INTERNATIONAL Iso
STANDARD 7919-4
Fist edtior
1996-07-15,
Mechanical vibration of non-reciprocating
machines — Measurements on rotating
shafts and evaluation criteria —
Part 4:
Gas turbine sets
Vibrations mecaciguss obs machines non aftamatives ~ Mesirages sur
Ine arbens thumants ot ecteras eavaluatinn
Partie 4 Turbines a gaz
ference number
180 7919-4 : 1996 (E)
673Foreword
ISO (the Intemational Cirganization for Standarcization) Is @ worldwide
federation of national standards bodies (ISO member bodies). The work at
preparing Intemational Standards Is normally carrisd out through ISO.
technical comminees. Each member noay interested n a subject for which
a technical committee has heen established has the right to be represented
on that committee. Intemational organizations, governmental an
on-governmental, In liaison with ISO, also take part in the work. ISO
collaborates closely with the International Electrotechnical Commission (IEC)
(on all matters of clectrotechnical standardization.
Dran Intemational Standards adopted ty me tecmical comminees are
circulated to the member bodies for voting. Publication as an Intemational
Standard requires approval by at least 75% of the member bodies casting a
vote.
International Standard (SQ 7919-4 was prepared by Technical Committee
ISQ/TC 108, Mechanical vibration and shock, Subcommittee SC 2,
Measurement and evaluation of mechanical vibration and shock as applied
to machines, vehicles and structures.
ISO 7919 consists of tne following pans, under tne general tile Mechanical
‘wiration of non-reciprocatiig machines - Measurements on rotating shafts
and evaluation criteria:
Part 1: General guidelines
~ Part 2: Large land-basec steam turbine generator sats
Part 3 Coupled industria machines
Part 4: Gas turbine sets
~ Pail 5: Machine sets in hydraulic power generating and vumping
plants
~ Parl 5: Machine sels in hydraulic power generaling and pumping
plants
10 1996
All rights reserved. Unless oherwise specified, no pan of this publeation may be
reproduced
or uulzed In any form or by any means, electronic or mechanical. cluging
photovopying ard microti, wihout permission in yaitny thor the publishes
Interaational Organization for Standardization
Case Postalo 58 CH-1211 Geneve 20 Switzerland
Printed In Switzertand
674Introduction
‘This part of ISO 7919 deals with the special features required for measuring
transverse shaft vioration cn the coupled rator systems of gas turbine sets.
Evaluation crteta, based on previous experience, are presented which may
be used as guidelines for assessing the vibratory conditions Of such
machines,
A general desertion of the principles which are generally applleable for the
measurement and evaluation of shaft vibration of non-reciprocating
machines is given in ISO 7919-1
675