Beruflich Dokumente
Kultur Dokumente
v = o = = ?j = ` ?
Summary of Results
23% Correct of 35 Score d ite m s:
8 C orre ct: 27 Incorre ct: 23% 77%
1.
FET amplifiers provide ________. Your Answer: excellent voltage gain Correct Answer: All of the above
2.
3.
4.
The E-MOSFET is quite popular in ________ applications. Your Answer: high-frequency Correct Answer: All of the above
5.
S to 5000
6.
For what value of ID is g m equal to 0.5 g m 0 ? Your Answer: 0 mA Correct Answer: 0.25 IDSS
7.
What is the typical value for the input impedance Zi for JFETs? Your Answer: 100 k Correct Answer: 1000 M
K ~ K L L ~
NLU
NM LNO LNO
v = o = = ?j = ` ?
8.
Your Answer: 3 mS
9.
Use the following equation to calculate g m for a JFET having IDSS = 10 mA, VP = 5 V, and VGSQ = 2.5 V.
Your Answer: 2 mS
10.
11.
K ~ K L L ~
O LU
NM LNO LNO
v = o = = ?j = ` ?
12.
Referring to the figure below, determine the output impedance for VGS = 3 V at VDS = 5 V.
13.
Calculate g m and rd if yfs = 4 mS and yos = 15 Your Answer: 4 mS, 15 k Correct Answer: 4 mS, 66.7 k
S.
14.
The steeper the slope of the ID versus VGS curve, the ________ the level of g m . Your Answer: same Correct Answer: greater
15.
When VGS = 0.5 Vp g m is ________ the maximum value. Your Answer: one-half
16.
K ~ K L L ~
If ID = IDSS / 2, g m = ___________ g m o .
PLU
NM LNO LNO
v = o = = ?j = ` ?
17.
The more horizontal the characteristic curves on the drain characteristics, the ________ the output impedance. Your Answer: same Correct Answer: greater
18.
What is (are) the function(s) of the coupling capacitors C 1 and C 2 in an FET circuit? Your Answer: to create a short-circuit equivalent for ac analysis Correct Answer: All of the above
19.
Where do you get the level of g m and rd for an FET transistor? Your Answer: from the characteristics Correct Answer: All of the above
20.
S.
21.
S.
K ~ K L L ~
Q LU
NM LNO LNO
v = o = = ?j = ` ?
22.
________.
23.
Which of the following is a required condition to simplify the equations for Zo and Av for the self-bias configuration? Your Answer: None of the above Correct Answer: rd 10RD
24.
S.
25.
On which of the following parameters does rd have no or little impact in a source-follower configuration? Your Answer: All of the above
26.
K ~ K L L ~
RLU
NM LNO LNO
v = o = = ?j = ` ?
27.
28.
Which of the following is (are) related to depletion-type MOSFETs? Your Answer: All of the above
29.
S.
30.
K ~ K L L ~
SLU
NM LNO LNO
v = o = = ?j = ` ?
31.
32.
33.
34.
Referring to this figure, calculate the value of RD if the ac gain is 10. Assume VGSQ = Vp .
K ~ K L L ~
TLU
NM LNO LNO
v = o = = ?j = ` ?
35.
For an FET small-signal amplifier, one could go about troubleshooting a circuit by ________. Your Answer: using a dc meter Correct Answer: All of the above
Copyright 1995 - 2010 Pearson Education . A ll rights reserved. Pearson Prentice Hall is an imprint of Pearson . Legal Notice | Privacy Policy | Permissions
K ~ K L L ~
ULU