Sie sind auf Seite 1von 3

mke2fs 1.

42
fs_types for mke2fs.conf resolution: 'ext4'
...
Running command: badblocks -b 4096 -X -s -w /dev/sdb1 78142159
Block 0 in primary superblock/group descriptor area bad.
Blocks 0 through 20 must be good in order to build a filesystem.
Aborting....
--------------------------------------------------------------------------smartctl 5.41 2011-06-09 r3365 [x86_64-linux-3.8.0-34-generic] (local build)
=== START OF INFORMATION SECTION ===
Device Model:
Hitachi HTS543232A7A384
Serial Number:
E203421K0LSMUP
LU WWN Device Id: 5 000cca 6e9c8876b
Firmware Version: ES2OA60W
User Capacity:
320,072,933,376 bytes [320 GB]
Sector Size:
512 bytes logical/physical
Device is:
Not in smartctl database [for details use: -P showall]
ATA Version is:
8
ATA Standard is: ATA-8-ACS revision 6
Local Time is:
Thu Dec 12 12:45:49 2013 EET
SMART support is: Available - device has SMART capability.
SMART support is: Enabled
=== START OF READ SMART DATA SECTION ===
SMART overall-health self-assessment test result: FAILED!
Drive failure expected in less than 24 hours. SAVE ALL DATA.
See vendor-specific Attribute list for failed Attributes.
General SMART Values:
Offline data collection status:
Self-test execution status:

(0x82)
Offline data collection activity
was completed without error.
Auto Offline Data Collection: Enabled.
(
0)
The previous self-test routine completed
without error or no self-test has ever
been run.

Total time to complete Offline


data collection:
(
45) seconds.
Offline data collection
capabilities:
(0x5b) SMART execute Offline immediate.
Auto Offline data collection on/off support.
Suspend Offline collection upon new
command.
Offline surface scan supported.
Self-test supported.
No Conveyance Self-test supported.
Selective Self-test supported.
SMART capabilities:
(0x0003)
Saves SMART data before entering
power-saving mode.
Supports SMART auto save timer.
Error logging capability:
(0x01)
Error logging supported.
General Purpose Logging supported.
Short self-test routine
recommended polling time:
(
2) minutes.
Extended self-test routine
recommended polling time:
( 92) minutes.
SCT capabilities:
(0x003d)
SCT Status supported.
SCT Error Recovery Control supported.
SCT Feature Control supported.
SCT Data Table supported.
SMART Attributes Data Structure revision number: 16
Vendor Specific SMART Attributes with Thresholds:
ID# ATTRIBUTE_NAME
FLAG
VALUE WORST THRESH
1 Raw_Read_Error_Rate
0x000b
086
086
062
2 Throughput_Performance 0x0005
197
197
040
3 Spin_Up_Time
0x0007
218
218
033
4 Start_Stop_Count
0x0012
100
100
000
5 Reallocated_Sector_Ct
0x0033
001
001
005
7 Seek_Error_Rate
0x000b
100
100
067
8 Seek_Time_Performance
0x0005
117
117
040
9 Power_On_Hours
0x0012
099
099
000
10 Spin_Retry_Count
0x0013
100
100
060
12 Power_Cycle_Count
0x0032
100
100
000

TYPE
Pre-fail
Pre-fail
Pre-fail
Old_age
Pre-fail
Pre-fail
Pre-fail
Old_age
Pre-fail
Old_age

UPDATED
Always
Offline
Always
Always
Always
Always
Offline
Always
Always
Always

WHEN_FAILED
FAILING_NOW
-

RAW_VALUE
2818136
157
1
661
0
0
33
714
0
648

191 G-Sense_Error_Rate
192 Power-Off_Retract_Count
193 Load_Cycle_Count
194 Temperature_Celsius
15/46)
196 Reallocated_Event_Count
197 Current_Pending_Sector
198 Offline_Uncorrectable
199 UDMA_CRC_Error_Count
223 Load_Retry_Count

0x000a
0x0032
0x0012
0x0002

100
100
099
193

100
100
099
193

000
000
000
000

Old_age
Old_age
Old_age
Old_age

Always
Always
Always
Always

0
45
14376
31 (Min/Max

0x0032
0x0022
0x0008
0x000a
0x000a

001
100
100
200
100

001
100
100
200
100

000
000
000
000
000

Old_age
Old_age
Old_age
Old_age
Old_age

Always
Always
Offline
Always
Always

2527
1
0
0
0

SMART Error Log Version: 1


ATA Error Count: 15542 (device log contains only the most recent five errors)
CR = Command Register [HEX]
FR = Features Register [HEX]
SC = Sector Count Register [HEX]
SN = Sector Number Register [HEX]
CL = Cylinder Low Register [HEX]
CH = Cylinder High Register [HEX]
DH = Device/Head Register [HEX]
DC = Device Command Register [HEX]
ER = Error register [HEX]
ST = Status register [HEX]
Powered_Up_Time is measured from power on, and printed as
DDd+hh:mm:SS.sss where DD=days, hh=hours, mm=minutes,
SS=sec, and sss=millisec. It "wraps" after 49.710 days.
Error 15542 occurred at disk power-on lifetime: 714 hours (29 days + 18 hours)
When the command that caused the error occurred, the device was active or idle.
After
ER ST
-- -40 51

command completion occurred, registers were:


SC SN CL CH DH
-- -- -- -- -02 f5 8f 2b 0f Error: UNC at LBA = 0x0f2b8ff5 = 254513141

Commands
CR FR SC
-- -- -60 08 00
60 08 00
60 08 00
60 08 00
60 08 00

leading to the command that caused the error were:


