Sie sind auf Seite 1von 1

Attachment 2 of Open Season Notice SPECIFICATION SHEET FOR LIGHT CONDENSATE

Light Condensate Specifications at Kankakee County, Illinois Receiving Point [Excerpted from Rule 4 of the Cochin Light Condensate Rules and Regulations]
a. Shipper shall not deliver to Carrier and Carrier shall not be obligated to accept Light Condensate that, as determined by Carrier, has on receipt: i. qualities which are outside of the minimum and maximum ranges specified in the following table: Units kg/m3 cSt F vol% mg/l kPa Wt% wppm S wppm vol% vol% wppm wppb Min 600 Max 775 2.0 100 0.5 200 103 0.5 175 20 1.6 2.0 100 10 Referee Test Method ASTM D4052 D445 D95 D4807 Procedure C D323M D5453 D5623 D5623 PONAOX(U) D6729 PONAOX(U) D6729 PONAOX(U) D6729 UOP 938

Quality Density Kinematic Viscosity (7.5 C) Temperature Sediment & Water Filterable Solids Reid Vapour Pressure Sulfur, total Mercaptans, volatile C1, C2, C3 H2S (in liquid phase) Benzene Aromatics, total (BTEX) Oxygenates Mercury ii. iii. iv.

any untreated cracked material which will include, but will not be limited to, coker by products, olefin plant by products and cat cracked stocks; any organic chlorides; physical or chemical characteristics that may render such Light Condensate not readily transportable by Carrier or that may materially affect the quality of other commodities transported by Carrier or that may otherwise cause disadvantage to Carrier; and any characteristics that are inconsistent with the Light Condensate Acceptance Practice referenced in Rule 23.

v.

In the event of any conflict or discrepancy between clauses (i) through (iv) above, on the one hand, and the Light Condensate Acceptance Practice referenced in clause (v), on the other, whichever is the more stringent shall apply. Shipper shall not deliver to Carrier and Carrier shall not be obliged to accept Light Condensate that is inconsistent with the NAFTA Practice referenced in Rule 23. b. Shipper shall, as required by Carrier, provide to Carrier a certificate with respect to the specifications of Light Condensate listed in (i) through (v) above to be received by Carrier from Shipper. If Shipper fails to provide Carrier with such certificate, then Carrier will not be obligated to accept Shipper's Light Condensate. If Carrier determines that a Shipper does not comply with the provisions of paragraph (a) of this Rule 4, then such Shipper shall remove its Light Condensate from the Cochin Pipeline as directed by Carrier.

c.

Page 1 of 1

Das könnte Ihnen auch gefallen