Sie sind auf Seite 1von 16

R Mini Dome (NDOOR) Camera

User ManuaI
ModeI : AA - 4525P - FSR1
AA - 4825P - FSR1
CAUTON : TO REDUCE THE RSK OF
ELECTRC SHOCK
DO NOT REMOVE COVER (OR BACK)
NO USER-SERVCEABLE PARTS
NSDE REFER SERVCNG TO
QUALFED SERVCE PERSONNEL.

This lighting flash with arrowhead symbol within an equilateral triangle is


intended to alert the user to the presence of uninsulated dangerous voltage within
the product's enclosure that may be of sufficient magnitude to constitute a risk of
electric shock to persons.
The exclamation point within an equilateral triangle is intended to alert the user to
the presence of important operating and maintenance instruction in the literature
accompanying the product.
FCC WARNING : This equipment may generate or use radio frequency energy. Changes
or modifications to this equipment may cause harmful interference unless the
modifications are expressly approved in the user manual. The user could lose the authority
to operate this equipment if an unauthorized change or modification is made
This equipment has been tested and found to comply with the limits for a class A digital
device, pursuant to part 15 of the FCC Rules. These limits are designed to provide
reasonable protection against harmful interference when the equipment is operated in a
commercial environment
CAUTON
RSK OF ELECTRC SHOCK
DO NOT OPEN

This equipment generates, uses, and can radiate radio frequency energy and, if not
installed and used in accordance with the instruction manual, may cause harmful
interference to radio communications.
Operation of this equipment in a residential area is likely to cause harmful interference in
which case the user will be required to correct the interference at his own expenses.
Asuitable conduit entries, knock-outs or glands shall be provided in the cable entries of this
product in the end user.
Caution: Danger of explosion if battery is incorrectly replaced. Replace only with the same
or equivalent type recommended by the manufacturer. Dispose of used batteries
according to the manufacturer's instructions.
Holes in meta, through which insulated wires pass, shall have smooth well rounded
surfaces or shall be provided with brushing.
WARNING: Do not install this equipment in a confined space such as a bookcase or
similar unit.
WARNING: Wiring methods shall be in accordance with the National Electric Code,
ANS/NFPA70.
WARNING: This is a class A product. n a domestic environment this product may cause
radio interference in which case the user may be required to take adequate measures.
WARNING: To reduce a risk of fire or electric shock, do not expose this product to rain or
moisture.
Caution: This installation should be made by a qualified service person and should confirm
to all local codes.
Caution: To avoid electrical shock, do not open the cabinet. Refer servicing to qualified
personnel only.
To disconnect power from the mains, pull out the mains cord plug.
While installing the product, ensure that the plug is easily accessible.

Caution: The apparatus should not be exposed to water and no objects filled with liquids, such as
vases, should be placed on the apparatus.
DisposaI of your oId appIiance
1. When this crossed-out wheeled bin symbol is attached to a product it means the
product is covered by the European Directive 2002/96/EC
2. All electrical and electronic products should be disposed of separately from the
municipal waste stream via designated collection facilities appointed by the
government or the local authorities.
3. The correct disposal of your old appliance will help prevent potential negative
consequences for the environment and human health.
4. For more detailed information about disposal of your old appliance, please contact
your city office, waste disposal service or the shop from where you purchased the
product.
Important Safety Instructions
1. Read these instructions.-All these safety and user instructions should be read before the
product is operated.
2. Keep these instructions:- The safety, operating and user instructions should be retained for
future references.
3. Read all warnings :- All warnings on the product and in the operating instructions should be
adhered to.
4. Followall instructions:- All operating and user instructions should be followed.
5. Do not use this apparatus near water :- e.g near swimming pool ,Bathroom, wet walls.
6. Clean Only with dry cloth:- Unplug the power supply and then clean with dry cloth.
7. Do not block any ventilation openings, install in accordance with the mfg instructions:- Kindly
provide some air ventilation in any form. The opening should never be blocked by placing the
product on a bed, sofa, fug or other similar surface.
8. Do not install near any heat sources such as radiators, heat registers, stoves or other
apparatus that produce heat.
9. Protect the power cord from being walked on or pinched particularly at plugs, convenience
receptacles, and the pint where they exit from the apparatus.
10. Only use attachments/accessories specified by the manufacturer.
11. Use only with the cart, stand, tripod, bracket, or table specified by the
manufacturer, or sold with the apparatus. When a cart is used use caution
when moving the cart/apparatus combination to avoid injury from tip over.
12. Unplug this apparatus during lighting storms or when unused for long periods
of time.
13. Refer all servicing to qualified service personnel. Servicing is required when the apparatus has
been damaged in any way, such as power supply cord or plug is damaged.

