Beruflich Dokumente
Kultur Dokumente
2-Thiopheneethylamine
Label elements
Pictogram Signal word Hazard statement(s) H302 H312 H315 H319 H332 H335 Precautionary statement(s) P261 P280 P305 + P351 + P338 Hazard symbol(s) Xn R-phrase(s) R20/21/22 R36/37/38 S-phrase(s) S26 S36 Warning Harmful if swallowed. Harmful in contact with skin. Causes skin irritation. Causes serious eye irritation. Harmful if inhaled. May cause respiratory irritation. Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray. Wear protective gloves/ protective clothing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Harmful
Harmful by inhalation, in contact with skin and if swallowed. Irritating to eyes, respiratory system and skin. In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. Wear suitable protective clothing.
thiophene-2-ethylamine
For the full text of the H-Statements mentioned in this Section, see Section 16.
General advice
Consult a physician. Show this safety data sheet to the doctor in attendance.
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration. Consult a physician.
If swallowed
Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician.
Further information
Use water spray to cool unopened containers.
Environmental precautions
Prevent further leakage or spillage if safe to do so. Do not let product enter drains.
Hand protection
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it.
Eye protection
Face shield and safety glasses Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU).
Hygiene measures
Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday.
Safety data
pH Melting point Boiling point Flash point Ignition temperature Lower explosion limit Upper explosion limit Density Water solubility
Conditions to avoid
Heat, flames and sparks.
Materials to avoid
Strong oxidizing agents
Skin corrosion/irritation
no data available
Carcinogenicity
IARC: No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.
Reproductive toxicity
no data available
Aspiration hazard
no data available
Potential health effects Inhalation Harmful if inhaled. Causes respiratory tract irritation. Ingestion Harmful if swallowed. Skin Harmful if absorbed through skin. Causes skin irritation. Eyes Causes serious eye irritation. Signs and Symptoms of Exposure
To the best of our knowledge, the chemical, physical, and toxicological properties have not been thoroughly investigated.
Additional Information
RTECS: Not available
Bioaccumulative potential
no data available
Mobility in soil
no data available
Contaminated packaging
Dispose of as unused product.
IMDG
Not dangerous goods
IATA
Not dangerous goods
Further information
The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The information this document is based on the resent state of our knowledge and is applicable to the product with regard to appropriate safety precautions. The above information is believed toof be correct but does not purport guidechem to be all inclusive and shall be used It does not represent any guarantee the properties of the product. shall not be only a guide. The information in this document based on the present ofproduct. our knowledge and is held as liable for any damage resulting from handlingis or from contact with thestate above applicable to side the product with to slip appropriate safety precautions. It does not represent any guarantee See reverse of invoice orregard packing for additional terms and conditions of sale. of the properties of the product. - Co., shall not be held liable for any damage resulting from handling or from contact with the above product. See reverse side of invoice or packing slip for additional terms and conditions of sale.