SN CL CH DH DC
Powered_Up_Time Command/Feature_Name
-- -- -- -- -- ---------------- -------------------ef 8f 2b 40 00
1d+19:15:29.461 READ FPDMA QUEUED
e7 8f 2b 40 00
1d+19:15:29.461 READ FPDMA QUEUED
df 8f 2b 40 00
1d+19:15:29.460 READ FPDMA QUEUED
d7 8f 2b 40 00
1d+19:15:29.460 READ FPDMA QUEUED
cf 8f 2b 40 00
1d+19:15:29.460 READ FPDMA QUEUED

Error 15541 occurred at disk power-on lifetime: 714 hours (29 days + 18 hours)
When the command that caused the error occurred, the device was active or idle.
After
ER ST
-- -40 51

command completion occurred, registers were:


SC SN CL CH DH
-- -- -- -- -07 d0 7d 27 0f Error: UNC at LBA = 0x0f277dd0 = 254246352

Commands
CR FR SC
-- -- -60 08 00
60 08 00
60 08 00
60 08 00
60 08 00

leading to the command that caused the error were:


SN CL CH DH DC
Powered_Up_Time Command/Feature_Name
-- -- -- -- -- ---------------- -------------------cf 7d 27 40 00
1d+19:13:07.462 READ FPDMA QUEUED
c7 7d 27 40 00
1d+19:13:06.828 READ FPDMA QUEUED
bf 7d 27 40 00
1d+19:13:06.675 READ FPDMA QUEUED
b7 7d 27 40 00
1d+19:13:06.675 READ FPDMA QUEUED
af 7d 27 40 00
1d+19:13:06.675 READ FPDMA QUEUED

Error 15540 occurred at disk power-on lifetime: 714 hours (29 days + 18 hours)
When the command that caused the error occurred, the device was active or idle.
After
ER ST
-- -40 51

command completion occurred, registers were:


SC SN CL CH DH
-- -- -- -- -04 1b 2d 24 0f Error: UNC at LBA = 0x0f242d1b = 254029083

Commands
CR FR SC
-- -- -60 08 00
60 08 00

leading to the command that caused the error were:


SN CL CH DH DC
Powered_Up_Time Command/Feature_Name
-- -- -- -- -- ---------------- -------------------17 2d 24 40 00
1d+19:12:03.824 READ FPDMA QUEUED
0f 2d 24 40 00
1d+19:12:03.813 READ FPDMA QUEUED

60 08 00 07 2d 24 40 00
60 08 00 ff 2c 24 40 00
60 08 00 f7 2c 24 40 00

1d+19:12:03.813
1d+19:12:03.802
1d+19:12:03.801

READ FPDMA QUEUED


READ FPDMA QUEUED
READ FPDMA QUEUED

Error 15539 occurred at disk power-on lifetime: 714 hours (29 days + 18 hours)
When the command that caused the error occurred, the device was active or idle.
After
ER ST
-- -40 51

command completion occurred, registers were:


SC SN CL CH DH
-- -- -- -- -07 d8 00 24 0f Error: UNC at LBA = 0x0f2400d8 = 254017752

Commands
CR FR SC
-- -- -60 08 00
60 08 00
60 08 00
60 08 00
60 08 00

leading to the command that caused the error were:


SN CL CH DH DC
Powered_Up_Time Command/Feature_Name
-- -- -- -- -- ---------------- -------------------d7 00 24 40 00
1d+19:11:50.813 READ FPDMA QUEUED
cf 00 24 40 00
1d+19:11:50.614 READ FPDMA QUEUED
c7 00 24 40 00
1d+19:11:50.614 READ FPDMA QUEUED
bf 00 24 40 00
1d+19:11:50.613 READ FPDMA QUEUED
b7 00 24 40 00
1d+19:11:50.613 READ FPDMA QUEUED

Error 15538 occurred at disk power-on lifetime: 714 hours (29 days + 18 hours)
When the command that caused the error occurred, the device was active or idle.
After
ER ST
-- -40 51

command completion occurred, registers were:


SC SN CL CH DH
-- -- -- -- -08 df af 1a 0f Error: UNC at LBA = 0x0f1aafdf = 253407199

Commands
CR FR SC
-- -- -60 08 00
60 08 00
60 08 00
60 08 00
60 08 00

leading to the command that caused the error were:


SN CL CH DH DC
Powered_Up_Time Command/Feature_Name
-- -- -- -- -- ---------------- -------------------df af 1a 40 00
1d+19:09:09.359 READ FPDMA QUEUED
d7 af 1a 40 00
1d+19:09:09.359 READ FPDMA QUEUED
cf af 1a 40 00
1d+19:09:09.359 READ FPDMA QUEUED
c7 af 1a 40 00
1d+19:09:09.359 READ FPDMA QUEUED
bf af 1a 40 00
1d+19:09:09.359 READ FPDMA QUEUED

SMART Self-test log structure revision number 1


Num Test_Description
Status
Remaining
# 1 Short offline
Completed without error
00%
# 2 Short offline
Completed: read failure
30%
# 3 Extended offline
Aborted by host
60%
# 4 Extended captive
Interrupted (host reset)
90%
# 5 Short offline
Completed without error
00%
# 6 Extended offline
Completed: read failure
90%
# 7 Short offline
Completed without error
00%
# 8 Extended offline
Completed: read failure
60%
# 9 Short offline
Completed without error
00%
#10 Short offline
Completed without error
00%

LifeTime(hours)
668
664
647
637
614
612
612
608
590
24

SMART Selective self-test log data structure revision number 1


SPAN MIN_LBA MAX_LBA CURRENT_TEST_STATUS
1
0
0 Not_testing
2
0
0 Not_testing
3
0
0 Not_testing
4
0
0 Not_testing
5
0
0 Not_testing

LBA_of_first_error
241644866
241644864
234146172
-

Das könnte Ihnen auch gefallen