Sie sind auf Seite 1von 25

Not All Carrots Are Orange

This is the VOA Special English Agriculture Report. Carrots are grown on and in family gardens throughout the world. Carrots are easy to raise and easy to harvest. They taste good. And they contain a lot of carotene, which the body makes into vitamin A. When people think of carrots, they usually picture in their mind a vegetable that is long, thin and orange in color. But carrots come in many different carrots are orange. and shapes. And not all

For example, Paris Market carrots are about five centimeters around. Imperator carrots are thin and about twenty-five centimeters long. And Belgian White carrots are, as their suggests, white. For the best results, carrots should be grown in sandy soil that does not hold time. The soil also should have no rocks. for a long

To prepare your carrot garden, dig up the soil, loosen it and turn it over. Then, mix in some plant material or fertilizer.

Weather, soil conditions and age will affect the way carrots taste. Experts say warm days, cool and a medium soil temperature are the best conditions for growing carrots that taste great. Carrots need to develop their full sugar content. This gives them their taste. If they are harvested too early, they will not have enough sugar. But carrots loose their sweetness if you wait too long to pull them from the ground. The best way to judge if a carrot is ready to be harvested is by its color. Usually, the the color, the better the taste. Most people do not know that carrots can be grown during the winter months. If the winter is not cold enough to freeze the ground, you can grow and harvest carrots the same way as during the months.

If the ground does freeze in your part of the world, simply cover your carrot garden with a layer of leaves or straw. This will prevent the ground from freezing. You can remove the ground cover and harvest the carrots as they are needed. Carrots are prepared and eaten many different ways. They are cut in thin pieces and added to other vegetables. They are cooked by themselves or added to washed, they are eaten just as they come out of the . . Or, once they are

And that's the VOA Special English Agriculture Report. For more agricultural advice, along with transcripts and archives of our reports, go to voaspecialenglish.com. And our e-mail address is special@voanews.com. I'm Steve Ember.

McDonald's Targets Starbucks


This is the VOA Special English Economics Report. McDonald's, the fast-food company, is heating up competition with the Starbucks Coffee Company. McDonald's plans to put bars in its fourteen thousand restaurants in the United States. Fewer than a thousand now offer specialty coffee drinks like lattes and cappuccinos. Just like Starbucks, each coffee bar would have its own barista, the person who makes and serves the . Company documents reported by the Wall Street Journal said the plan would add one billion dollars a year in sales. McDonald's has enjoyed several years of strong growth. The company had almost twenty-two billion dollars in sales in two thousand six. Still, the move to compete against Starbucks carries some risk. Some experts say it could slow down at McDonald's restaurants. And some people who are happy with McDonald's the way it is now may not like the changes. As early as two thousand one the company tested McCafes in the United States to sell specialty coffee at McDonald's restaurants. But the drinks were not available at the drivethrough windows that provide two-thirds of its business. McDonald's thinks its new plan has a greater chance of success. Starbucks, on the other , has faced slower growth and increasing competition. Its stock has lost about half its value since last January. Starbucks has about ten thousand stores in the United States. Its high-priced coffee drinks have names like Iced Peppermint White Chocolate Mocha and Double Chocolate Chip Frappuccino. Lately Starbucks has added more foods, including breakfast foods, and put drive-through in some stores.

This week, the company replaced its chief executive officer, bringing back former C.E.O. Howard Schultz. He remains chairman of the board. He joined Starbucks in nineteen eightytwo, when it had just four stores. He is credited with building the Seattle company into an international success .

But a year ago he warned that its fast growth had led to what he called the watering down of the Starbucks experience. Some neighborhoods have a Starbucks on every block or two. Now, Starbucks will speed up its international growth while slowing its expansion in the United States.

Millions of people have a taste for Starbucks. But last , McDonald's Premium coffee got some good press. Testers from Consumer Reports thought it tasted better than Starbucks, and it cost less. And that's the VOA Special English Economics Report, written by Mario Ritter. I'm Steve Ember.

Coyotes Eyeing the Sheep? Employ a Guard Llama


This is the VOA Special English Agriculture Report. (SOUND) When Americans think of where coyotes live, they probably think of states in the Southwest like Arizona. But over time, these wild dogs have spread all the way to the East Coast. Some farmers have to protect their sheep from coyotes. These guards are llamas. Llamas are South American animals usually raised in the United States for their fiber or for show or as . But farmers and ranchers noticed that llamas get along well with sheep. , coyotes were killing fewer sheep. So they chose llamas

They also noticed that over for guard duty. Llamas do not need any

. Farmers usually place only one with a group of sheep.

