Beruflich Dokumente
Kultur Dokumente
Customer Client
: HYUNDAI Corporation : Black & Veatch Special Project Corp. (B&V) Project Name : Kandahar Helmand Power Date Issued : October 24, 2012
Operation Manual
for
1 0 Rev.
TABLE OF CONTENTS
1. 2. 3. 4. 5. 6. 7.
In-door Light System Emergency Light External Flood Light Louver Screen Exhaust Duct Screen Exhaust Fan Smoke Detector Attachment: Operation Manual of Fire Alarm Panel
page 1
page 2
1e. Twist the busted light bulb, making sure that the contact terminals are aligned with the holder slots. slots Then, gently pull the busted light bulb down.
page 3
1g. Install the replacement bulb, then replace the cover afterwards. afterwards
1h. Close the latches by pushing it upwards and against the side of the base.
page 4
1i. Check if all ten latches are already closed; then check the cover for proper fit. fit
page 5
page 6
page 7
2c. Push the "TEST" button to test if the light bulb is working properly.
2d. Remove the plug from the power outlet to check if the emergency g y light g is operating p gp properly. p y
page 8
2e. To replace the 9W bulb, use a screwdriver to lift the cover of the lamp head.
page 9
page 10
2j. Re-attach the lamp head cover, then push the "TEST" button to check if the replacement bulb is in good working condition.
page 11
page 12
3a. The external flood light shown located beside the single door.
3b. Remove the two (2) top screws to release the glass cover, let the cover swing outward but maintain steady supporting grip so as to prevent the cover from falling down.
page 13
3c. Remove the busted light and replace with a new bulb.
3d. Return the cover to upright position and tighten the screws.
page 14
page 15
page 16
page 17
page 18
5d. After drying, re-attach the exhaust duct screen and tighten g the nuts.
page 19
5b. Disconnect the exhaust fan wires from power supply wires. If the fan is defective, replace with a new one. If the fan is functional, clean the fan blades and support frame before re-attaching the fan to the wall frame.
page 20
page 21
page 22
7c. Twist off the smoke detector to release it from the base.
7d. After cleaning the smoke chamber, re-attach to it base. Install a new smoke detector if the p present one is already y defective.
page 23
page 24
page 25
page 26