Beruflich Dokumente
Kultur Dokumente
Activity Description
Activity Type Name of Activity Introduction to Radio Estimated Duration 10 Minutes Introduction Explanation of some of the basic radio components, operations and procedures !rinciples of the Activity !rocedure Ma"e #couts familiar $ith typical radio enablin% them to use a t$o $ay radio effectively &and out information sheet on radios and radio operation Turnin% the radio on and initial setup Explain the "ey points on all of the sheets especially those concerned $ith radio eti'uette (onduct a radio chec" Demonstrate ho$ to call (omms or another person Demonstrate the $ay to hold and spea" into the radio Discuss the protocols of ma"in% a call, cuttin% in an emer%ency )o throu%h the correct use of phonetics and callsi%ns Tal" about the ran%e of the radios Tal" about $hat happens $hen the batteries %o flat +ith a small %roup it mi%ht be possible to %ive out the radios at an early sta%e so that people can be involved in the demonstration E'uipment &andouts , (ode #heet, #cout -adio *perations )uidelines, &andheld -adios .(/ $ould be fine0
*ptions
Radio Controls
1
*n1*ff 2 3olume 4 5ully anticloc"$ise is off 2 Initial settin% about 6 $ay Speaker 7 Not used 3 8 !ress to Tal" .Transmit /utton0 9 :eypad loc" Microphone ; (hannel selection 4 < !0, !1, !7, !8 Direct channel selection 5 = (hec" battery 4 has it been char%ed properly> ? (hec" volume settin% 4 "eep an eye on this 6 @ !ush the !ress to Tal" button firmly to prevent unintentional release and dropout 10 /e certain the radio is set on the proper fre'uency or channel 11 The s'uelch control bloc"s out $ea" si%nals AdAust the s'uelch control until a noise can be heard, then adAust it sli%htly in the opposite direction until the noise stops
Radio Checks
/efore movin% a$ay from the (ommunications )roup1radio pic"up point you should perform a radio chec" to test the si%nal stren%th and readability of transmitted radio si%nals Comms .person bein% called0 THIS IS Red Team .your callsi%n0 RADIO CHECK .meanin% ho$ do you hear me>0 Comms should then reply $ith ROGER and you mi%ht then %et a response such as LOUD and CLEAR but omission of a comment indicates LOUD and CLEAR