Beruflich Dokumente
Kultur Dokumente
com
INDUSTRIES
1993-1998
Lincoln Mark 8
www.SuncoreIndustries.com
INDUSTRIES
Turn air suspension switch o . Raise vehicle and remove the wheel. Remove the Upper Control Arm by removing the pinch bolt and nut. Position the air suspension height sensor out of the way. Tap the wishbone control arm upward. Twist air spring counter-clockwise, pull the air spring out. Unbolt the brake line braket that is mounted to the frame. Go to the engine compartment and remove the three shock tower nuts 13mm. Pull air strut out and install the kit in reverse procedure. Be sure to securly plug both airlines after removing solenoids. ( 2-wheel kits only)
5 6 7 8
10
See attached instructions to disarm suspension warning light. If this DOES NOT turn out the suspension warning light, you can cut the ground wire to the suspension compressor. In the Trunk Turn main air ride switch on.
11
50F-30-4
www.SuncoreIndustries.com
1.
www.SuncoreIndustries.com
INDUSTRIES
GRAY PLUG
MODULE
PL UG
YES
50F-30-4
GR AY
32 20 31 30 19 18
NO
29
28
27
17
16
15
14
13
12
11
Contact Suncore Industries For How To: Disarming The Suspension Warning Message
www.SuncoreIndustries.com
2.
www.SuncoreIndustries.com
INDUSTRIES
50F-30-4
www.SuncoreIndustries.com
3.
www.SuncoreIndustries.com
INDUSTRIES
50F-30-4
www.SuncoreIndustries.com
4.
www.SuncoreIndustries.com
INDUSTRIES
GRAY PLUG
MODULE
GR
REMOVE SHOCK BOLT
AY PL UG
YES
32 20
31
30
29
28
27
19
18
17
16
15
14
13
12
11
NO
Contact Suncore Industries For How To: Disarming The Suspension Warning Message
50F-30-4
www.SuncoreIndustries.com
5.