Llamas are animals. Two llamas together will not pay attention to the sheep. A lone llama has no choice. In the Shenandoah Valley of Virginia, farmer Leo Tammi has several hundred sheep. His dogs help him control and protect the he uses llamas. Whenever anything enters the of sheep. But the dogs are not always available. So

, they know about it. He says their natural interest, and , is enough to scare away a

willingness to face almost anything that comes animal like a coyote.

Their size also helps. Llamas can weigh as much as one hundred thirty-six kilograms. And they look something like a small horse -- a funny looking with a lot of fine, soft fur. Llamas are not vicious animals. However, if they are not around people at a very young age, they will not like to be touched. In many ways a llama is just as secret . They spit. as a sheep. But llamas have a

When they get angry, they spit out the contents of their stomachs. The result looks and

smells

Llamas really know how to make a statement. In fact, you can find examples of llama sounds on the Internet -- just remember that llama is spelled with two Ls, L-L-A-M-A. If they sense a threat, they make an (SOUND) And this is a female alarm call. (SOUND) Llamas are New World camelids along with alpacas, vicunas and guanacos. Camelids are a of animals that also include the camels and dromedaries of Africa and Asia. sound. This is what a male sounds like:

And that's the VOA Special English Agriculture Report. To see a video report about llamas, go to voaspecialenglish.com. I'm Steve Ember.

Petroleum: A Short History of Black Gold


1. Petroleum was used in ancient times for making roads. cars. rolls. 2. Petroleum comes from the remains of ancient times. plants and animals. dinosaurs and other animals. 3. Oil can also contain a lot of sulfur. True. False. The author doesn't say. 4. The modern history of oil started in 1800. 1850. 1980.

5. Edwin Drake drilled the first oil well in the US in 1815. 1829. 1859. 6. John D. Rockefeller entered the oil business in the early 1816. the early 1860s. 1870. 7. The company Standard Oil was divided into 24 companies. 34 companies. 54 companies.

Want to Stay Warm in Winter? Think COLD


1. Frostbite mainly happens on the legs. the lips. the ears. 2. If blood vessels are damaged, people can suffer an infection. remove fingers and toes. suffer hypothermia. 3. In the C.O.L.D. steps, the C stands for Cover. Cold. Caution. 4. Wet clothes and cold weather are a bad mix. True. False. The author doesn't say.

5. Wearing one layer on top of another is better than a single heavy layer of clothing. True. False. The author doesn't say. 6. Snow can enter through the legs. the wrist areas. the arms. 7. Eating snow is a good idea. True. False. The author doesn't say.

Schools Look to Save Money With Four-Day Week


This is the VOA Special English Education Report. As we said last week, American schools are looking for ways to save money on bus transportation because of high prices. More children may have to walk, bikes or find other ways to get to school. But, as another effect of the high prices, they may not have to go to school as Some schools, especially in rural areas, are changing to a four-day week. That means days instead of the traditional Monday through Friday schedule. Beginning in the , students in the Maccray school district in Minnesota will be in school Tuesday through Friday. Each school day will be sixty-five minutes longer. Superintendent Greg Schmidt says the district expects to save about sixty-five thousand dollars a year in transportation costs. The district has about seven hundred students living in an area of nine hundred square kilometers. State officials have approved the plan for three years. They may change their mind before then if suffers. . their

In Custer, South Dakota, students have been going to school Monday through Thursday since nineteen ninety-five. Superintendent Tim Creal says the change has saved an estimated one million dollars over just the past eight years.

But he sees other benefits, too. Students get more instructional time. And activities that used to with classes are now on non-school days.

He says that in the future, the growth of online classes could make it possible to require even fewer days in school. High fuel prices are driving college students to take more online classes. And in some states, high school students can take them, too. A four-day school week sounds like a great for students and teachers. But working

parents may have to pay for child for that fifth day. In agricultural areas, though, it can mean an extra day of helping on the family ranch. In New Mexico, the first school district changed to a four-day week in nineteen seventy-four because of the Arab oil . Now, seventeen out of eighty-nine districts use it.

The Lake Arthur School District has just one hundred sixty students. Lake Arthur used a fourday for twelve years. But a few years ago it went back to five days.

Michael Grossman heads the district. He says two studies there failed to show any real educational using the four-day week. And he says not much instruction was taking .

place during the last hour of school, because teachers and students were too

And that's the VOA Special English Education Report, written by Nancy Steinbach. I'm Steve Ember.

'Summer Work/Travel' Brings Many Students to US


This is the VOA Special English Education Report. This week, we answer a question from a student in Odessa, Ukraine. Marushka wants to know about a program that lets foreign students work in the United States during their summer . The program is called Summer Work/Travel. The State Department administers it for fulltime or university students who speak English well. during their , restaurants and

Students come on a J-one exchange visa. They can work for up to four school break. They generally work in service jobs in stores, resorts, amusement parks. But summer internships are also permitted.

"Summer" in this case means summer in the student's country. Those from south of the equator come to the United States during the northern .

Students cannot work as housekeepers in private they are supposed to be paid the same as Americans.

or be involved in patient care. And

Congress created this popular program under a nineteen sixty-one law, the Mutual Educational and Cultural Exchange Act. Last year, one hundred fifty thousand students came to the United States this way. Students can do the Summer Work/Travel program than once.

Sally Lawrence heads the State Department office responsible for the program. She says students should begin to gather information a year before they want to .

More than fifty organizations are approved to act as sponsors. Sally Lawrence advises students to avoid unapproved groups offering , and to research a few different sponsors.

Sponsors must confirm the English language ability of students and make sure they are currently in school. But sponsors do not all charge the same for their services. they

Another difference: some sponsors arrange employment and housing for students leave home. Others permit students to find their own jobs Sally Lawrence says the first thing to do is to find the J visa exchange programs. they arrive.

of sponsors on the Web page for

The address is a little long, but here it is: exchanges.state.gov/education/jexchanges. Click on Designated Sponsor List, then choose Summer Work/Travel under Category Description. For more information about the program, go to the main page and click on Private Sector Programs. To make it easier, we'll post a link at voaspecialenglish.com. And that's the VOA Special English Education Report, written by Nancy Steinbach. I'm Steve Ember.

Among Vitamins, D Seems Short for 'Does a Lot'


This is the VOA Special English Health Report. Vitamin D helps bones and grow strong and healthy. Low levels of vitamin D can lead

to problems such as rickets, a deformity mainly found in . Osteoporosis, the thinning of bone, is a common problem as people, especially women, get older. But more and more research is suggesting that vitamin D might also help diseases. many

The easiest way to get vitamin D is from . The sun's ultraviolet rays react with skin cells to produce vitamin D. But many people worry about getting skin cancer and skin damage from the . As a result they cover their skin or wear sunblock or stay out of the . that get less

sun.Also, darker skinned people produce less vitamin D than lighter skinned Production also decreases in older people and those living in northern sunlight.

Not many foods naturally contain vitamin D. Foods high in this vitamin include oily fish such as salmon, and mackerel, and fish liver oils.

Boston University researchers reported last year that farmed salmon had only about onefourth as much vitamin D as wild salmon. Small amounts of D are found in beef liver, and egg yolks. And some people take dietary supplements containing the vitamin. But most of the vitamin D in the American diet comes from foods with D added, like .

In nineteen ninety-seven, the United States Institute of Medicine established levels for how much vitamin D healthy people need. It set the daily amount at two hundred international units from birth through age fifty. It set the level at four hundred I.U.s through age seventy, and six hundred for age seventy-one and over. But some groups say these amounts are not enough. They are hoping that the new research findings will lead to new recommendations. Research in the last several years has shown that levels of vitamin D may increase the risk of heart attacks in men and deaths from some cancers. Other studies have shown that people with rheumatic diseases often have low levels of vitamin D. More doctors are now having their tested for their vitamin D levels. But as research

continues, some experts worry that if people take too much vitamin D, it might act as a . Also, skin doctors warn people to be careful with sun exposure because of the risk of skin cancer. And that's the VOA Special English Health Report, written by Caty Weaver. I'm Steve Ember.

Farming Techniques That Will Feed a Family


This is the VOA Special English Development Report. The Food and Agriculture Organization estimates that poor countries will spend up to one hundred seventy billion dollars this year to import . This is an increase of forty percent

from last year. The United Nations agency says the rising price of food over the past year is a serious problem because most hungry people also live in .

