Sie sind auf Seite 1von 14

1) Two wires A and B of the same material and length L and 2L have radius r ad 2r resp.

the ratio of their specific resistance will be a) 1:1 b) 1:2 c) 1:4 d) 1:8 2) Three parallel resistive branches are connected across a dc supply. What will be the ratio of branch current I1:I2:I3 if the branch resistance are in ratio R1:R2:R3::2:4:6? a) 3:2:6 b) 2:4:6 c) 6:3:2 d) 6:2:4 3) A certain network consists of a large number of ideal linear resistance R and two constant ideal sources. The power consumed by R is P1when only one source is active and P2 when second source is active. If both sources are active simultaneously then the power consumed by R is a) P1 P2 b) c) ( d) ( P1 P2)2 )2

4) Kirchhoff law is not applicable to the circuit with a) Distributed parameters b) Lumped parameters c) Passive elements d) Nonlinear elements 5) In the interconnection of ideal sources it is known that 60V source is absorbing power. What is the value of current source i?
+20V +60V i

12 A

a) b) c) d)

10A 13A 15A 18A

6) In a balanced wheat stone bridge if the position of detector and source are interchanged, the bridge will still remain balanced. This inference can be drawn from a) Reciprocity theorem b) Duality theorem c) Compensation theorem d) Equivalence theorem 7) The most important advantage of using electrical energy in form of AC is a) The lower construction cost per KW of ac generation b) Conductor of smaller cross section is required c) Lesser insulation is required d) Transformation of voltage is possible in case of ac only 8) A 2 terminal network consist of one of the RLC element. The element is connected across the ac supply and current through it is (i) Amp. When an inductor is inserted in series between the source and that element, the current through the element is 2(i) Amp. What is the element? a) Resistor b) Inductor c) Capacitor d) Cannot be a single element 9) The power factor of following will be zero a) Resistive b) Capacitive c) Inductive d) Both b and c 10) In ac series RLC circuit the voltage across R and L is 20V, voltage across L and C is 9V and voltage across RLC is 15V. What is the voltage across C? a) 7V b) 12V c) 16V d) 21V 11) When the Q factor of circuit is high then a) Power factor of the circuit is high b) Impedance of the circuit is high c) BW is large d) None of the above 12) In series and parallel resonant circuit increase in resistance would cause a) Increase in BW of both circuit

b) Decrease in BW of both circuit c) Decrease in BW in series and increase in parallel circuit d) Decrease in BW in parallel and increase in series circuit 13) If the step response of initially relaxed circuit is known then ramp response can be obtained by a) Integrating the step response b) Differentiating the step response c) Integrating the step response twice d) Differentiating the step response twice 14) A sinusoidal voltage of voltage source 50 V with an impedance of 10+20j is connected to a load ZL which is variable in both power and reactance. Match list 1 and 2 for maximum power transfer and select the correct answer List 1 List 2 Load impedance 1 62.5 Total impedance 2 10+20j Current 3 2.5 Maximum power 4 20 5 10-j20 6 2.5-j2.5 A 5 5 2 2 B 2 4 4 5 C 3 3 6 6 D 4 1 1 4

A B C D

Codes a b c d

15) A rotating electrical machine having its self-inductance of both stator and rotor winding, independent of rotor position will definitely not develop a) Staring torque b) Synchronizing torque c) Hysteresis torque d) Reluctance torque 16) In dc machine the winding loss is propositional to a) Supply voltage b) Square of supply voltage c) Square of flux density d) Square of armature speed 17) Wave winding is employed in a dc machine a) High current and low voltage rating b) low current and high voltage rating