Safety Precautions
Do not attempt to disassembIe the camera.
To Prevent electric shock, do not remove screws or covers. There are no user serviceable parts
inside. Ask a qualified service personnel for servicing.
Do not use strong soIvents or detergents.
Use a dry cloth to the camera when it is dirty. f it is hard to remove the dirt on the camera, Use a
mild detergent and wipe it gently.
Before operating, pIease check proper temperature, humidity and power source
ratings.
Use the camera under conditions where temperature is between -10C~+50C.
Do not expose the camera in such conditions as shown beIow.
User in a room or area filled with cigarettes smoke, dust or gas.
Avoid the camera with direct sunIight
Do not aim the camera at bright objects. Never face it with direct sunlight or other extremely
bright objects.
Otherwise blooming or smear may be caused.
HandIe the camera with care
Do not abuse the camera .Avoid striking, shaking, etc. The camera could be damaged by
improper handling or storage.
Do not expose the camera to rain or moisture
This product is designed for indoor use or location where it is protected from rain and moisture.

Contents
Cautions for Safe Operation ........................................................ 08
Box contains ............................................................................... 09
Construction ............................................................................... 10
nstallation .................................................................................. 12
Troubleshooting .......................................................................... 14
Specification ............................................................................... 15

Cautions for Safe Operation


Power SuppIy
This camera must always be operated a DC12Vonly.
HandIing of the unit
Be careful not to spill water or other liquids on the unit. Be cautious not to
get combustible or metallic material inside the body. f used with foreign
matter inside, the camera is liable to fail or to get a cause of fire or electric
shock.
Operating and storage Iocation
Avoid viewing a very bright object during an extended period. Avoid
operating or storing the unit in the following locations.
Extremely hot or cold places( -10C~+50CWe recommend to use unit in
between 0C ~+45C)
Damp or dust place
Places exposed to rain
Places subject to strong vibration
Close to generators of powerful electromagnetic radiation such as radio
or TVtransmitters.
08
Box contains
09
Camera
Cable
DC Power Plug
Video BNC Plug
Front View
Screws
Construction
10
Front View
Dome
Cover Ring
R
R Sensor
Lens
Construction
11
Inner View
R
Lens
R Sensor
Cable
InstaIIation
1. Draw out power / video wires from
required place.
2. Fix the screws on the ceiling.
3. Connect the cable through out the
groove side of camera
4. Loose screws for adjusting camera
angle to upward or downward & right
or left.
5. Loose the Dome Top Cover , adjust the
camera angle to required direction.
6. After installation, view the images by
connecting the camera with monitor.
12
InstaIIation
13
Power
Video
Cable
TroubIeshooting
Check the foIIowing guide for the possibIe cause of a probIem
before contacting service.
The picture is poor
- Does the Dome Cover have lots of dust on the surface?
- Use a dry cloth to clean the camera when the glass is dirty.
Smear may be caused to the screen of night than day time.
-Adjust the Focus by moving the Focus Lens.
-Ris not on then check the sensor must be working or there should not be sufficient light.
Contrast of the screen is not cIear
- Check the condition of the monitor.
A Iight source such as a spot Iight causes burning on the dispIay screen.
Adjust position or angle of the camera to eliminate strong background light.
14
Specification
15
ModeI AA-4525P-FSR1 AA-4825P-FSR1
mage Sensor Sony 1/3 Super HAD CCD
Picture elements(Effective Pixels) PAL -500(H) * 582(V)
NTSC - 510(H) * 494(V)
Scanning System 2:1 nterlace
Scanning Frequency PAL H: 15.625 KHz V:50Hz
NTSC H:15.734Khz V:60Hz
Horizontal Resolution 450 TVL 480 TVL
S/N Ratio >48 db
Shutter Speed 1/50(60) -1/20000s
Back Light Compensation(BLC) Auto
Gain Control (AGC) Auto Adjusted according to Lux Level(15dB - 30dB)
White Balance ATW
Min. llumination 0.05 Lux @ F 1.2 , 0 Lux with R LED ON
R LED 8Pcs RLED, 0.5
REffect Distance 8 Mtr approx
Focal Length 3.6 MM M12 Lens
Specification
16 www.avtrontech.com
Aperture f/1.2
nput voltage DC12V+- 10%, DCCable Connector
Video Output Level 1V p-p,75 BNC connectors
Power Consumption <150mA@ 12VDC @ Night Time with RLEDON
Operating Temperature -10 to ~ + 50C
Operating Humidity Up to 90%
Dimension 71mm (W) x 53.5(H)mm
Enclosure Power Coated Metal Case with Plastic Dome Cover
Weight 126 g (W/O Box)

Das könnte Ihnen auch gefallen