Beruflich Dokumente
Kultur Dokumente
Revision History
Date
July 2007
Revision
1.1
Description
Final Draft submission
Table of Contents
Using QoS on NETGEAR TA612V & WGR613V VoIP devices.Page 3 How to connect to your ADSL/Cable MODEM..Page 3 How to connect using an existing ROUTER or GATEWAYPage 4 Connecting to a QoS capable ADSL ROUTER/GATEWAYPage 5 How do I enable QoS in my NETGEAR VoIP product.Page 5 What figure should I put in for my BandwidthPage 6 What value should I use for the MTU.Page 6 How many simultaneous VoIP calls can I make...Page 6
LAN port
Internet port
LAN port
Internet port
Note: If you encounter problems using this method you may need to enable the DMZ option of the ADSL/CABLE/WIRELESS ROUTER and point it to the IP address assigned to the NETGEAR VoIP device. Alternatively you should port forward the following ports to the NETGEAR VoIP device; SERVICE TFTP SIP SIP(optional) RTP PORT 69 5060 5180 10000 - 10100 PROTOCOL UDP TCP TCP UDP
1. Log into your Netgear VoIP product. 2. Go to the WAN SETUP page, ensure the check box labeled Enable QoS is ticked. 3. Specify the BANDWIDTH value as per the guide below.
4. Click APPLY. Note: You may be prompted to set a different MTU value, this can usually be ignored but it is advisable to use 1492 or less for ADSL.
The value you set here depends on your broadband connection. See the next page to know what figure to put in here. 5