c) High current and high voltage rating d) low current and low voltage rating 18) welding generator will have a) lap winding b) wave winding c) either lap or wave winding d) none 19) Due to magnetic saturation, the flux per pole in a dc machine without brush shift a) Increase in both generator and motor with load b) decrease in both generator and motor with load c) increase in generator but decrease in motor d) increase in motor but decrease in generator 20) The interpoles in dc machine have tapering shape in order to a) Reduce the overall weight b) Reduce saturation in the interpole c) Economics of the material for interpole and their winding d) Increase in the acceleration of commutation 21) Consider the following statement about the commutating poles which are fitted on most large dc shunt motors a) The commutating poles are placed in geometrical neutral plan and their number is usually equals to the number of main poles b) The windings on the commutating poles is connected in series with the shunt field windings on the main poles c) The polarity of the commutating poles must be that of next of the main pole further ahead d) The commutating poles neutralize the reactance produced in the coil undergoing commutation. i. 1,2,3 are correct ii. 1,4 are correct iii. 2,3,4 are correct iv. 1,2,4 are correct 22) The voltage at the terminal of dc series generator running at rated rpm and no load will be a) More than rated voltage b) Full rated voltage c) Very small voltage d) Zero

23) A dc shunt generator is supplying a load of 1.8kw at 200 V. its armature and field resistance are 0.4 and 200 respect. What is generated emf? a) 190 b) 196 c) 204 d) 210 24) Consider the following statement i. In dc series generator, full load voltage is more than no load voltage ii. In separately excited dc generator full load voltage is more than no load voltage iii. In dc shunt generator full load voltage is less than no load voltage a) 1,2,3 are correct b) 1,2 are correct c) 2,3 are correct d) 1,3 are correct 25) Which of the following has rising VI characteristic a) Series b) Shunt c) Compound d) None 26) A dc series motor is employed a) As a booster to maintain constant voltage at the load end of the feeder b) For supplying transaction load c) For supplying industrial load at constant voltage d) For battery charging 27) The main factor that lead to unstable parallel operation of flat or over compound dc generator a) The rising voltage characteristic b) Unequal series field resistance c) Unequal speed regulation of their prime mover d) The drooping characteristic 28) The dc motor which can provide zero voltage regulation at full load without any controller is a) Series b) Shunt c) Cumulative Compound d) Differential Compound 29) T is the load torque of a dc series motor having linear magnetization and negligible armature resistance. Speed of the motor is

a) b) c) d)

Inversely proportional to square root of T Directly proportional to square root of T Inversely proportional to square of T Directly proportionalto square of T

30) A differentially compound dc motor is running at rated speed. If the series field winding of the motor get short circuited, the speed of the motor will a) Remain unaltered b) Increases c) Decreases d) Zero 31) The main disadvantage of Hopkinson test is that a) It need large power b) It need two identical machine c) No account is taken for charge in iron loss due to flux distortion on full load condition d) All of the above 32) In relation to dc machine match the following 33) List 1 List 2 A Developed power 1 N B torque 2 EBIA C Generated emf 3 EB/ D Speed 4 IA

Codes A B C D

A 2 3 2 3

B 4 1 1 4

C 1 4 4 1

D 3 2 3 2

34) If the rated dc voltage is applied instead of ac to primary of a transformer a) Secondary of transformer will burn b) Primary of transformer will burn c) Secondary voltage will be excessively large d) No secondary voltage 35) The low voltage windings of a 400/230 v single phase 50 hz Transformer to be connected to a 25 hz supply. In order to keep the magnetization current at the same level in both case the voltage at 25 hz should be a) 230v b) 460v c) 115v

