Beruflich Dokumente
Kultur Dokumente
GENERAL DESCRIPTION
The TDA1060N is a bipolar integrated circuit intended for the control of a switched-mode power supply.
Ratings
Supply voltage (voltage source) Supply current (current source) Output current Output current Operating ambiant temperature range
Value
< 18 <30 <40 <40 -25 to 85
Unit
V mA mA mA C
www.DataSheet.net/
FUNCTIONAL DESCRIPTION
The TDA1060N contains the control loop for a fixed-frequency pulse-duration regulated SMPS. The device works as follows. The output voltage Vo of the SMPS is sensed via a feedback network and compared with an internal reference voltage Vref. Any difference between Vo and Vref is amplified and fed to a pulse-width modulator (PWM), where it is compared with the instantaneous level of a ramp waveform (sawtooth) from an oscillator. The output from the PWM is a rectangular waveform synchronized with the oscillator waveform ; its duty factor depends on the difference between Vo and Vref. This signal drives the base of the SMPS power switching transistor so that its conduction period and hence the amount of energy transferred from the input to the output of the SMPS is controlled, resulting in a constant output voltage.
29/10/2012
COMSET SEMICONDUCTORS
1|3
TDA1060N
ABSOLUTE MAXIMUM RATINGS
Symbol
VCC ICC V14 V15 -I14 I15 Tstg Tamb Ptot
Ratings
Supply voltage (voltage source) Supply current (current source) Emitter output voltage range Collector output voltage range Output current Output current Storage temperature range Operating ambiant temperature range Power dissipation (-25 to 60C)
Value
-0.5 to 18 <30 0 to 5 0 to VCC <40 <40 -55 to 150 -25 to 85 <0.9
Unit
V mA V V mA mA C C W
Symbol
Supply Current
Ratings
Test Condition(s)
www.DataSheet.net/
Min
Typ
Max
Unit
ICC
13
mA
-IZ
Output Current Measured at pins 3 and 4 interconnected and grounded Tamb=25C At V14=0V ;I15=40mA
mA
Vref
3.42
3.72
4.03
V15-14
400
mV
29/10/2012
COMSET SEMICONDUCTORS
2|3
TDA1060N
PINNING
Pin
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
Symbol
VCC VZ FB GA MOD DFM RX CX SYN EN CM VEE SAT QE QC FW
Descritions
Positive Supply Connection Stabilized Voltage Output Feedback Input Gain Adjustement Output Modulation Input Maximum Duty Factor Input External Resistor Connection External Capacitor Connection Synchronization Input ENABLE Input Overcurrent Protection Input Common Core Saturation And Overvoltage Protection Input Emitter Output Collrctor Output Feed-Forward Input
www.DataSheet.net/
www.comsetsemi.com
29/10/2012 COMSET SEMICONDUCTORS
info@comsetsemi.com
3|3
Datasheet
http://www.DataSheet4U.co.kr/