AIC1084-ADJ 3 1 C148 C147 100uF/25V ECD_D6.3_2.5 0.1uF 2 VIN GND 1 R331 100R VOUT0 2 L20 0 C141 47uF/25V ECD_D5_2
pin12
C138 0.1uF
pin162,pin182
VDDC
C136 0.1uF
C142 0.1uF
C143 0.1uF
C161 0.1uF
C162 0.1uF
C163 0.1uF
C164 0.1uF
C165 0.1uF
C166 0.1uF
C167 0.1uF
GNDD GNDD 5V
GNDD
+3.3DV2
GNDD
pin63,pin79,pin131, pin156,pin173,pin185,pin195
GNDD GNDD
GNDD GNDD
pin66
C156 0.1uF
5V_STBY L55 +3.3DV1 L56 R307 LED_B 10K B E Q17 C MMBT3906 R308 680 BLUE C176 100uF/25V ECD_D6.3_2.5 BLUE 8 GNDD GNDD R277 100R R309 B 10K E Q18 C MMBT3906 R310 680 ORANGE AVDDA AVDD_DVI VDD_MPLL +3.3DV2 +3.3DV1 +2.5MVDD GNDD L0805 L0805 0 C175 0.1uF 3 1 VIN ADJ VOUT1 VOUT2 2 4 R276 100R L49 L0805 0 0/NC U33 MM1117STA 2V5_STBY +2.5MVDD
GNDD GNDD L48 0 L0805 C312 47uF/25V ECD_D5_2 U40 3 VIN ADJ/GND ME1117DT18 TO-252 VOUT 2 1
1V8
L21
L24
pin109
C159 0.1uF
C169 0.1uF
C170 0.1uF
C171 0.1uF
C172 0.1uF
C173 0.1uF
C174 0.1uF
C154 0.1uF
0.1uF
pin49
GNDD VDD_MPLL
GNDD
3V3AVDD
L27
pin204
C178 0.1uF
+3.3DV1
LED_A
GNDD AUMUTE AUWS AUSCK AUSD AUMCK 199 198 197 196 193 192 191 190 189 188
GNDD AUMUTE AUWS AUSCK AUSD AUMCK 3 3 3 3 3 3V3AVDD L28 0 C179 47uF/25V ECD_D5_2
AVDDA
204
66 162 182
109
17 34
4 10
49
12
pin17,pin34
AVDD_ADC AVDD_ADC
AVDD_DVI AVDD_DVI
AVDD_MPLL
AVDD_APLL
AVDD_PLL2
AVDD_PLL
AIWS AISCK AISD SIMCK SPDIFO AUMUTE AUWS AUSCK AUSD AUMCK
C180 0.1uF
C181 0.1uF
HHDMI
6 DVI_R+ 6 DVI_R6 DVI_G+ 6 DVI_G6 DVI_B+ 6 DVI_B6 DVI_CK+ 6 DVI_CKR188 390 AVDD_DVI DVI_SDA 5,6,8 DVI_SDA DVI_SCL 5,6,8 DVI_SCL 5 5 5 5 5 5 5 5 5 7 7 7 7 7 7 7 HS_RGB VS_RGB BLUE+ BLUESOG GREEN+ GREENRED+ REDPBPB+ YY+ SOG_Y PRPR+
DVI_R+ DVI_RDVI_G+ DVI_GDVI_B+ DVI_BDVI_CK+ DVI_CKR189 R190 HS_RGB VS_RGB BLUE+ BLUESOG GREEN+ GREENRED+ REDPBPB+ YY+ SOG_Y PRPR+ C185 0.1uF C186 0.1uF 0 0
DVI_R+ DVI_RDVI_G+ DVI_GDVI_B+ DVI_BDVI_CK+ DVI_CKREXT DDCD_DA DDCD_CK HSYNC1 VSYNC1 BIN1 BIN1M SOGIN1 GIN1 GIN1M RIN1 RIN1M BIN0M BIN0 GIN0M GIN0 SOGIN0 RIN0M RIN0 HSYNC0 VSYNC0 RMID REFP REFM VI_DATA[8] VI_DATA[9] VI_DATA[10] VI_DATA[11] VI_DATA[12] VI_DATA[13] VI_DATA[14] VI_DATA[15] GPIO[5]/VHS GPIO[4]/VCLK2 VI_CK VI_DATA[0] VI_DATA[1] VI_DATA[2] VI_DATA[3] VI_DATA[4] VI_DATA[5] VI_DATA[6] VI_DATA[7] GPIO[2]/VVS HWRESET INT ALE RDZ WRZ DBUS[0] DBUS[1] DBUS[2] DBUS[3] PWM0 PWM1 VCTRL BYPASS GPIO[3]/VDE GPIO[1]/FIELD XOUT
