Beruflich Dokumente
Kultur Dokumente
1. Cutting force 2. Stripping force 3. Flat blank length 4. Correction factor for flat blank length 5. Pre-form for full circle forming 6. Number of drawing process 7. Draw clearance 8. Number of draw reduction 9. Draw reduction percentage 10. Area of flat ring 11. Area of Cylinder 12. Area of fillet 13. Area of invert fillet 14. Area of hemisphere 15. Area of spherical ring & dish
F= A x T
Cutting force
F = Cutting force L = Total cutting length S = Material thickness A = L x S = Shear area
T = Shear strength
P= ( L x S x T ) / 10
Stripping force
P = Stripping force L = Total cutting length
T = Shear strength
L = a + ( R + q x s/2 )( Pi x / 180)
L = Flat blank length a, b = Length of legs R = Bend radius q = Correction factor ( refer to table below ) = Bend angle Pi = 3.1416
Correction factor q Ratio R : s Correction factor
Correction factor
5.0 1.0
3.0 0.9
2.0 0.8
1.2 0.7
0.8 0.6
0.5 0.5
R = Bend Radius
S = Material Thickness
E = ( D + s ) 0.707 C = ( D + s ) 1.414
E = Center distance C = Center distance between two apart radii s = Material thickness D = Inside diameter of final formed part R = D/2 ( approximate ) Note : if R = D/2, radii will be tangent, if R /= D/2, radii will require blending.
Draw clearance
Thickness S < 0.4 0.4 - 1.27 1.27 - 3.18 > 3.175 S = Material thickness
H/D < 0.75 Draw reduction ( number of draw ) 0.7 - 1.5 1.5 - 3.0 3.0 - 4.7
H = Draw piece height
No. of draw 1 2 3 4
% = 1 -( MD / D )
Draw % of reduction
% = percentage of reduction MD = Mean diameter of draw piece D = Flat blank diameter
A = 3.1416 ( D x H )
D = Mean diameter H = Shell height
A= 4.935 RD + 6.283 (R x R)
D = Hole diameter R = Radius ( 1/2 thickness )
A= 4.935 RD - 6.283 (R x R)
D = Outer diameter R = Radius ( 1/2 thickness )
A= 6.283 ( R x R )
R = Radius ( 1/2 thickness )
A = 6.283 RH
R = Radius ( 1/2 thickness ) H = Shell height
A = 9.87 RD
D = center to center diameter R = Radius ( 1/2 thickness )