A humanitarian organization based in Washington, D.C. has a new anti-hunger project. Women for Women International is teaching poor women in Sudan and Rwanda a new food production system called commercial integrated farming. The women are trained to grow that not only feed their families, but also earn them a profit. Pat Morris is program director at Women for Women International. The group launched its commercial integrated farming program in Rwanda. Female farmers receive information about what kind of seeds to use, how to farm without and when to harvest. The program also provides business skills training. Mizz Morris says women being trained in Rwanda could more than triple the amount of money they earn from farming. With integrated farming, the women animals and different crops on one piece of land. Animal waste provides fertilizer. Some of the crops can be used as animal feed. In Rwanda, the women have been able to grow traditional crops like and sorghum grain

along side higher-value crops, such as . A hectare of farmland in Rwanda used to earn about four hundred twenty dollars a year. But a family using integrated farming techniques on the same piece of land can earn as much as three thousand five hundred dollars a year. Women for Women International works with local community partners to design and carry out its integrated farming program. Grace Fisiy is an agricultural business expert working in Rwanda and Sudan. She says the local about farming. in both countries have helped educate people

Women for Women International plans to train at least three thousand women in Sudan and Rwanda. Mizz Fisiy hopes the program will to other countries as well.

And that's the VOA Special English Development Report, written by Jill Moss. You can learn about the efforts of other groups working in developing countries at voaspecialenglish.com.

Food Safety After a Flood


This is the VOA Special English Agriculture Report. People can get if they eat food touched by floodwaters. Floodwater may contain human and animal wastes, and other pollutants like agricultural and industrial chemicals. After a flood, throw away anything not stored in a waterproof container if there was a chance of contact. That is the advice of food safety specialists at the United States Agriculture Department. Food containers that are not waterproof, they say, include those with screw caps, snap lids,

pull tops and crimped caps. Also throw away have come into contact with floodwater.

of juice,

or baby formula if they

The Minnesota Department of Health says to throw away anything in soft packaging. And the Extension Service at North Dakota State University says not to save plastic even if boxes and containers inside the bags appear dry. of food

Also, do not eat fresh produce from the garden if it has come in contact with floodwater. To be safe, have the soil tested. The Extension Service also says to throw away screw-topped or crimp-topped jars and even if they have never been opened. Glass jars and bottles of home-canned foods should be thrown out as well. Experts say the containers cannot be effectively cleaned after a flood. Throw away damaged metal or hard swollen or leaking, or that are rusted or crushed. containers. Do not use cans that are

But experts say that some unopened, undamaged all-metal cans can be saved. First, remove any . The paper may contain dirt and germs from the floodwater. Wash the cans with for

soap and water, and brush or wipe away dirt. Use hot water and water that is drinking if they are available.

Next, place the cans again in water and heat the water to one hundred degrees Celsius. Boil the cans for two .

Another way to disinfect them is in a freshly made solution of chlorine bleach. Use one tablespoon of unscented liquid bleach for every four liters of . Use drinking water or the cleanest, clearest water available. Place the cans in the solution for fifteen minutes. Once cans are clean, let them air-dry for at least one before opening or storing them. Relabel them with a marking pen to list their contents and any dates when they are best used by. Experts advise using the cans as soon as possible. And that's the VOA Special English Agriculture Report, written by Jerilyn Watson. I'm Bob Doughty.

Australia Aims for Cleaner Coal

Topic: A demonstration project will seek to develop new technology to burn coal in pure oxygen and capture carbon dioxide underground. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar

This is the VOA Special English Development Report.

Australia wants to show that existing

stations can be refitted to burn coal in a much

cleaner way. A demonstration project will seek to develop new technology over the next four years that makes it easier to capture carbon dioxide. Carbon dioxide is the main gas that many scientists say helps cause warming.

In traditional coal-fired power stations, the coal is burned in air in a big furnace and the carbon dioxide is released into the atmosphere. In the new system, the coal is burned in pure oxygen instead of . The captured carbon dioxide gas is then made into a liquid and

buried deep underground. The process is called geo-sequestration. The operators of the project in the northern state of Queensland say it is the first of its kind in the Australian and Japanese companies are supporting the project, and the Australian government is paying for part of it. .

Geoff Wilson is the mines and energy minister in Queensland. He says the new system will sharply to store. the amount of carbon released from the coal-fired process and make it easier

The International Energy Agency has said that clean coal technology could help reduce the release of greenhouse by one-fourth. But a spokeswoman for the environmental group

Friends of the Earth says the technology has very limited promise to cut emissions in the short term.

Critics say the technology is unproven. And they say it will not guarantee that Australia will be able to reduce emissions in the . Australia releases more greenhouse gases per

person than almost any other country in the world. Its emissions come mainly from coal burned for electricity.