5V
PC
3,7,8,9,10,12 5V 5V_STBY 2V5_STBY 2,5,6,8,10 5V_STBY 4 2V5_STBY
LVB0M LVB0P LVB1M LVB1P LVB2M LVB2P LVBCKM LVBCKP LVB3M LVB3P LVA0M LVA0P LVA1M LVA1P LVA2M LVA2P LVACKM LVACKP LVA3M LVA3P
187 186 181 180 179 178 177 176 175 174 171 170 169 168 167 166 165 164 161 160 153 152 151 150 149 148 147 146 145 144 143 142 141 138 137 136 135 134 133 101 100 99 98 97 96 95 94 93 92 91 90 89 88 85 84 83 82 81 130 129 128 127 124 123 122 121 120 119 118 117 116 115 112 111 110 107 106 105 104
RXE0RXE0+ RXE1RXE1+ RXE2RXE2+ RXECRXEC+ RXE3RXE3+ RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ RXOCRXOC+ RXO3RXO3+ FSDQS0 FSDATAU0 FSDATAU1 FSDATAU2 FSDATAU3 FSDATAU4 FSDATAU5 FSDATAU6 FSDATAU7 FSDATAU8 FSDATAU9 FSDATAU10 FSDATAU11 FSDATAU12 FSDATAU13 FSDATAU14 FSDATAU15 FSDQS1 FSDQM0U R191 FSDQM1U R192 FSDQS2 FSDATAU16 FSDATAU17 FSDATAU18 FSDATAU19 FSDATAU20 FSDATAU21 FSDATAU22 FSDATAU23 FSDATAU24 FSDATAU25 FSDATAU26 FSDATAU27 FSDATAU28 FSDATAU29 FSDATAU30 FSDATAU31 FSDQS3U FSADDR11 FSADDR10 FSADDR9 FSADDR8 FSADDR7 FSADDR6 FSADDR5 FSADDR4 FSADDR3 FSADDR2 FSADDR1 FSADDR0 R226 R227 R228 R229 R230 0 0 0 0 0 FSCLK+ FSCLKFSCKE MVref MVref
RXE0RXE0+ RXE1RXE1+ RXE2RXE2+ RXECRXEC+ RXE3RXE3+ RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ RXOCRXOC+ RXO3RXO3+ FSDQS0
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 4
GNDD
AVDD_DVI
3V3AVDD
L29
0 C183 0.1uF
pin4,pin10
C184 0.1uF
GNDD
FSDATAU[0..31]
FSDATAU[0..31]
U21A
MST5251A
1,2,3,4,5,6,7,8,9,10,12
GNDD GNDD
Y/Pb/Pr
GNDD
12 12
D[0..7] D_CLK
D[0..7]
D0 D1 D2 D3 D4 D5 D6 D7 LED_A D_CLK
LED_B 8 5151A_RST R195 100R C189 0.1uF 8 8 8 GNDD 8 INT ALE RD WR INT ALE RD WR AD0 AD1 AD2 AD3 47K 100/NC 0.1uF IR_SW LCD_PWR
AD[0..3] 5V
AD[0..3]
R196 R197 R198 1K 9 S_ADJ_PWM S_ADJ_PWM R199 C191 0.1uF MMBT3904L GNDD GNDD C193 GNDD 18pF 0 C E GNDD Q13 B 7,8 10 IR_SW LCD_PWR C192 18pF C190
