Beruflich Dokumente
Kultur Dokumente
cyclohexanone
398241 606-010-00-7 108-94-1 Laboratory chemicals, Manufacture of substances
1.2 2. 2.1
Relevant identified uses of the substance or mixture and uses advised against
Identified uses
HAZARDS IDENTIFICATION Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 [EU-GHS/CLP]
Flammable liquids (Category 3) Acute toxicity, Inhalation (Category 4)
2.2
- - 398241 R-phrase(s)
2.3 3. 3.1
Cyclohexanone
CAS-No. EC-No. Index-No.
4. 4.1
Consult a physician. Show this safety data sheet to the doctor in attendance.
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration. Consult a physician.
If swallowed
Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician.
4.2
4.3 5. 5.1
Further information
Use water spray to cool unopened containers.
- - 398241
6. 6.1
ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures
Use personal protective equipment. Avoid breathing vapors, mist or gas. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas.
6.2 6.3
Environmental precautions
Prevent further leakage or spillage if safe to do so. Do not let product enter drains.
6.4 7. 7.1
7.2
EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Components with workplace control parameters Exposure controls Appropriate engineering controls
Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday.
Tightly fitting safety goggles. Faceshield (8-inch minimum). Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU).
Skin protection
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it.
Body Protection
Complete suit protecting against chemicals, Flame retardant antistatic protective clothing, The type of protective equipment must be selected according to the concentration and amount of the dangerous substance at the specific workplace.
Respiratory protection
Where risk assessment shows air-purifying respirators are appropriate use a full-face respirator with multi-purpose combination (US) or type ABEK (EN 14387) respirator cartridges as a backup to engineering controls. If the respirator is the sole means of protection, use a full-face supplied air
- - 398241
respirator. Use respirators and components tested and approved under appropriate government standards such as NIOSH (US) or CEN (EU).
9. 9.1
PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties
a) Appearance b) Odour c) Odour Threshold d) pH e) Melting point/freezing point f) Initial boiling point and boiling range g) Flash point Form: clear, liquid Colour: colourless no data available no data available no data available Melting point/range: -47 C - lit. 155 C - lit. 44 C - closed cup
h) Evaporation rate no data available i) Flammability (solid, gas) no data available j) Upper/lower Upper explosion limit: 9,4 %(V) flammability or Lower explosion limit: 1,1 %(V) explosive limits k) Vapour pressure 4,5 hPa at 20 C 13 hPa at 38,7 C l) Vapour density 3,39 - (Air = 1.0) m) Relative density n) Water solubility o) Partition coefficient: noctanol/water p) Autoignition temperature q) Decomposition temperature r) Viscosity s) Explosive properties t) Oxidizing properties 0,947 g/cm3 at 25 C ca.50 g/l log Pow: 0,81 no data available no data available no data available no data available no data available 35,05 mN/m at 20 C
9.2
no data available
Skin corrosion/irritation
Skin - rabbit - Open irritation test
Carcinogenicity
This product is or contains a component that is not classifiable as to its carcinogenicity based on its IARC, ACGIH, NTP, or EPA classification. IARC: 3 - Group 3: Not classifiable as to its carcinogenicity to humans (Cyclohexanone)
Reproductive toxicity
no data available Overexposure may cause reproductive disorder(s) based on tests with laboratory animals.
Aspiration hazard
no data available
Potential health effects Inhalation May be harmful if inhaled. May cause respiratory tract irritation. Ingestion Harmful if swallowed. Skin May be harmful if absorbed through skin. May cause skin irritation. Eyes Causes eye burns. Signs and Symptoms of Exposure
Prolonged or repeated exposure to skin causes defatting and dermatitis., Cough, Shortness of breath, Headache, Nausea, Vomiting, Central nervous system depression, Incoordination., To the best of our knowledge, the chemical, physical, and toxicological properties have not been thoroughly investigated.
Additional Information
RTECS: GW1050000
no data available
Contaminated packaging
Dispose of as unused product.
15.
REGULATORY INFORMATION
This safety datasheet complies with the requirements of Regulation (EC) No. 1907/2006.
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
no data available
16.
- - 398241