Beruflich Dokumente
Kultur Dokumente
1
I B.Tech Supplimentary Examinations, Aug/Sep 2007
INTRODUCTION TO CHEMICAL ENGINEERING
(Chemical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) Write the physical significance of any four dimensional groups. [4×2=8]
i. Sherwood number
ii. Schmidt number
iii. Prandtl number
iv. Match number
v. Froude number
vi. Euler number
(b) Explain the Geometric, kinematic and dynamic similarities useful for a process.
[8]
2. (a) Write about velocity gradient and rate of shear for steady flow.
(b) Write about mechanism of fluid flow. [6+10]
3. Write about enlargement and contraction losses in closed pipe lines? [16]
4. Explain the boiling point elevation and Duhring’s rule? [16]
5. (a) Prove that for a binary gas mixture, the diffusivity of A in B equals the
diffusivity of B in A.
(b) Why is it suggested that sulphur trioxide be absorbed in concentrated sul-
phuric acid rather than in water. [8+8]
6. (a) Write about selection of dispersed phase in liquid liquid extraction.
(b) Describe rotating disc contactor and centrifugal extractor. [4+12]
7. (a) What are the two main categories into which industrial liquid-liquid contactors
are classified? Discuss about each category.
(b) Describe the construction and working of a rotating disc contactor. Where is
it used and what are its advantages? [6+10]
8. (a) Define the following terms pertaining to drying:
i. Free moisture content
ii. Wet basis
iii. Dry basis
iv. Moisture gradient
(b) Discuss in detail about the drum dryer with a neat diagram. [8+8]
⋆⋆⋆⋆⋆
1 of 1
Code No: RR10803 Set No. 2
I B.Tech Supplimentary Examinations, Aug/Sep 2007
INTRODUCTION TO CHEMICAL ENGINEERING
(Chemical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) Explain briefly the material, momentum and energy balances used in an op-
eration.
(b) What an ideal gas is? Write on perfect gas mixture. [8+8]
2. For a fluid transfer system write the total energy balance for steady flow and explain
each term in the resulting expression. [16]
5. (a) Prove that for a binary gas mixture, the diffusivity of A in B equals the
diffusivity of B in A.
(b) Why is it suggested that sulphur trioxide be absorbed in concentrated sul-
phuric acid rather than in water. [8+8]
6. (a) Write briefly about the selection of equipment for gas-liquid operations.
(b) Write briefly about the selection of solvent in liquid-liquid extraction. [10+6]
7. (a) Describe the construction and working of a rotating disc contactor. Where is
it used and what are its advantages?
(b) Explain how interdispersion of liquids and separation of phases is achieved
in a centrifugal extractor? Mention the uses and advantages of a centrifugal
extractor. [10+6]
⋆⋆⋆⋆⋆
1 of 1
Code No: RR10803 Set No. 3
I B.Tech Supplimentary Examinations, Aug/Sep 2007
INTRODUCTION TO CHEMICAL ENGINEERING
(Chemical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) Explain briefly the material, momentum and energy balances used in an op-
eration.
(b) What an ideal gas is? Write on perfect gas mixture. [8+8]
2. (a) Derive an expression for the thickness of the boundary layer ‘δ ’ for the flow
of a fluid part a flat plate at zero incidence.
(b) For a gas obeying the equations of state, calculate the isothermal compress-
ibility and the coefficient of thermal expansion. [8+8]
7. (a) Write in detail about centrifugal extractors. What are its uses and advantages?
(b) Write about the construction and operation of mixer-settlers with neat dia-
grams. Mention their uses and advantages. [6+10]
8. (a) Define drying. How is it different from evaporation, dehydration, freeze- drying
and gas drying?
(b) Explain how heat and mass transfer occur simultaneously during drying. Men-
tion the uses of drying operation. [10+6]
⋆⋆⋆⋆⋆
1 of 1
Code No: RR10803 Set No. 4
I B.Tech Supplimentary Examinations, Aug/Sep 2007
INTRODUCTION TO CHEMICAL ENGINEERING
(Chemical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
2. (a) Write about velocity gradient and rate of shear for steady flow.
(b) Write about mechanism of fluid flow. [6+10]
3. Write about transition length for laminar and turbulent flow in a tube? [16]
4. Draw a neat diagram of single-pass tubular condenser and explain its working?
[16]
7. (a) What do you understand by the term distribution coefficient with respect
to liquid-liquid extraction? Explain with reference to dilute solutions and
concentrated solutions.
(b) The selection of the phase to be dispersed depends on various considerations.
What are they?
(c) Describe the single stage equilibrium extraction with an example. [6+4+6]
8. (a) Define drying. How is it different from evaporation, dehydration, freeze- drying
and gas drying?
(b) Explain how heat and mass transfer occur simultaneously during drying. Men-
tion the uses of drying operation. [10+6]
⋆⋆⋆⋆⋆
1 of 1