On November fifteenth, thousands of Australians in Sydney, Melbourne and other joined a yearly protest called "Walk Against Warming." They called for renewable energy.

Scientists warn that the Australian continent could suffer more severe and storms as a result of climate change.

periods, floods

For years the government refused to

the Kyoto treaty limiting greenhouse gas

emissions. But Prime Minister Kevin Rudd signed the protocol as his first act in office following his election last year. He has made action on climate change an important part of his environment .

And that's the VOA Special English Development Report. Transcripts and MP3s of our reports are at voaspecialenglish.com. I'm Steve Ember.

Finding Uses for Marginal Lands

Topic: Farmers can try planting grasses and forage crops for their animals. Trees are another possibility. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Agriculture Report.

We have a question from Jonah Ojowu in Benue State, Nigeria, about a subject we have discussed in the past. Jonah is a postgraduate student in soil and management at the

University of Agriculture in Makurdi. He would like information about the management of marginal lands. "Marginal" lands might have quality soil. Or they might be on a hillside

that rises sharply. Or they might be in an area that gets limited rainfall. In any case, they are the last to be conditions. under good conditions and the first to be avoided under bad

But there are uses for marginal lands. Most often they are used as grasslands for cattle, or goats. A farmer might use native grasses or non-native seed. Either way, it is important to establish good ground cover to avoid the loss of soil through erosion.

Forage crops like clover and alfalfa could be planted. These members of the legume family provide high protein food for grazing animals. They also improve the of the soil.

Most plants use up nitrogen. Legumes put nitrogen back into the soil. Forage crops also reduce erosion of the soil.

But using marginal land for grazing is not as simple as it might sound. Cattle can damage

forage crops by eating down to the the ground too hard for growing.

. Also, their weight crushes the soil. That can make

A way to reduce the damage from overgrazing is to move animals from one field to another. Experts say rotational grazing like this is extremely important for marginal land. We will talk more about rotational grazing next week.

Another use for marginal land is for tree crops. Trees help support the soil. They reduce the damaging effects of the sun. and rain. And they can provide grazing animals with shade from

Studies have shown that the white pine and loblolly pine are two kinds of trees that grow well on marginal land. They grow and provide good quality wood. Another kind to consider

is the poplar. And there are slower-growing trees like the black walnut that provide a nut crop as well as wood.

Marginal lands need care. Failing to take that care might only make a bad situation worse. But good planning can a marginal resource into a highly productive one.

And that's the VOA Special English Agriculture Report, written by Mario Ritter. Archives are at voaspecialenglish.com, where you can also contact us with questions that we might be able to answer on our program. I'm Steve Ember.

Got Milk? How to Make Yogurt

Topic: Directions for making your own at home. Also, Italy moves to rescue its king of cheeses. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Development Report.

Yogurt is a healthy

that can be made at home. One way to make it is to first buy some spoonfuls of the yogurt to

yogurt from a store or purchase dry yogurt culture. Add two

two cups of milk. This will be the starter for your own yogurt. A cup in the United States is two hundred forty milliliters.

When making yogurt, it is very important to have clean equipment, clean temperature control.

and good

Pour eight cups of milk into a large cooking

. Heat the milk to eighty-five degrees

Celsius. Then cool the milk quickly to forty-three degrees. To do this, you can put the cooking pot in cool water.

Keep the yogurt at forty-three degrees and add one-half cup of the starter. The remaining starter can be kept for later use. If you want a cup of dry milk. yogurt, you can also add one-third of a

Cover the pot and keep it at a temperature of forty to forty-five degrees Celsius for four to six . After that, your homemade yogurt is ready. It can be left at room temperature

for up to twelve hours if you like a stronger taste.

You can add

, nuts, honey or spices.

Yogurt can be made with milk from

or other animals including goats, sheep, water

buffalo and camels. It can be spelled y-o-g-u-r-t or y-o-g-h-u-r-t. More information on yogurt making can be found at Web sites such as practicalanswers.org.

Now, from yogurt, we move on to another ancient and related food -- cheese.

Parmigiano-Reggiano is the king of Italy's cheeses. People worldwide use it on other foods. The traditional Italian cheese is produced on several hundred northern city of Parma.

and around the

Cheese makers age it for at least twelve months in large rounds called wheels.

