Beruflich Dokumente
Kultur Dokumente
v = o = = ?j = ` ?
Summary of Results
29% Correct of 35 Score d ite m s:
10 C orre ct: 25 Incorre ct: 29% 71%
1.
What is the ratio of the common logarithm of a number to its natural logarithm? Your Answer: 0.435 Correct Answer: 2.3
2.
3.
By what factor does an audio level change if the power level changes from 4 W to 4096 W? Your Answer: 4 Correct Answer: 6
4.
The input power to a device is 10,000 W at 1000 V. The output power is 500 W, and the output impedance is 100 . Find the voltage gain in decibels. Your Answer: 20.0 dB Correct Answer: 13.01 dB
5.
What magnitude voltage gain corresponds to a decibel gain of 50? Your Answer: 31623.8 Correct Answer: 316.228
6.
An amplifier rated at 30-W output is connected to a 5- speaker. Calculate the input power required for full power output if the power gain is 20 dB. Your Answer: 300 mW
7.
An amplifier rated at 30-W output is connected to a 5- speaker. Calculate the input voltage for the rated output if the amplifier voltage gain is 20 dB. Your Answer: 122.5 mV
K ~ K L L ~
NLS
NM LNO LNO
v = o = = ?j = ` ?
8.
For audio systems, the reference level is generally accepted as ________. Your Answer: 1 W Correct Answer: 1 mW
9.
For which of the following frequency region(s) can the coupling and bypass capacitors no longer be replaced by the short-circuit approximation? Your Answer: All of the above Correct Answer: Low-frequency
10.
By what other name(s) are the cutoff frequencies in a frequency response plot called? Your Answer: All of the above
11.
What is the ratio of the output power to the input power at the cutoff frequencies in a normalized frequency response plot? Your Answer: 0.707 Correct Answer: 0.50
12.
What is the ratio of the output voltage to the input voltage at the cutoff frequencies in a normalized frequency response plot? Your Answer: 1 Correct Answer: 0.707
13.
What is the normalized gain expressed in dB for the cutoff frequencies? Your Answer: +3 dB Correct Answer: 3 dB
14.
The ________-frequency response of a transformer-coupled system is calculated primarily by the stray capacitance between the turns of the primary and secondary windings. Your Answer: low Correct Answer: high
15.
The larger capacitive elements of the design will determine the ________ cutoff frequency. mid
K ~ K L L ~
O LS
NM LNO LNO
v = o = = ?j = ` ?
16.
The smaller capacitive elements of the design will determine the ________ cutoff frequencies. Your Answer: high
17.
What is the ratio of the capacitive reactance XC S to the input resistance RI of the input RC circuit of a single-stage BJT amplifier at the low-frequency cutoff? Your Answer: 0.50 Correct Answer: 1.0
18.
In the input RC circuit of a single-stage BJT, by how much does the base voltage lead the input voltage for frequencies much larger than the cutoff frequency in the low-frequency region? Your Answer: 45 Correct Answer: About 0
19.
In the input RC circuit of a single-stage BJT, by how much does the base voltage lead the input voltage at the cutoff frequency in the low-frequency region? Your Answer: 45
20.
21.
Refer to Figure 9.19. Calculate Your Answer: 26.56 Correct Answer: 63.43
at 0.5f1 .
22.
K ~ K L L ~
PLS
NM LNO LNO
v = o = = ?j = ` ?
23.
A change in frequency by a factor of ________ is equivalent to 1 decade. Your Answer: 5 Correct Answer: 10
24.
For the low-frequency response of a BJT amplifier, the maximum gain is where ________ . Your Answer: RE = 0
25.
Which of the low-frequency cutoffs determined by C S, C C , or C E will be the predominant factor in determining the low-frequency response for the complete system? Your Answer: highest
26.
27.
Which of the following elements is (are) important in determining the gain of the system in the high-frequency region? Your Answer: All of the above
28.
K ~ K L L ~
In the ________-frequency region, the capacitive elements of importance are the interelectrode (between terminals) capacitances internal to the active device and the wiring
Q LS
NM LNO LNO
v = o = = ?j = ` ?
29.
Which of the following capacitors is (are) included in C i for the high-frequency region of a BJT or FET amplifier? Your Answer: All of the above
30.
In the hybrid
31.
Which of the following configurations does (do) not involve the Miller effect capacitance? Your Answer: All of the above Correct Answer: Common-base
32.
A 3-dB drop in h fe will occur at a frequency defined by ________. Your Answer: 2 Correct Answer:
33.
What is the range of the capacitors C gs and C gd ? Your Answer: 1 to 10 F Correct Answer: 1 to 10 pF
34.
What is the range of the capacitor C ds ? Your Answer: 0.1 to 1 F Correct Answer: 0.1 to 1 pF
35.
Which of the following statements is true for a square-wave signal? Your Answer: The harmonics waveforms are also square waves. Correct Answer: It is composed only of odd harmonics.
K ~ K L L ~
RLS
NM LNO LNO
v = o = = ?j = ` ?
My nam e is (first last): E-m ail m y re sults to: E-mail address: Me Instructor TA O the r He lp Send as: Te x t Te x t Te x t Te x t E-m ail R e sults
Copyright 1995 - 2010 Pearson Education . A ll rights reserved. Pearson Prentice Hall is an imprint of Pearson . Legal Notice | Privacy Policy | Permissions
K ~ K L L ~
SLS