Beruflich Dokumente
Kultur Dokumente
Living
Outside
Play
Technology
Workshop
Comments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Image Notes 1. Enough gel wax to fill about three 1.5L wine bottles
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Image Notes 1. $16 at Home Depot. They also had single bits for around $7 each. I used the smallest bit in the pack.
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Image Notes 1. Ground 2. 5 volts 3. red 4. blue 5. 220 Ohm 6. 100 Ohm
Image Notes 1. I used thin wrapping wire inside the bottle so it would be less visible.
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Image Notes 1. $16 at Home Depot. They also had single bits for around $7 each. I used the smallest bit in the pack.
Image Notes 1. The cork prevents the drill from breaking the bottle after the hole is drilled.
Image Notes 1. A big hole is drilled on the bottom so the toggle switch will fit inside.
Image Notes 1. The small hole on the top lets the toggle switch poke through.
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Image Notes 1. Sticky tack over the hot glue to hold the glue in place if it melts
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Related Instructables
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/
Comments
2 comments
Add Comment
Dec 4, 2011. 8:41 PM REPLY
susanrm says:
Very pretty!
Nanovirus says:
That is Gorgeous! :D I can imagine having a whole wall of these! Good job :)
http://www.instructables.com/id/Wine-Bottle-LED-Gel-Lamp/