Beruflich Dokumente
Kultur Dokumente
5 Volt Regulator
D CON1 RxD+ RxDTxD+ V+ V+ TxDGND GND 1 2 3 4 5 6 7 8 Power+Comms D1 1N4004 +12v PS1 1 POLYSWITCH (0.5A) U1 VOLTREG GND Vin Vout 3 VCC
C2 100n
EN VCC
2 4 5 6 9 8 GND
V+ V-
D4 SM4T33CA
EC1 220u/25v
LED1 5V
C3 100n
GND ON/OFF
16 18 10 11 13 12
RX2 IN RX2 OUT TX2 OUT TX2 IN RX1 IN RX1 OUT TX1 OUT TX1 IN
R6 100R
14 15
GND D3 12V C
GND
DISPLAY CONTROLLER
VCC 5 GND 14 BP1 100n
SERIAL DATA OUT VDD OUT 20 SERIAL DATA IN OUT 19 OUT 1 OUT 18 OUT 2 OUT 17 OUT 3 OUT 16 OUT 4 OUT 15 OUT 5 OUT 14 OUT 6 OUT 13 OUT 7 OUT 12 OUT 8 OUT 11 OUT 9 BLANKING OUT 10 CLK STROBE GND VBB 14 1
U2 Z86E08-12PSC
1 16 17 18 15 7
GND
Vcc
4 3 2 11 12 13 8 10 9
5 4 3 2 1
VCC
R7 R8 R9
Control
STROBE X1 10MHz 6
ECLK
R10 33R
Xtal2
GND B SCLK SBLANK C7 22p GND C6 22p GND R5 4K7 2 VCC VCC R3 470R DIS 7 R4 470R 8 4 1 GND JP1 DSP MODE LED2 Active R12 270R VCC VCC GND B
3 5
Cathode 10 Cathode 9 Cathode 8 Cathode 7 Cathode 6 Cathode 5 Cathode 4 Cathode 3 Cathode 2 Cathode 1 Cathode 0
Anode Comma Anode D Anode DP Anode C Anode E Anode B Anode F Anode G Anode A Anode Hyphen NC NC NC
Xfmr1 Construction. The transformer is wound onto a pressed ferrite powdered bobin measuring 15mm high, 5mm inner barrel and 10mm outer edges.
A
Vfil2
26
U6 LM395
51T
1 GND
69T
GND
VCC
2 6
C8 10n
Primary winding: 69 Turns of 32 gauge enamelled wire or thinner. Secondary winding: 51 Turns of 32 gauge enamelled wire or thinner over the top of the primary winding. The ratio of 69:51 should be maintained. If twice as many winds can be applied to the bobin then drive current will be reduced and the need for the LM395 driving transistor can be removed. The NE555 will be capable of driving the transformer direct although a Back-EMF diode across the primary will be needed for the NE555's protection.
VFD1 VFD_ZD1880
Vfil1
VCC GND
470R
1 GND
Title
C021
EB
2-Jan-2003 M:\src\..\z8_vfd12_pulse_7805.sch 7