Beruflich Dokumente
Kultur Dokumente
Date :
Stage:
Revision:
Prepared by
ODM Supplier:
Check/Confirmed by:
Date:
1.
PCB
Is the correct PCB grade used? (See Annex 1)
PCB
Is the mechanical keep-out finalized?
Is the flux density level equal to 1.4 +/- 5% tesla? (See Annex 2)
1.4 +/- 5% ?
Is the Peak Excitation Current Ratio (PECR) less than 3dB? (See Annex 2)
3dB
Is the maximum excitation current less than 130% of the average measured value?
130%
Has the performance (mechanical transfo hum, tape hum, loading curve, temperature rise, etc) of the transformer been
verified?
Has the Brazilian requirement been met for /01 or /19?
/01 or /19 ?
Has the Indian requirement been met for /01 or /12?
/01 or /12 ?
Microprocessor
Has the User Requirement Specification (URS) been defined?
"(URS)"
Has the Hardware Software Interface (HIS) been defined?
"/(HIS)"
Has the Functional Requirement Specification (FRS) been defined?
"(FRS)"
Has the Factory Service Mode (FSM) been defined?
"(FSM)"
Are the port type (tri-state, open collector, interrupt, timer, etc) assigned correctly?
(,,,)
Are unused ports pulled-up or pulled-down?
?
Has the location of the uP w.r.t. tuner/sensitive circuit (pre-amp input, etc) been verified?
/,
Are inter-PCB logic/control lines level and RC time constant within IC specification?
IPCB/RCIC?
Has RC filters been provided for I/O pins to improve self-pollution?
,I/ORC
Preamplifier
Is the location of the pre-amp optimized w.r.t. :,
- Hand-effect
- Table-effect
- TV noise
TV
- ESD
- Hum pick-up
- Noise source (transformer, motor, digital electronics, etc.)
YES
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
IC Regulator IC
Is the regulator located far away (noise level increase <1.5 dB) from the ferrite bar?
( <1.5 dB)
Are the input/output capacitors placed near the IC to prevent oscillation?
IC
Motor/RP Head /
Is the orientation of the tape-deck motor optimized w.r.t. R/P head?
,?
Is the motor orientation optimized w.r.t. the ferrite bar?
,
Is the R/P head shielded to prevent table-hum?
?
Is the tape-deck d.c. grounded?
Heat Sink
Is the position of the heatsink optimized fo heat flow?
Is the ambient temperature surrounding the tuner and CD modules according to allowable maximum temperature?
CD
Amplifier
Is the position of the amplifier optimized w.r.t. the tuner esp. ferrite bar?
(),?
Is the position of the amplifier optimized w.r.t. the tape and mic input?
MIC,?
Are the speaker sockets placed near the amplifier (power loss <0.3 dB)?
( <0.3 dB)
Is the amplifier operating within SOAR limits?
SOAR(
Is the amplifier unconditionally stable (has sufficeint phase /gain margin)?
(/)
What is the ripple voltage at protection pin? Pcb layout position correct?
? PCB
Refer to IC
spec. and
design
reference info.
For digital amplifier, is the output inductor correctly use according to product spec. with enough margin?
Loudspeaker Socket
Is the position of the loudspeaker sockets optimized w.r.t. the tuner esp. ferrite bar?
(),?
Is the position of the loudspeaker sockets optimized w.r.t. the tape and mic input?
MIC,?
Miscellaneous
Is the IR viewing angle according to PQR? IRPQR
Is the IR operating distance according to PQR? IRPQR
Is the IR function affected by external light sources?
IR
2.
Block Diagram
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Are the following defined at the various stages of the block diagram for all versions:
,
- S/N
- Headroom
- Signal level
- Frequency reponse
3.
Switching/Muting Concept
Have care been taken to prevent muting circuity from distorting the audio signals?
Has the timing of the muting signal been defined and evaluated?
?
Are there separate muting circuits for audio signal and line-out?
4.
Supply Concept
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Are the voltages catering for sufficient headroom (headphone, amplifier, etc)?
(,)?
Are the temperatures of IC regulators within specification?
IC ?
Are the regulators sufficiently protected against fault conditions?
5.
Are simulations (breadboard, PC, etc) of the new circuit concept available?
(,)
Have the following been evaluated
6.
CD/ /
Grounding Concept
7.
Wiring Diagram
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
8.
Noise Performance
Are the digital circuits in the CD module switched off in Tuner mode?
CD
Are the PCB edges guarded by ground?
PCB ?
Are all elcos polarities for the signal paths correct?
9.
Safety Concept
10.
ESD Performance
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Requirem
YES
ent
N/A
NO
Meas.
Data /
Remarks
Supporti
ng data
Has FCR reports of similar concepts/ modules been reviewed to avoid recurrence of these problems in the new set?
