Beruflich Dokumente
Kultur Dokumente
SIPROTEC 4 Ethernet Module EN100 for IEC 61850 with electrical/optical 100 MBit Interface
Manual
Design of the Ethernet Modules Commissioning in the Device Integration Into Networks Parameterization Additional Information Troubleshooting Hints Diagnostic Functions Technical Data Checklist for Commissioning Appendix Index
1 2 3 4 5 6 7 8 9 10 11
Disclaimer of Liability We have checked the text of this manual against the hardware and software described. However, since deviations cannot be ruled out entirely, we do not accept liability for complete conformity or for any any errors or omissions. The information given in this document is reviewed regularly and any necessary corrections will be included in subsequent editions. We appreciate any suggested improvements. Subject to technical modifications without notice. Document version: 01.10.00
Copyright Copyright Siemens AG 2013. All rights reserved. The reproduction, transmission or use of this document or its contents is not permitted without express written authority. Offenders will be liable for damages. All rights, including rights created by patent grant or registration of a utility model or design, are reserved. Registered Trademarks SIPROTEC, SINAUT, SICAM and DIGSI are registered trademarks of Siemens AG. Other designations in this manual may be trademarks that if used by third parties for their own purposes may violate the rights of the owner.
Preface
Content of this manual This manual describes the EN100-Module, protocol version IEC 61850, which can be used in all SIPROTEC 4 units. It is divided into the following sections: Introduction Chapter 1 Design of the Ethernet Modules Chapter 2 Commissioning in the Device Chapter 3 Integration Into Networks Chapter 4 Parameterization Chapter 5 Additional Information Chapter 6 Troubleshooting Hints Chapter 7 Diagnostic Functions Chapter 8 Technical Data Chapter 9 Checklist for Commissioning Chapter 10 Appendix Chapter 11 For general information on the operation, installation, commissioning, and configuration of SIPROTEC 4 units, please refer to the SIPROTEC 4 System Description (Order No.: E50417-H1140-C151). EN100-Module Specification The specification of the EN100-Module conforms to international standard IEC 61850. The most relevant part is Part 8: