Beruflich Dokumente
Kultur Dokumente
2. Eight holiday lights are connected in parallel as shown in Fig. a. If the set is connected to a 120-V source, what is the current through each bulb if each bulb has an internal resistance of 1.8 k ohms? b. Determine the total resistance of the network. c. Find the power delivered to each bulb. d. If one bulb burns out (that is, the filament opens), what is the effect on the remaining bulbs? e. What are the relative advantages and disadvantages of the parallel system compared to the series arrangement?
3. A portion of a residential service to a home is depicted in Fig. a. Determine the current through each parallel branch of the network. b. Calculate the current drawn from the 120-V source. Will the 20-A circuit breaker trip? c. What is the total resistance of the network? d. Determine the power supplied by the 120-V source. How does it compare to the total power of the load?
Page 1
5. Determine the current through each resistor and voltage through the labeled nodes with respect to ground in the ladder circuit given below.
Page 2
9. The circuit of Figure is referred to as a bridge circuit and is used extensively in electronic and scientific instruments.
Page 3
11. For the circuit, find the indicated currents and voltages., I1,I2 and Vab
Page 4
14. If all the resistors of the cube in Fig are 10 ohms, what is the total resistance? (Hint: Make some basic assumptions about current division through the cube.)
15. For the multiple ladder configuration shown below: a. Determine I. b. Calculate I4. c. Find I6. d. Find I10.
Shiv Nadar University, School of Engineering, Department of Electrical Engineering Page 5
16. Using Y-Delta or Delta -Y conversions, determine the total resistance of the network.
Page 6