/FCR
Critical to customer list
Learn for
the past
list
DEMO BOARD
MICRO
BOOM_BOX
MICRO
CDSM
DATE: 29-03-05
DEMO BOARD
DEMO BOARD
Set No.
Software Ver.
CDM
CD SERVO & DRIVE
Remark
Test date
DISCITEM
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10 10
11 11
12 12
13 13
14 14
15 15
16 16
17 17
18 18
19 19
20 20
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
1
2
3
4
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
2
3
1
2
3
4
5
4
5
6
7
8
9
10
11
12
13
14
15
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
16
17
18
19
20
21
22
23
24
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
1
2
3
4
5
6
7
100.0
100.0
100.0
100.0
100.0
100.0
100.0
100.0
(AL0/tr220)
(AL1/tr44)
(AL25/tr500)
(AL24/tr500)
(AL9/tr139)
(AL1/tr33)
(AL15/tr147)
(AL27/tr270)
(AL9/tr119)
(AL0/tr204)
(AL0/tr230)
(20 Folder/tr26)
***:
*1:
DISCITEM
1
1.1
1.2
1.3
1.4
1.5
1.6
2
2.1
2.2
2.3
2.4
2.5
DISCITEM
3
3.1
3.2
3.3
3.4
3.5
3.6
3.7
3.8
3.9
3.10
3.11
4
4
4.1
4.2
4.3
4.4
5
5.1
3.2
3.3
5.4
6.1
6.2
6.3
6.4
6.5
6.6
6.7
6.8
6.9
6.10
6.11
6.12
6.13
6.14
6.15
6.16
6.17
6.18
6.19
6.20
6.21
6.22
6.23
6.24
VCD PLAYABILITY
ABEX SVD TEST DISC
ABEX SVD-3047 Tr2, Black dot 0.4um
ABEX SVD-3047 Tr4, Black dot 0.6um
ABEX SVD-3047 Tr8/9, Black dot 0.8um
ABEX SVD-3047 Tr12/13, Black dot 1.0um
ABEX SVD-3047 Tr20/21, Normal Fingerprint 65um
ABEX SVD-3047 Tr24/25,Normal Fingerprint 75um
ABEX SVD-3048 Tr2/9, Scratch 0.4 um
ABEX SVD-3048 Tr11/17, Scratch 0.8 um
ABEX SVD-3048 Tr19/21, Scratch 1.2 um
ABEX SVD-3048 Tr23/26, Scratch 1.6 um
ABEX SVD-3048 Tr 27/31, Scratch 2.0 um
ABEX TCD-725 TEST DISC
ABEX TCD-725B Tr 2, Interruption 500um
ABEX TCD-725B Tr 3, Interruption 700um
ABEX TCD-725B Tr 4, Interruption 800um
ABEX TCD-725B Tr 5, Interruption 900um
ABEX TCD-725B Tr 6, Interruption 1000um
ABEX TCD-725B Tr 7, Black Dot 400um
ABEX TCD-725B Tr 8, Black Dot 600um
ABEX TCD-725B Tr 9, Black Dot 800um
ABEX TCD-725B Tr 10& Tr11, Black Dot 1000um
ABEX TCD-725B Tr 13, Fingerprints 65um
ABEX TCD-725B Tr 15, Fingerprints 75um
ABEX Eccentric TCD-713R TEST DISC
ABEX Eccentric TCD-713R TEST DISC
Eccentric TCD-713R. Tr 1 & Tr 24, 2105um (position 90 deg.)
Eccentric TCD-713R. Tr 1 & Tr 24, 2105um (position 180 deg.)
Eccentric TCD-713R. Tr 1 & Tr 24, 2105um (position 270 deg.)
Eccentric TCD-713R. Tr 1 & Tr 24, 2105um (position 3600 deg.)
ABEX Eccentric TCD-714R TEST DISC
Eccentric TCD-714R. Tr 1 & Tr 24, 280 5um (position 90 deg.)
Eccentric TCD-714R. Tr 1 & Tr 24, 280 5um(position 180 deg.)
Eccentric TCD-714R. Tr 1 & Tr 24, 280 5um(position 270 deg.)
Eccentric TCD-714R. Tr 1 & Tr 24, 280 5um(position 3600 deg.)