d) 65v 36) In transformer which of the following is valid statement a) In open circuit test , copper loss are obtained while in SC test core loss are obtained b) In OC test current is drawn at high power factor c) In a SC test current is drawn at zero power factor d) In OC test current is drawn at lower power factor 37) The desirable property of transformer core material are a) Low permeability and low hysteresis loss b) high permeability and high hysteresis loss c) high permeability and low hysteresis loss d) Low permeability and high hysteresis loss 38) Sludge formation in transformer oil is due to which of the following a) Ingress of dust particles and moisture b) Appearance of small fragment of paper varnish cotton and other organic material in oil c) Chemical reaction of transformer oil with insulating material d) Oxidation of transformer oil 39) Possible three to three phase transformer connection for parallel operation a) - to - b) - to c) - to d) to 40) Which one of the following is the primary reason for placing field winding on rotor in an alternator a) Small power in field circuit b) Insulation of high voltage is made easy on stator than on rotor c) Large power in stator d) Large current in stator 41) In a large synchronous generator the damper winding is provided for a) Absorption of energy of oscillation when operating in parallel with another alternator b) Suppuration of spontaneous hunting when supplying power to a transmission with high resistance/reactance ratio. c) Providing a low resistance path for current due to unbalancing of voltages. d) All of the above 42) The salient pole rotor are not suitable for high speed turbo generator due to a) Excessive bearing friction

b) Undesirable mechanical oscillation c) High centrifugal forces and winding loss d) large eddy current losses 43) in a synchronous alternator which has emf closer to sin wave a) concentrated winding in full pitch coil b) concentrated winding in short pitch coil c) distributed winding in full pitch coil d) distributed winding in short pitch coil 44) the magnitude of leakage flux of synchronous alternator depend on a) magnitude of armature current b) phase angle between armature current and terminal voltage c) air gap thickness d) both a and b 45) armature reaction of a synchronous generator supplying power at rated voltage with zero power factor lagging is a) Magnetizing b) Demagnetizing c) Cross Magnetizing d) Both a and b 46) The leakage reactance of a three phase alternator is determined by a) OC test and zero power factor test b) zero power factor test and slip test c) OC and SC test d) SC and slip test 47) Higher the applied voltage a) Higher will be the stator flux b) Higher will be pull in torque c) Lower will be stator torque d) Lower will be pull in torque e) Both a and b f) Both a and d 48) An infinite bus bar has a) Constant voltage b) Constant frequency c) Infinite voltage d) Infinite current

e) Infinite frequency f) Both a and b 49) An inductor motor can run at synchronous speed if its operated a) No load b) Full load c) With emf injected in the rotor d) On voltage higher than rated voltage 50) In comparison to resistance start induction motor the permanent capacitor motor is a) More expensive b) Has better power factor c) Has better starting torque d) Both a and b e) All of the above 51) In shaded pole induction motor locked rotor current is ____________ full load current a) Less than b) Equal to c) Slightly more than d) Several times the 52) Hysteresis motor is a) Self starting b) Constant speed motor c) Does not need dc excitation d) Both a and b e) All of the above 53) A B C D 54) List 1 Unity power factor Zero power factor lagging Zero power factor leading Intermediate lagging 1 2 3 4 List 2 Fully demagnetizing Fully magnetizing Cross magnetizing Partially cross magnetizing and Partially cross demagnetizing

Codes A B C D

A 3 3 1 1

B 1 1 3 3

C 4 2 2 4

D 2 4 4 2

55) Which one of the temperature below which certain material are anti ferromagnetic and above which are paramagnetic a) curie temperature b) Neel temperature c) Transition temperature d) Weiss temperature. 56) In diamagnetic material the effect of an applied magnetic field is that a) Net reduction in flux density b) Induced magnetization is in opposite to the applied field c) Net dipole moment is induced in the material d) All of the above 57) Susceptibility of diamagnetic material is 1) Negative 2) Positive 3) Depend on temperature 4) Independent of temperature a) 1,3 b) 2,4 c) 1,4 d) 2,3

58) The converse of magnetostriction effect is a) Villari effect b) Curie effect c) Skin effect d) See back effect 59) Blinking of fluorescent tube may be removed by a) Replacement of starter b) Checking of all connection c) Change of ballast tapping d) Any of the above turn by turn 60) Draw in system of laying underground cable has drawback of a) Higher cost b) Reduced current carrying capacity c) Requirement of much deeper and wider trenches d) Repair replacement alternation or addition difficulty e) All of the above except (d)

61) Which of following distribution system is preferred for good efficiency and high economy a) Single phase, 2 wire system b) 2 phase, 3 wire system c) 3 phase. 3 wire system d) 3 phase 4 wire system 62) Stranded conductor usually has central wire around which there are successive layer of 6,12,18,24 wires. For n layers the total number of individual wires is a) 3n(n+1) b) 2n(n+1) c) 3n(n+1)+1 d) 2n(n+1)+1 63) The non-uniform distribution of voltage across the unit in a string of suspension type insulator is due to a) Unequal self-capacitance of the unit b) Non uniform distance of separation of the unit from the tower body c) The existence of stray capacitance between the metallic junction of the unit and the tower body d) Non uniform distance between the cross arm and the unit. 64) 3 phase transmission line has its conductor at the corner of an equilateral triangle with side 3m. the diameter of each conductor is 1.63 cm. the inductance of the line per phase per km is a) 1.232mh b) 1.182mh c) 1.093mh d) 1.043mh 65) Which the following is correct a) Surge impedance is the impedance at the time of breakdown of voltage b) Surge impedance and characteristic impedance for a transmission line are same c) Surge impedance is the impedance of transmission line when corona take place. d) None of the above. 66) A lossless radial transmission line with surge impedance loading a) Take negative VAR at sending end and zero VAR at receiving end b) Take positive VAR at sending end and zero VAR at receiving end c) Has flat voltage profile and unity power factor at all point along it. d) Has sending end voltage higher than receiving end voltage and unity power factor at sending end.

67) Capacitance grading of cable means a) Use of dialectical in different concentration b) Introduction of capacitance at various length of cable to counter the effect of inductance c) Use of dialectical of different permittivity, d) Grading according to capacitance per km length of the cable. 68) Bulk power transmission over long HVDC lines are preferred an account of a) Low cost of HVDC terminal b) No harmonics problem c) Minimum line power loss d) Simple protection 69) HVDC transmission there are predominant a) Voltage harmonics on dc side and current harmonics on ac side of converter b) Current harmonics on dc side and voltage harmonics on ac side of converter c) Current harmonics only on the dc side of converter d) Voltage harmonics only on the ac side of converter. 70) Which of the following are the effect of increase the reverse bias across PN junction a) Decrease in junction capacitance of the diode b) Increase in carrier generation current c) Increase in carrier recombination in the depletion layer. i. 1 alone ii. 2 and 3 iii. 1 and 2 iv. 1,2,and 3 are correct 71) A step recovery diode a) Has extremely short recovery time b) Is mainly used as a harmonic generator c) Conducts equally well in both direction d) Is an ideal rectifier of high frequency signal. 72) 73) List 1 Boltzmann constant Permeability of free space Permittivity of free space mobility List 2 Farad/meter Cm2/volt-sec Henry/meter Cm2/second Electron volt/kelvin

A B C D

1 2 3 4 5

Codes A A 5

B 2

C 1

D 4

B C D

1 5 1

2 3 3

5 1 5

4 2 2

A B

73) 74) List 1 Donor energy level Fermi level of p type semiconductor at room temperature Acceptor energy band Fermi level in intrinsic semiconductor A 4 2 4 2 B 3 1 1 3 C 2 4 2 4 D 1 3 3 1

1 2

List 2 At the middle of forbidden energy gap Close to the conduction band

C D

3 4

Very close to the valence band Close to the valence band

Codes A B C D

74) In an RC coupled common emitter amplifier a) coupling capacitance affect the higher frequency response and bypass capacitance affect the low frequency response b) both coupling and bypass capacitance affect HF response c) both coupling and bypass capacitance affect LF response d) coupling affect Hf response and bypass capacitance affect LF response

Das könnte Ihnen auch gefallen