DQS[0] MDATA[0] MDATA[1] MDATA[2] MDATA[3] MDATA[4] MDATA[5] MDATA[6] MDATA[7] MDATA[8] MDATA[9] MDATA[10] MDATA[11] MDATA[12] MDATA[13] MDATA[14] MDATA[15] DQS[1] DQM[0] DQM[1] DQS[2] MDATA[16] MDATA[17] MDATA[18] MDATA[19] MDATA[20] MDATA[21] MDATA[22] MDATA[23] MDATA[24] MDATA[25] MDATA[26] MDATA[27] MDATA[28] MDATA[29] MDATA[30] MDATA[31] DQS[3] MADR[11] MADR[10] MADR[9] MADR[8] MADR[7] MADR[6] MADR[5] MADR[4] MADR[3] MADR[2] MADR[1] MADR[0] WEZ CASZ RASZ BADR[0] BADR[1] MCLK MCLKZ MCLKE MVREF
33 33
4 4 4 4
+2.5MVDD
FSDQS3
4 GNDD
Unloaded trace impedance on this interface is 90 Ohm Loaded trace impedace with DRAM load is 65 Ohm (for 2.5 inch total trace length)
FSADDR[0..11]
ViewSonic Corporation
Model Title
1 7 13 16 35 50 64 65 80 87 103 108 114 126 132 140 155 157 159 163 172 183 184 194 205 206
GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND
SCALER
Rev:
GNDD
Date
ViewSonic Corporation
VX2835wm-1
L31
10uH
CHK_0403 C204 47uF/25V ECD_D5_2
P_A3.3V
3V3
U22 2 VIN
L30
10uH
P_A1.8V
CHK_0403 + C198 100uF/25V 2 C206 0.1uF + C199 C200 C201 C202 C203
C208 0.1uF
C194
C195
C196
+ C197
C205
0.1uF/16V0.1uF/16V 0.1uF/16V
2
GNDD GNDD GNDD GNDD
25
125
GNDD L32
100uF/25V 0.1uF
GNDD
11
13
16
123
10uH
P_D1.8V
CHK_0403 C215 5V 3V3 3,7,8,9,10,11 8,9,10 7 3V3 P_A3.3V C216 22pF 14.318MHz GNDD R200 100K 5V GNDD P_A3.3V
C209
C210
C211
C212
C213
C214
33
47
65
85
99
111
1,2,3,4,5,6,7,8,9,10,11
GNDD X2 GNDD
C217 22pF
P_A1.8V
P_A3.3V
GNDD
P_D3.3V P_D1.8V
R352
10K
GNDD
AV2_SY
1.8uH
C219 220pF GNDD C220 220pF GNDD C221 5.6pF L34 U24 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 108 107 106 105 104 103 102 101 100 99 98 97 R202 75
A33GND ANALOG_OUT A33GND A33VDD PLL18GND PLL18VDD XTAL2 XTAL1 D18DGND FSS VS/VBLK/GPIO HS/CS/GPIO FID/GPIO AVID/GPIO C_0/GPIO C_1/GPIO D18DGND D18DVDD C_2/GPIO C_3/GPIO C_4/GPIO C_5/GPIO V33IOGND V33IOVDD C_6/GPIO/DR C_7/GPIO/DG C_8/GPIO/DB C_9/GPIO/FSO D18DGND D18DVDD Y_0 Y_1
GNDD C222 C223 C224 C225 C228 C229 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
AV2_CVBS
R203
75
1.8uH
C226 220pF GNDD C227 220pF GNDD C230 5.6pF R204 75
CARD_Y
GNDD
AV2_SC
R207
75
L35
1.8uH
C235 220pF C236 220pF R209 75
CARD_C
GNDD
GNDD
1.8uH
C314 220pF C315 220pF
P_D1.8V
33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64
P_D3.3V
