Beruflich Dokumente
Kultur Dokumente
0)
By: Owey
1
Why is it important that the network administrator consider the spanning-tree network diameter when choosing the root
bridge?
Refer to the exhibit. A network administrator configures HyperTerminal with the parameters shown but is unable to connect
to a switch via the console port. The administrator is using a tested rollover cable attached to the only COM port on the
computer, and the connections have been verified. What is the likely problem?
Refer to the exhibit. Switch SW2 was tested in a lab environment and then inserted into a production network without
reloading its configuration. After the trunk link between SW1 and SW2 was brought up, all users lost connectivity to the
network. What could be the source of the problem?
All the VLANs were pruned from the trunk port between SW1 and SW2.
SW1 and SW2 cannot be both set as VTP servers in the same VTP domain.
VTP configuration revision number of SW2 was higher than the configuration revision number of SW1.
The additional VLANs from SW2 created more VLANs than the VLAN database of SW1 could contain.
4
Refer to the exhibit. R1 is configured for traditional inter-VLAN routing. R1 can ping computer 3 but cannot ping computer 1.
What is a possible cause for this failure?
Refer to the exhibit. The hosts connected to switch SW1 are not able to communicate with the hosts in the same VLANs
connected to switch SW2. What should be done to fix the problem?
The boot loader uses the self-contained switch operating system to boot the switch.
The boot loader retrieves diagnostics routines via TFTP.
The boot loader performs POST.
The boot loader is loaded from RAM.
The boot loader initializes the flash file system that is used to boot the system.
The boot loader loads the default operating system if the flash-based operating system is corrupt or missing.
7
An administrator is viewing the running configuration for a switch on the network. The enable password is displayed in plain
text but the enable secret password has been encrypted. What level of access can be gained using the enable password?
Refer to the exhibit. A network administrator has segmented the network into two VLANs. The connected hosts can only
access resources in their own VLAN. What is the most scalable and cost effective solution to allow inter-VLAN
communication in this network?
Replace S1 with a router that has one FastEthernet interface for each PC.
Add a second switch and divide the PCs so that each VLAN is connected to its own switch.
Configure a router with two subinterfaces on one of its FastEthernet ports and connect it to S1 using a trunk
link.
Connect a router to a port on S1 and assign the IP address of VLAN1 to the connecting router interface.
9
Refer to the exhibit. Router RA receives a packet with a source address of 192.168.1.65 and a destination address of
192.168.1.85. What will the router do with this packet?
Refer to the exhibit. The devices in the network are operational and configured as indicated in the exhibit. However, hosts
A and D cannot ping each other. What is the most likely cause of this problem?
Refer to the exhibit. Which three options correctly describe the router configuration that is shown? (Choose three.)
12
A network administrator needs to save the configuration file currently in RAM to NVRAM before rebooting the switch.
Which command should the administrator issue?
13
Refer to the exhibit. The configuration steps that are listed in the exhibit have been entered in switch S1 via the console.
Subsequent attempts to telnet to the switch are not successful. What is causing the problem?
14
Which parameter is associated with wireless authentication?
shared key
SSID
ad hoc
channel
15
A wireless LAN access point will convert traffic between which two frame encapsulation types?
16
Refer to the exhibit. Switch SW2 has been newly purchased and added to the network. What configuration should be applied
to SW2 so that it participates in the same VTP domain as switch SW1, receives VLAN information from SW1, and
synchronizes VLAN information?
17
What is the correct order in which the STP components are chosen?
18
What are three features of router-on-a-stick, inter-VLAN routing? (Choose three.)
19
While configuring a new switch, a network administrator configures the switch as an HTTP server. What benefits does this
configuration provide?
This allows the switch to host web pages for the network.
This allows remote VPN connections to the switch over the Internet.
This is required if a web server or web farm is attached to the switch.
This allows web-based configuration tools to be used with the switch.
20
What will be the effect of the command S1# copy system:running-config tftp://172.16.2.155/tokyo-config?
Refer to the exhibit. What does "FORWARDING" mean in the command output shown?
22
Refer to the exhibit. What does STATIC indicate in the output that is shown?
This entry will be removed and refreshed every 300 seconds to keep it in the table.
The switch learned this MAC address from the source address in a frame received on Fa0/15.
The switch will only allow a device with a MAC address of 0000.c123.5432 to connect to port Fa0/15.
When processing a frame, the switch does not have to perform a lookup to determine the final destination port.
The switch is configured to forward traffic destined for MAC address 0000.c123.5432 will be forwarded to
Fa0/15.
23
Which benefit is gained by designing a network with a small network diameter?
lower latency
improved security
increased redundancy
higher interface bandwidth
24
25
Refer to the exhibit. An administrator documented the output of a CAM table from an Ethernet switch as shown. What
action will the switch take when it receives the frame shown at the bottom of the exhibit?
26
Refer to the exhibit. The switches in the exhibit have VTP pruning enabled. Which VLAN(s) will be allowed on the trunk to
SW2 by SW4?
VLAN 20 only
VLAN 10 and VLAN 30
VLAN 10, VLAN 20, and VLAN 30
VLAN 1, VLAN 20 and VLANs 1002 through 1005
27
What are two benefits of the IEEE 802.11n standard over the IEEE 802.11G? (Choose two.)
Refer to the exhibit. If switch SW1 is configured with the four VLANs as shown in the exhibit, how many physical
interfaces are needed on router R1 to configure inter-VLAN routing using subinterfaces?
zero
one
two
four
29
Refer to the exhibit. After entering the commands in the exhibit, the administrator receives a "password required, but none
set" message when attempting to connect to S1. What is the problem?
