Beruflich Dokumente
Kultur Dokumente
Quick introduction about UDOO UDOO is an newly launched multi Development platfrom solution for Linux,Android,Arduino and Google ADK(2012).It has main processor as iMX6 ARMCORTEX A9 from freescale.1GHz and RAM 1 GB DDR3.And it has the ARM Cortex-M3 controller which is same as Arduino DUE
Distributions Ubuntu 12.04 Android 4.2.2 Jelly Bean Arduino IDE (by default) Features Freescale i.MX 6 ARM Cortex-A9 CPU Dual/Quad core 1GHz Integrated graphics, each processor provides 3 separated accelerators for 2D, OpenGL ES2.0 3D and OpenVG Atmel SAM3X8E ARM Cortex-M3 CPU (same as Arduino Due) RAM DDR3 1GB 76 fully available GPIO Arduino-compatible R3 1.0 pinout HDMI and LVDS + Touch (I2C signals) Ethernet RJ45 (10/100/1000 MBit) WiFi Module Mini USB and Mini USB OTG USB type A (x2) and USB connector (requires a specific wire) Analog Audio and Mic SATA (Only Quad-Core version) Camera connection Micro SD (boot device) Power Supply 12V and External Battery connector
Booting Ubuntu on UDOO Steps for porting image to micro SD card Step 1: Download the Win32 Disk Imager(tool for porting an image) from the here. Insert your microSD Card and then run Win32 Disk Imager.exe. It may give an error message on startup, but you can often ignore it. It should find your SD Card drive or if not select it. You can get the prebuilt image from here. Unzip and select the file '#.img' image file you wish to use and then press write. Once it completes you are ready to go, insert your microSD card into the UDOO micro SD slot(I am using UDOO Quad)
Selecting Drive
Backup
Step 2: Click write button and select your image as per the image shown below. After ten minutes it will display a successful message.
Step 3: Insert the micro SD card.Connect the power adapter 12v 2A,then HDMI cable for video out,usb keyboard and mouse.For internet connection i am using inbuilt Wi-Fi.
Step 4: After powering up the board ,ubuntu 11.10 starts booting.It wont ask for username and password,directly go to the Desktop.you can find the Desktop picture of UDOO below. UDOO Desktop
Scilab installation on UDOO For more details about click here Step 1: sudo apt-get update
Step 2: Make sure the java is installed in the system using by the following command. $ java version
Step 3: Install scilab from the command prompt.It will download nearly 150 MB of data for installation. $ sudo apt-get install scilab y
Step 4: After sometime you will get a successful message like below.
Step 5: ApplicationsScienceScilab
For placing an order: UDOO Quad For queries: info@tenettech.com Contact: 080-26722726