D18DVDD D18DGND PWDN RESET# V33IOVDD V33IOGND D0 D1 D2 D3 D4 D5 D6 D7 D18DVDD D18DGND D15 D14 D13 D12 D11 D10 D9 D8 V33IOVDD V33IOGND DQM CLK A11 A9 A8 A7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
A33GND A33VDD VI_1 VI_2 VI_3 NC VI_4 VI_5 VI_6 NC A18VDD A18GND A18VDD A18GND A18GND A18VDD VI_7 VI_8 VI_9 NC VI_10 VI_11 VI_12 NC A33VDD A33GND A33GND A33GND D18DGND SCL SDA INTREQ
TVP5160PNP
128P-TQFP
TVP5160PNP
Y_2 Y_3 Y_4 V33IOGND V33IOVDD Y_5 Y_6 Y_7 Y_8 Y_9 D18DGND D18DVDD DATACLK GLCO/GPIO/I2CA0 GPIO/I2CA1 A3 A2 A1 A0 A10 BA1 V33IOGND V33IOVDD BA0 RAS# CAS# WE# A4 A5 A6 D18DGND D18DVDD
96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65
D[0..7]
11
P_D3.3V
R205 0 /NC
R268 75
GNDD
GNDD
GNDD
CARD_SC
R269
1.8uH
C317 220pF C318 220pF
CARD_C
Active_Low
R270 75 8 RESET# R212 33 RP18 1 2 3 4 RP19 1 2 3 4 8 22 7 6 5 8 22 7 6 5 8 22 7 6 5 8 22 7 6 5 PTDR8 PTDR9 PTDR10 PTDR11 PTDR12 PTDR13 PTDR14 PTDR15 PTDR7 PTDR6 PTDR5 PTDR4 PTDR3 PTDR2 PTDR1 PTDR0 ABC R338 0
A0 DQ0 A1 DQ1 A2 DQ2 A3 DQ3 A4 DQ4 A5 DQ5 A6 DQ6 A7 DQ7 A8 DQ8 A9 DQ9 A10 DQ10 A11 DQ11 BS1/A12 DQ12 BS0/BA DQ13 NC DQ14 CLK DQ15 CAS RAS CKE DQMU DQML WE CS VCC VCC VCC VCCQ VCCQ VCCQ VCCQ GND GND GND VSSQ VSSQ VSSQ VSSQ
GNDD
GNDD
GNDD
P_SD3.3V
PTDQM_1 PTWE_1
1.Analog Channel Video Model Selection following up the Datasheet Page 44 . 2.Must considered your Video Input Connector in layout Side,To avoid Trace Cross in PCB.
RP20 1 2 3 4 RP21 1 2 3 4
P_SD3.3V
28 41 54 52 46 12 6
GNDD
P_D3.3V
3V3 1 L36 600z/100MHz
P_D3.3V
P_SD3.3V
GNDD
C240
+ L38
P_SD3.3V
600z/100MHz
C254
100uF/25V 2
C241 0.1uF
C242 0.1uF
C243 0.1uF
C244 0.1uF
C245 0.1uF
+ C246
C247
C248 0.1uF
C249
C250
C251 0.1uF
C252 0.1uF
C253 0.1uF
47uF/25V ECD_D5_2
10uF/16V 0.1uF
0.1uF 0.1uF
ViewSonic Corporation
Model Title Date
GNDD
37
GNDD
57
74
92
105
GNDD
SCALER
Rev:
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
Rev: 1a
Location Universal number#
Remark 1: Above listed items are examples, supplier can expand the rows to add more necessary items. Remark 2: All revised RSPLs with newly added items or any change made should be highlighted and correlated with the ECN/ECR approved by ViewSonic Corporation. This is to eliminate repeated cross checks of each item between this version and prior versions.