Parmigiano-Reggiano producers say now they are struggling with the financial crisis. Sales of the cheese and a lower-priced , Grana Padano, are down in Italy. Prices for producers .

have dropped. And low-priced copies are on the

Now comes a rescue plan for the industry. Italy's government has made available enough

money to buy two hundred thousand wheels of Parmigiano-Reggiano. Charitable organizations then will give the cheese -- more than sixty million dollars' worth -- to people.

Teens, Television, and Depression

Topic: A new study looks at the relationship between media use and mental health, but does not answer a big question. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Health Report.

A new study suggests that the more teenagers watch television, the more likely they are to develop depression as young adults. But the extent to which TV may or may not be to blame is a question that the study leaves unanswered.

The researchers used a national long-term

of adolescent health to investigate the

relationship between media use and depression. They based their findings on more than four thousand adolescents who were not depressed when the survey began in nineteen ninety-five.

As part of the survey, the young people were asked how many

of television or videos and

they watched daily. They were also asked how often they played computer listened to the radio.

Media use totaled an average of five and one-half hours a day. More than two hours of that was spent watching TV.

Seven years later, in two thousand two, more than seven percent of the young people had signs of depression. The average at that time was twenty-one.

Brian Primack at the University of Pittsburgh medical school was the lead author of the new study. He says every hour of television meant an eight percent increase in the

chances of developing signs of depression.

The researchers say they did not find any such relationship with the use of other media such as movies, video games or radio. But the study did find that young men were more likely than young women to develop depression given the same of media use.

Doctor Primack says the study did not explore if watching TV

depression. But one

possibility, he says, is that it may take time away from activities that could help prevent depression, like and socializing. It might also interfere with , he says, and that

could have an influence.

The study was just published in the Archives of General Psychiatry.

In December, the journal Social Indicators Research published a study of activities that help lead to happy . Sociologists from the University of Maryland found that people who

describe themselves as happy spend less time watching television than unhappy people. The study found that happy people are more likely to be services and to vote. active, to read, attend religious

Making a Solar Water Heater

Topic: Directions for a system that can heat seventy liters of water to sixty degrees Celsius. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Development Report.

Solar water heaters are devices that use energy from the sun to heat water. Solar water heating is used around the world.

The solar water heater described here is based on a design developed some years ago in Afghanistan. Since then, it has been built and used in many countries. It can heat seventy liters of water to sixty degrees Celsius. It can do this between and noon on a clear

day with an average outside temperature of thirty-two degrees Celsius.

There are two parts to the solar water heater. One part is made of a

of metal painted

black. This metal surface, placed in contact with the water, will heat the water. Blackpainted surfaces that receive the sun's heat become hotter than surfaces of any other color.

The black metal plate is called a

. There are several kinds of metal sheets that can be

used for the collector. Metal sheets that have raised sections will work very well. These

corrugated sheets often are used to make the roofs of houses.

Once the water is heated, it is kept hot with material called insulation. This allows the water to stay for a long time.

The second part of the solar water heater holds the water for the system. This storage can be a container that holds about one hundred liters. Two rubber pipes are attached to the water storage tank. One pipe lets water flow into the system. The other lets water flow out.

When the water heater is working correctly, water will flow from the storage

to the

collector and back again. You can use the hot water at the top of the tank for washing and cleaning. You can change the flow of water so that the temperature is hot or warm as desired.

This solar water heater is easy to build and rubber pipes need to be replaced.

. It will last about two years before the

There is also something else you will need to make the solar water heater work -- the sun. As you might expect, the heater will heat water only on days.

You can get more information about projects like solar water heaters from EnterpriseWorks/VITA. This nonprofit group works to fights poverty in many countries. The Web site is enterpriseworks.org. Choose the link for News & Resources, then click on Publications.

Transcripts, MP3s and podcasts of our reports are at voaspecialenglish.com.

Rural Areas of Kenya Get Connected to the Web

Topic: A solar-powered system, designed by young engineers in the U.S., brings the Internet to communities by satellite. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Development Report.

Some rural Kenya.

engineers from the United States have brought the Internet to several areas of

Their idea was to connect the communities to the Web by satellite. But there was a problem. The areas are not even connected to Kenya's electric power supply. The answer: solar . Energy from the sun powers the satellite dishes and computers that link the areas with the world outside.

Kelly Moran, Joan Ervin and Trisha Donajkowski spent ten days in Kenya in November. The women recently earned master's degrees in space systems engineering from the University of Michigan.

