Beruflich Dokumente
Kultur Dokumente
‘How-to’ guides
Step 1. Undo the clamps on either side of this U-Shaped hose, and then remove the hose.
Step 2. Undo these 2 screws, it will allow you lift up the intake pipe giving you more room.
Step 4. Disconnect the loom plug (may vary in appearance). Then just move 2 disconnected looms off to the
side. You don't have to remove the 2 circled screws.
Step 5. There are 8 Allen screws to undo all the way along the plastic cover as circled below. Once you have
removed them all you can then slide out the plastic cover.
Step 7. Now, at this stage you will see the top of each coil pack, I pulled out the whole cradle and coil pack as
described next but you don’t have to that. You can just remove the screws that hold each coil pack in. This how
to pull it all out; Unscrew the gold/bronze bolts that hold the coil pack cradles in place. There are about 6 or 7
of them. Once they are removed you can pull out the coil-packs and cradle to see the spark plugs underneath.
Now remove the spark plugs and put in the new ones!
NOTES: