Beruflich Dokumente
Kultur Dokumente
RSS SET UP
Line Adapter
A293X000.WMF
1 2-3 0
2 2-3 1
3 2-3 2
4 2-3 3
5 1-2 4
!CAUTION
Unplug the machine power cord before starting the following procedure. NOTE: When connecting only one machine to the line adapter, start from step 5. 1. Remove the ADF connector [A] and rear cover [B] (2 screws). 2. Set the jumper switch [C] on the IOB as shown (default setting is 1-2). 3. Reinstall the rear cover and DF connector. 4. Set the PI device code with SP5-821 (default 0). NOTE: After changing the value, turn the main power switch off and on to enable the PI device code. 5. Connect the modular cord [D] to the right modular connector, as shown. 6. Install the line adapter (refer to chapter 2-1 L-ADP Installation Procedure in the CSS L-ADP Service Manual).
APPENDIX-1
SP MODE SETTING
11 July 2000
APPENDIX-2
11 July 2000
JAM HISTORY
The last 5 digits of the total counter value at jam occur Paper Size Jam Condition
A229I539.WMF
APPENDIX-3
11 July 2000
Condition Finisher entrance sensor: paper does not activate the sensor Finisher upper tray exit sensor: paper does not activate the sensor Finisher shift tray exit sensor: paper does not activate the sensor Finisher staple tray paper sensor: paper does not activate the sensor Finisher stack feed-out belt HP sensor: paper does not activate the sensor Mail box entrance sensor: paper does not activate the sensor Mail box proof tray exit sensor: paper does not activate the sensor Mail box relay sensor: paper does not activate the sensor Mail box sensor: paper does not activate the sensor By-pass tray: paper non-feed jam Stapler tray entrance sensor: Paper does not activate the sensor Entrance sensor (Booklet FIN)-Late: Paper does not activate the sensor Transport (Booklet FIN): Paper stays in the finisher unit Entrance sensor (Booklet FIN): Paper activates the sensor too early Staple: Finisher Unit Booklet entrance sensor: Paper does not activate the sensor Booklet transport sensor: Paper stays in the booklet unit Staple: Booklet Unit 1st paper feed sensor: Paper stays at the sensor 2nd paper feed sensor: Paper stays at the sensor 3rd paper feed sensor: Paper stays at the sensor LCT relay sensor: Paper stays at the sensor Relay sensor: Paper stays at the sensor Registration sensor: Paper stays at the sensor 2nd exit sensor: Paper stays at the sensor Duplex entrance sensor: Paper stays at the sensor Duplex transport sensor 2: Paper stays at the sensor Duplex transport sensor 3: Paper stays at the sensor
Document Feeder
Code 01 03 04 Condition Jams at power on Jams in the feed-in area Jams in the feed-out area
APPENDIX-4
11 July 2000
OTHERS
1.5 OTHERS
1.5.1 SC630 [RDS COMMUNICATION ERROR]
Frequent occurrence of SC630 indicates a problem in the customers communication line or line adapter. To maintain the communications environment in good working order, it is necessary to contact planned inspections periodically.
APPENDIX-5