Another engineer, Drew Heckathorn, did not go to Africa but worked on parts of the

Kelly Moran says there was excitement when the team would arrive to connect communities to the Internet. People would sometimes run alongside the car carrying the engineers to them. And local residents would offer to help the team build the Internet stations.

People now have access to educational, medical and all kinds of other information. Farmers, for example, can easily find weather, crop and information online.

The project began back at the college of engineering in Ann Arbor, Michigan, in two thousand seven. That was when twenty-five students in a talked about the idea. taught by Thomas Zurbuchen first

The goal was to test whether Internet stations could be set up, how much they would cost, and how long they could operate. But the engineers also had to consider others things -- like social . Students from the public health and business schools offered advice.

The young engineers also had to design the equipment to survive the heat in Africa. Professor Zurbuchen praises his former students for "making something work in a different climate far away from home."

Google paid for the final design of the equipment. The company is also supporting the costs of

the satellite bandwidth needed for the

. Google has invested in a new company that

wants to put up a system of satellites over Africa. The availability of more satellites would reduce the costs.

Just five percent of Africans have Internet connections. The International Telecommunication Union says one-third of Kenyans have mobile well with the Internet. . But mobile phones may or may not work

Home Gardening: What to Do About Lead

Topic: The first step is to test soil to see if there is a danger. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Agriculture Report.

Soil naturally contains harmless amounts of lead, along with other metals. Because of pollution, however, the amounts are higher the closer you get to cities and towns. But experts say this should not stop gardeners from growing if they take safety measures.

David Johnson is a chemistry professor in the State University of New York's College of Environmental Science and Forestry. He explains that lead can enter the paint and leaded fuel and from industry. from leaded

And once lead gets into the soil, it stays a long

. It remains an environmental threat

especially to children. Lead can harm mental and physical development even in babies before they are born.

If a test finds that soil has too much lead, you might be advised to remove the soil or cover it with sod grass. Different have different levels that they consider acceptable.

Carl Rosen of the University of Minnesota Extension notes that concerns about lead have increased now that more people are planting gardens. But Professor Rosen says plants generally do not much lead. He says there is likely more risk from lead dust on plants

or from playing in the soil than from the plant itself.

Still, some plants do absorb more than others. Experts say good choices for the garden include , peppers, beans and okra. Among the plants that can absorb more . If you grow carrots, for

contaminants, they say, are root crops, leafy vegetables and

example, you might want to peel them. Dirt may be harder to remove from some crops than from others. But all produce should be washed.

Gardens should be planted away from roads and structures, especially old buildings. Home gardeners should plant away from the foundation of their especially high near industrial areas and waste dumps. . And lead amounts can be

Soil should also be tested for its pH level, a measure of the acid and alkaline balance. Experts say the ability to take up lead is when the pH level is above six and a half. Adding

organic material such as compost to soil can also make lead less available to plants.

Some people attempt a process called phytoremediation. They try to remove lead from soil by growing certain plants that collect it. But Professor Rosen says the process is may not work. and

Going Digital: The Future of College Textbooks?

Topic: Sales of e-textbooks are expected to grow in the coming years. But experts say the popularity may be limited until more books are interactive. Second of two parts. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Education Report. The average college student in America spent an estimated seven dollars on textbooks last year. The National Association of College Stores reported more than five billion dollars in sales of textbooks and course materials. Association spokesman Charles Schmidt says electronic textbooks now represent just two to three percent of thousand twelve. . But he says that is expected to reach ten to fifteen percent by two

Online versions are now available for many of the most popular college textbooks. Etextbooks can cost half the of a new print textbook. But students usually lose access after the end of the term. And the books cannot be placed on more than one device, so they are not to share.

So what do students think of e-textbooks? Administrators at Northwest Missouri State University wanted to find out. Earlier this year they tested them with five hundred students in twenty .

The university is unusual. It not only provides laptop computers to all seven thousand of its full-time to save . It does not require students to buy their textbooks either. They rent them . The school aims to save even more by moving to e-textbooks.

The students in the survey reported that downloading the books from the Internet was easy. They liked the idea of carrying lighter able to find information. . And fifty-six percent said they were better

But most found that using e-textbooks did not their study habits. And sixty percent felt they read more when they were reading on paper. In all, almost half the students said they still liked physical textbooks .

But the survey found that cost could be a big influence. Fifty-five percent said they would choose e-textbooks if using them meant their textbook fee would not increase.

Roger Von Holzen heads the Center for Information Technology in Education at Northwest Missouri State. He tells us that administrators are disappointed with the e-textbooks now available because the majority are not .