ViewSonic Corporation
VX2835wm-1
ViewSonic Corporation
VX2835wm-1
ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A C-00008464 P-00008481 P-00008482 P-00008483 P-00008484 P-00008485 P-00008486 P-00008487 N/A N/A N/A N/A N/A N/A N/A DC-00008001 DC-00008002 DC-00008003 N/A N/A N/A B-00008444 B-00008074 N/A B-00008445 DC-00008429 N/A DC-00008431
Ref. P/N 43-01043001G040 43-04040804G000 43-04040804G010 43-10040602G000 43-12030502G000 43-12030801G010 43-12041002G010 43-90000082G000 45-X2830100G000 60-01000117G610 61-01000058G000 61-01000059G000 61-01000064G000 61-01000065G000 61-03000017G000 61-03000018G000 62-02000044G000 62-03000018G000 62-05000075G010 62-06000003G000 62-06000004G000 62-06000005G000 62-06000006G000 62-07000009G000 62-07000010G000 62-07000011G000 62-07000014G000 62-07000015G000 62-07000027G000 70-V9350200G040 70-VX193500G000 70-Y2832500G000 71-Y2831200G001 72-28350100G110 72-28350100G210 72-28350100G310
Description SCREW,M4*30,PAN,PT,ZN SCREW M4*8 FLAT BZ ME SCREW M4*8 FLAT BZ TAP SCREW,M4x6L,CH,NI,ME SCREW M3*5 ROUND WASHER NI ME SCREW M3x8 Round washer Zn Tap SCREW M4*10 ROUND WASHER NI TAP SCREW 4#-40*5*6.8 NI VX2835 BEZEL SUB ASSY VX2835wm Carton,Taiwan VX2835 END CAP-R-top EPS VX2835 END CAP-L-top EPS VX2835 END CAP-R-bottom EPS VX2835 END CAP-L-bottom EPS PE Bag,800*1000mm*0.05t VX2835 PE bag,1170mm*1095mm*0.08t VSC vista insert flyer(Art paper) ViewSonic Warranty China VX2835wm ID Label,Taiwan BARCODE LABEL 76.2*76.2MM BARCODE LABEL 50*25MM BARCODE LABEL 25*12MM Barcode label 35*4mm Energy Star Label QC-Pass Label Hi-Pot Pass Label Customer label ViewSonic Customer label 180*100mm VSC manufacture sticker VX1935 KEY BOARD ASS'Y (LF)(Premier) VX1935 KEY BOARD ASSY (Lead Free) VX2835 H/W PCB SUB ASSY POWER MODULE 217W (PHIHONG) VX2835 TWN packing assy,made in Taiwan VX2835 China packing assy,made in Taiwan VX2835wm USA Packing assy,made in Taiwan
Q'ty 8 6 8 6 18 6 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
ViewSonic Corporation
VX2835wm-1
* Readers Response*
Dear Readers: Thank you in advance for your feedback on our Service Manual, which allows continuous improvement of our products. We would appreciate your completion of the Assessment Matrix below, for return to ViewSonic Corporation. Assessment A. What do you think about the content of this Service Manual?
Unit 1. Precautions and Safety Notices 2. Specification 3. Front Panel Function Control Description 4. Circuit Description 5. Adjustment Procedure 6. Troubleshooting Flow Chart 7. Block Diagrams 8. Schematic Diagrams 9.PCB Layout Diagrams 10. Exploded Diagram and Exploded Parts List 11. Recommended Spare Parts List Excellent Good Fair Bad
C. Do you have any other opinions or suggestions regarding this service manual? Readers basic dada: Name: Company: Add: Tel: E-mail:
After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile 1-909-839-7943. You may also e-mail any suggestions to the Director, Quality Systems & Processes (marc.maupin@viewsonic.com)
Title:
Fax:
ViewSonic Corporation
VX2835wm-1