Beruflich Dokumente
Kultur Dokumente
Select the file and open new. The below display is appeared.
Now select the folder right click and select Insert new device and Siprotec devices.
Now select the Type and Version of the relay and drag it to the folder.
Now feed the M !" n#mber which is available in the relay Settings$Set#p% E&tra$M !" version and then press '(.
'nce M !" n#mber is done. The relay type and version is displayed.
Now select the relay type then right click and initiali)e device.
Select connection type *irect and comm#nication port then press '(.
Select -ES
Now the +, will comm#nicate with the relay and the following screen will appear.
+ress '(.
Now right click on the type of the relay and select '+EN '"2E,T.
The above screen will appear and select *irect and press '(.
Select the *evice config#ration and do#ble click. !#nctional settings display will be opened.
!or programming "inary inp#ts$"inary o#tp#ts$ E*3s select Masking I$' ,onfig#ration and do#ble click.
Select the f#nction for which "inary o#tp#t has to config#red. 0ight click and select .ctive with voltage$.ctive with o#t voltage.
Select the f#nction for which the '#t p#t relay has to config#red4 then right click and select atched$5nlatched.
Select the f#nction for which the E* has to be config#red4 then right click and select for atched$5n latched.
,!, config#ration.
'nce this is done. Then this signal has to be config#red for ,!, IN and '5T.
Then close this window and go to main men# select ,!, and do#ble click.
*rag it here.
'nce the f#nction is selected4 Then yo# have to select the n#mber of inp#ts to be #sed for the f#nction.
Now select the page in which ogic gates are available. Then )oom it #ntil Inp#t$'#tp#ts appear.
Now select the inp#t then right click and select the gro#p to be connected.