30
When implementing a router-on-a-stick, what must be configured on the router to ensure connectivity between different
VLANs?
subinterfaces
routing protocol
switched virtual circuits
dynamic trunking protocol
31
Refer to the exhibit. Hosts A and B attempt to transmit a frame at the same time and a collision occurs. When will host D be
able to transmit?
immediately
after sending its jam signal
after host A and host B have completed transmission
after the jam signal clears and its backoff delay expires
32
Refer to the exhibit. What would happen if the network administrator moved the network cable of Host A from interface
Fa0/1 to Fa0/3 on switch SW1?
Host A remains a member of VLAN 10, because the router is routing traffic between VLANs.
Host A is no longer a member of VLAN 10, because port Fa0/3 has been manually assigned to VLAN 30.
Host A remains a member of VLAN 10, because the switch provides dynamic VLAN assignment for the port.
Host A maintains connectivity to all members of VLAN 10, because it is connected to the same physical network.
Host A is no longer a member of VLAN 10, but because port Fa0/3 was unused, it is now a member of VLAN 1.
33
Refer to the exhibit. What will allow a host that is connected to switch X in VLAN 10 to communicate with a host that is
connected to switch Y in VLAN 10?
QoS
routing
trunking
VPN
VoIP
subinterfaces
34
Refer to the exhibit. Computer A sends a broadcast message. Which devices will see the broadcast?
computer B
computer B and Router1
computer C and Router1
computer B, computer D, computer E and Router1
computer B, computer C, computer D, computer E and Router1
computer A, computer B, computer C, computer D, computer E and Router1
35
Which value determines if a switch becomes the central point of reference in the spanning tree topology?
lowest bridge ID
highest revision number
lowest numeric IP address
highest numeric MAC address
36
Refer to the exhibit. A new host needs to be connected to VLAN 20. Which IP address should be assigned to this new host?
172.16.10.68 /27
172.16.10.99 /28
172.16.10.110 /27
172.16.30.96 /27
172.16.30.120 /28
172.16.30.146 /27
37
Refer to the graphic. In the Wireless menu option of a Linksys integrated router, what does the Network Mode option
Mixed mean?
The router supports encryption and authentication.
The router supports both wired and wireless connections.
The router supports 802.11b, 802.11g, and 802.11n devices.
The router supports connectivity through infrared and radio frequencies.
38
Refer to the exhibit. What will be the result of the commands that are shown in the exhibit?
39
Which method establishes an administrative connection for configuring the Linksys WRT300N wireless access point?
Associate with the access point and then open a HyperTerminal session with the access point.
Physically connect to the access point and then reboot the computer to launch the configuration software.
From a computer in the same IP subnet as the access point, enter the default IP address of the access point in
a web browser.
Modify the TCP/IP properties of the computer connected to the access point so that it exists on the same network, and
then reboot your computer to establish a connection.
40
Which statement is true about open authentication when it is enabled on an access point?
requires no authentication
uses a 64-bit encryption algorithm
requires the use of an authentication server
requires a mutually agreed upon password
41
Refer to the exhibit. Router R1 is properly configured for router on a stick inter-VLAN routing, but PC1 is unable to ping
PC2. What needs to be done to resolve the problem?
Rename VLAN1.
Connect one more port of S1 to R1.
Configure the Fa0/1 port of S1 as a trunk port.
Move the Fa0/0 interface of R1 to another VLAN.
42
Refer to the exhibit. What are two reasons for the Fa0/24 port being placed in the blocking state? (Choose two.)
43
How does Spanning Tree Protocol aid network architecture?
44
Refer to the exhibit. What three statements describe why Host1 and Host2 are unable to communicate? (Choose three.)
The switch ports are on different VLANs.
The switch IP address is on the wrong subnet.
The hosts are configured on different logical networks.
A router is required to forward traffic between Host1 and Host2.
The VLAN port assignments must be contiguous for each VLAN.
The host default gateway addresses must be on the same logical network.
45
Which device or devices should have the Spanning Tree Protocol enabled to prevent host traffic from creating a broadcast
storm?
Core_S1
Access_S2 and Access_S3
Core_S1, Access_S2, and Access_S3
Core_S1, Access_S2, Access_S3, and R1
46
Refer to the exhibit. Users A and B are reporting intermittent connectivity problems. Pre-installation surveys showed strong
signal strength from the AP locations to the client locations. Outside electrical interference has been eliminated. What will
fix the problem?
47
Refer to the exhibit. Hosts PC_A and PC_B send traffic simultaneously, and the frames from the transmitting stations
collide. What is the last device to receive the collision?
hub HB1
switch SW1
router R1
switch SW2
router R2
switch SW4
48
Which type of frame contains information that is used in the election of the spanning tree root bridge?
BID
LSA
LSU
BPDU
49
Refer to the exhibit. All hosts are in listen mode. Host 1 and Host 4 both transmit data at the same time. How do the hosts
respond on the network? (Choose two.)
50
Refer to the exhibit. Switches S2 and S3 are properly connected using an ethernet cable. A network administrator has
configured both switches with VTP, but S3 is unable to propagate VLANs to S2. What could be the reason for this?
51
Which parameter is used to uniquely identify one wireless network from another?
SSID
OFDM
WEP
DSSS
52
In which mode is a VTP switch operating if it does not allow for the creation of local VLANs but it does accept VLAN
updates from other switches in the same domain?
client
root
server
transparent