He thinks growth will come when more digital books include video, activities, and other ways to interact with the information. The technology is improving. But for now, most of the books are just words on a .

Study Finds More Trees on Farms Than Was Thought


Topic: Researchers using satellite imagery found that nearly half of the world's farmland has at least 10 percent tree cover. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Agriculture Report.

Farmers, especially in developing countries, are often criticized for

down forests. But

a new study suggests that many farmers recognize the value in keeping trees.

Researchers using

images found at least ten percent tree cover on more than one

billion hectares of farmland. That is almost half the farmland in the world.

The World Agroforestry Center in Kenya led the study. The findings were reported last week in Nairobi at the second World Congress of Agroforestry.

Earlier estimates were much lower but underestimate the true extent worldwide.

. The authors of the new study say it may still

The study found the most tree cover in South America. Next comes Africa south of the Sahara, followed by Southeast Asia. North Africa and West Asia have the least.

The study found that climate conditions

could not explain the amount of tree cover in

different areas. Nor could the size of nearby populations, meaning people and trees can live together.

There are areas with few trees but also few people, and areas with many trees and many people. The findings suggest that things like land rights, influence tree planting and protection. or government policies can

Dennis Garrity heads the World Agroforestry Center. He says farmers are acting on their own to and plant trees. The problem, he says, is that policy makers and planners have

been slow to recognize this and to support such efforts.

The satellite images may not show what the farmers are using the trees for, but trees provide nuts, , wood and other products. They provide windbreaks and shade from the sun.

They also help prevent soil loss and protect water supplies. Even under drought conditions, trees can often provide food and a way to earn until the next growing season.

The important thing, says one expert, is to find the right tree for the right place for the right use.

Some trees act as natural fertilizers. They take nitrogen out of the air and put it in the soil. Scientists at the Agroforestry Center say the use of fertilizer trees can the need for

chemical nitrogen by up to three-fourths. And they say it can double or triple crop

production.

Trees also capture carbon dioxide, a gas linked to climate change.

Wangari Maathai is a Kenyan environmentalist and Nobel Peace Prize winner. She says the study shows that trees are to agricultural production everywhere.

In the US, the New Look of Gas Exploration

Topic: Some see gas shale development as a way to fight global warming and reduce the need for oil. But low prices and a danger of water pollution could hurt an industry led by small to medium companies. Transcript of radio broadcast. Source: VOA Escucha el audio y completa los recuadros. Click aqu para escuchar This is the VOA Special English Economics Report.

Many people think the search for cleaner energy leads only to renewable resources like sun, wind and . But it also leads to a fossil fuel. Natural gas is considered the cleanest of

the fossil fuels, the fuels created by plant and animal remains over millions of years.

Burning it releases fewer pollutants than oil or coal. The gas is mainly methane. It produces half the carbon dioxide of other fossil fuels. So it may help cut the linked to climate change. of carbon gases

Russia is first in what are called "proved reserves" of natural gas. The United States is sixth. Over the years, big oil and gas companies much of the easily reached supplies of gas

in America. They drilled straight down into formations where gas collects. As these supplies were used up, big drillers looked for similar formations in other countries.

But now the industry is taking a new look. Companies are developing gas supplies trapped in shale rock two to three thousand meters underground. They drill down to the shale, then go sideways and inject high-pressure water, sand or other material into the rock.

This causes the

to break, or fracture, releasing the gas. Huge fields of gas shale are

believed to lie under the Appalachian Mountains, Michigan and the south-central states.

Gas shale exploration is being done mainly by

to medium sized companies.

Eric Potter is a program director in the Bureau of Economic Geology at the University of Texas at Austin.

ERIC POTTER: "The types of opportunities that are left for natural gas exploration in the U.S. have changed. So it's a different class of resource -- not as recognized as something worth pursuing, say, twenty years ago." to develop, and not even

He says more than half the gas in the United States is now coming from these new reserves.

But hydraulic fracturing can also produce debate and anger over the

of groundwater

pollution. This method of drilling is not federally supervised under the Safe Drinking Water Act. Some in Congress want to end that exemption from the law.

Natural gas provides Americans with about one-fourth of their energy. And, unlike oil, most of it is produced in America. Gas producers invested heavily in reaching new supplies when were high. But prices are down sharply now because the recession cut demand for energy. So energy expert Eric Potter says it is too early to know how the new gas shale reserves will affect the .

Das könnte Ihnen auch gefallen