Beruflich Dokumente
Kultur Dokumente
(Epoxy Primer)
Test Abrasion
Test Method ASTM D 4060 - Abrasion resistance of organic coatings by the Taber Abraser"
Typical Results Average of 175 mg weight loss per 1000 cycles using CS 10 Wheels and 1 Kg loading Classification 0
Adhesion
1 x 75 microns dft applied directly on Sa 2.5 blasted mild steel panel 1 x 75 microns dft of Apcothane CF 678 applied over 1 x 75 microns dft of Apcodur EHB Zinc Phosphate Primer 1 x 75 microns applied directly to Sa 2.5 blasted
Adhesion
Classification 0
Adhesion
IS0 4624/ ASTM D 4541 - "Pull-off test for adhesion" using portable adhesion testers
Not less than 7 MPA (1015 psi) when using a PAT Model GM01 hydraulic adhesion tester on 2 mm panel Not less than 7 MPA (1015 psi) when using a PAT Model GM01 hydraulic adhesion tester on 2 mm panel
Adhesion
IS0 4624/ ASTM D 4541 - Pull-off test for adhesion" using portable adhesion testers
75 microns of Apcodur EHB Zinc Phosphate Primer topcoated with 1) 75 microns of Apcothane CF 678 2) 35 microns of Apcothane CF 674/ Apcothane CF 675 1 x 75 microns dft applied directly on Sa 2.5 blasted mild steel panel and tested after 48 hours of air drying 1 x 75 microns applied directly to Sa 2.5 blasted steel 1 x 75 microns dft applied directly on Sa 2.5 blasted mild steel panel
Flexibility
Hardness
Test Method : ASTM D 3363 - "Film hardness by pencil test" ASTM D 2794 - "Resistance of organic coatings to the effects of rapid deformation (Impact)" IS 101 (Part 6/ Sec 1) 1988 "Resistance to humidity under condition of condensation" ASTM B 117 - "Operating Salt Spray (Fog) Apparatus"
Classification 2H
Impact
Condensation
1 x 75 microns dft applied directly on Sa 2.5 blasted mild steel panel 1 x 75 microns dft applied directly on Sa 2.5 blasted mild steel panel
No film defects following 1000 hours exposure No film defects following 1500 hours exposure and less than 1 mm rust creep at scribe No film defects following 1500 hours exposure and less than 1 mm rust creep at scribe
Salt Spray
Salt Spray
Disclaimer: The performance data provided is based on laboratory test conditions and actual performance will depend upon the conditions under which the product is used. To the best of our knowledge the information provided herein are true and accurate at the date of issuance. Since we have no control over the quality or condition of the substrate or the various factors affecting the use and application of the product, we do not accept any responsibility or liability arising out of use of the product. The company reserves the right to modify data contained herein without prior notice. Any change in data would normally be followed by issue of a new data-sheet. The user should check with the nearest sales office of the company and confirm the validity of the information, prior to using the product
Regd. Office: Asian Paints Ltd. 6 A, Shanti Nagar, Santacruz (E), Mumbai 400 055, India. Tel: 022 - 39818000, Fax: 022 39818888, E-mail: customercare@asianpaints.com Website: www.asianpaints.com
April2009 PC 1343