Beruflich Dokumente
Kultur Dokumente
Course Contents
Concept of RN optimization KPI of radio network Work flow of RN optimization Parameter adjustment principles RN optimization tools introduction Common problems of RN optimization
Concept of RN Optimization
Radio network optimization means network performance improvement utilizing existing network resources.
Steps in general
Data collection and verification Data analysis Parameter and hardware adjustment Optimization result confirm and reporting
The purpose is increasing the utilization of network resources and solving the existing and potential problem on the network, identifying solutions for future network planning.
Concept of RN Optimization
Q u a l i t Optimiz y e
p a c i t y
C o v e r a g
Concept of RN Optimization
Due to the mobility of subscribers and complexity of radio wave propagation, most of network problems are caused by increasing subscribers and the changing environments. RN Optimization is a continuous process that is required as the network evolves
Concept of RN Optimization
In the following case, the network should be optimized
New network or expansion on existing network The network quality decreased seriously and there are many complaints from subscribers. An event occurs suddenly which affects the network performance seriously. The number of subscribers increased and affects the network performance gradually.
Concept of RN Optimization
Input for Optimization
CUSTO MER COMPL AINTS
Course Contents
Concept of RN optimization KPI of radio network Work flow of RN optimization Parameter adjustment principles RN optimization tools introduction Common problems of RN optimization
KPI Parameter Call Drop Rate Congestion Rate Handover Success Rate Busy Hour Traffic TCH Utilization Call Setup success rate Coverage Quality
Source OMC/Drive test Drive test OMC/Drive test OMC OMC OMC/Drive test Drive test Drive test
BTS4 BTS3 BTS2 BTS1
Course Contents
Concept of RN optimization KPI of radio network Work flow of RN optimization Parameter adjustment principles RN optimization tools introduction Common problems of RN optimization
Course Contents
Concept of RN optimization KPI of radio network Work flow of RN optimization Parameter adjustment principles RN optimization tools introduction Common problems of RN optimization
MONITO R EFFECT
IDENTIF Y PROBLE M
Radio Parameters
Handover Parameters Handover Parameters Handover Parameters
Engineering Parameters
Antenna D-tilt Antenna Height Antenna Orientation
Course Contents
Concept of RN optimization KPI of radio network Work flow of RN optimization Parameter adjustment principles RN optimization tools introduction Common problems of RN optimization
The following are the frequently used drive test tools: TEMS and GIMS Ant Pilot and GSM 2000 SAFCO Walkabout & SAFCO OPAS TS9951 NEPTUNE
Signaling Analyzer
Signaling analyzer
In real time, MA-10 signaling analyzer can trace A-bis interface signaling message, A-G interface signaling message, SS7 signaling message of ISUP, TUP and INAP, and also bit error rate of transmission system. For further analysis the signaling message files can be saved during online tracing, then they can be opened for analysis at anytime.
Spectrum Analyzer
Spectrum analyzer
The spectrum analyzer is mainly used to test the characteristics of frequency, including spectrum, power of the adjacent channel, and frequency scanning etc.
HO measurement
Course Contents
Concept of RN optimization KPI of radio network Work flow of RN optimization Parameter adjustment principles RN optimization tools introduction Common problems of RN optimization
Traffic balance
Adjust the antenna height, downtilt, and change the TX power of BTS and MS. Adjust parameters for cell selection, cell reselection and handover Enable load handover and direct retry functions.
Cell select
Direct retry
Idle mode
Calling mode
Hand over
Cell reselect
Dedicate mode
Exercise
Questions
Please write down KPI for normal network Please write down the work flow for radio network optimization How to do for traffic balance
Thank You