ABEX TVD-581A TEST DISC
ABEX TVD-581A Tr2 Monoscope 60 seconds
ABEX TVD-581A Tr3 Color Bar 60 seconds
ABEX TVD-581A Tr4 Stair Step B/W 5 steps 30 seconds
ABEX TVD-581A Tr5 Stair Step Color 5 steps 30 seconds
ABEX TVD-581A Tr6 Mod. Ramp 30seconds
ABEX TVD-581A Tr7 Mod. Ramp APL 10% 30seconds
ABEX TVD-581A Tr8 Mod. Ramp APL 90% 30seconds
ABEX TVD-581A Tr9 Multi Burst 50% 30seconds
ABEX TVD-581A Tr10 Multi Burst 100% 30seconds
ABEX TVD-581A Tr11 Pulse and Bar 30seconds
ABEX TVD-581A Tr12 Video Speep 0.1~6Mhz 60 Seconds
ABEX TVD-581A Tr13 Magenta 60 Seconds
ABEX TVD-581A Tr14 Green 50 Seconds
ABEX TVD-581A Tr15 Blue 50 Seconds
ABEX TVD-581A Tr16 Red 50 Seconds
ABEX TVD-581A Tr17 White 100% 50 Seconds
ABEX TVD-581A Tr18 Gray 50% 50 Seconds
ABEX TVD-581A Tr19 Black 0% 50 Seconds
ABEX TVD-581A Tr20 V. Bar 60 Seconds
ABEX TVD-581A Tr21 Monoscope Scroll 60 Seconds
ABEX TVD-581A Tr22 Character Scroll 60 Seconds
ABEX TVD-581A Tr23 A.V. SynchronousCheck 60 seconds
ABEX TVD-581A Tr24 Motion Picture 120 seconds
ABEX TVD-581A Tr25 monoscope (PAL) 60 seconds
Test_CD_vs_Projects_251103_0
...P.6/39
DEMO BOARD
MICRO
BOOM_BOX
MICRO
CDSM
DATE: 29-03-05
DEMO BOARD
DEMO BOARD
Set No.
Software Ver.
CDM
CD SERVO & DRIVE
Remark
Test date
6.25
6.26
6.27
6.28
6.29
6.30
6.31
7
10
11
12
13
7
7.1
7.2
7.3
7.4
7.5
7.6
7.7
7.8
7.9
7.10
7.11
7.12
7.13
8
8.1
8.2
9
9.1
9.2
9.3
9.4
9.5
9.6
9.7
10.1
11.1
12.1
13.1
SAMPLE_050329-6
Test_CD_vs_Projects_251103_0
...P.7/39
CDSM
0
Set No.
Software Ver.
CDM
Test date
Standard CD
Protect CD
Horror CD
Differ. brands of CDRs
Differ. brands CDRWs
Standard MP3
Horror MP3
UDF DISC (NEW)
VCD ALL DISC
Overall Maturity Level
TESTER: YQ CHEN
DEMO BOARD
MICRO
0
0
0
0
BOOM_BOX
0
0
0
0
0
0
0
0
MICRO
0
0
0
0
0
CDSM
0
0
0
0
0
0
0
0
DATE: 29-03-05
DEMO BOARD
DEMO BOARD
0
0
0
SAMSUNG
0
0
0
0
SAMSUNG
0
Pass
0
Playability Radar Diagram
Standard CD
VCD ALL DISC
Protect CD
50
Horror CD
90
70
50
Horror MP3
Differ. brands of CDRs
Standard
Differ. brands
MP3CDRWs
Protect CD
Horror CD
Horror MP3
80
Horror CD
50
Standard MP3
Differ. brands of CDRs
Differ. brands CDRWs
Horror MP3
Differ. brands of CDRs
Standard
Differ. brands
MP3CDRWs
90
70
50
Standard CD
UDF DISC (NEW)
Protect CD
Standard CD
Differ. brands CDRWs
Protect CD
Horror CD
Horror MP3
Standard CD
VCD ALL DISC
Protect CD
90
70
50
Horror CD
Horror MP3
Differ. brands of CDRs
Standard
Differ. brands
MP3 CDRWs
90
70
50
Horror CD
Standard MP3
Differ. brands of CDRs
Differ. brands CDRWs
90
70
50
Horror CD
Standard CD
VCD ALL DISC
Protect CD
Standard CD
UDF DISC (NEW)
Protect CD
Standard CD
82.0647058824
Standard CD
UDF DISC (NEW)
Protect CD
Horror MP3
90
70
50
Horror CD
Standard MP3
Differ. brands of CDRs
Differ. brands CDRWs
:
:
:
Testing Conditions:
1. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. power IC power dissipation
2. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. volume
3. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at burn-in condition
4. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. usable output power
Testing Condition 1
:
V
W
:
Prated:
1)
2) Aux ,flattest, APPsedou Pink noise, 500mV
3) CD , flattest,Pink noise,
4) 1.33 X
5) 1/4Pmax 4 hours
6) 35C
CD : < / = 55
Tuner : < / = 60
:
Mode
Components
Location
ohms
LSB :
0 hr
1/4hr
1/2hr
3/4hr
1 hr
1.5hr
2 hr
3 hr
4 hr
corrected temp.(c)
IC
regulator IC
Tuner IC
Aux in
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
IC
regulator IC
Tuner IC
CD
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitor
Tape
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
215577878.xls
HDD
PCB
Transformer
Capacitors
Tuner
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitors
HDD
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
USB
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
/
215577878.xls
:
:
:
Testing Conditions:
1. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. power IC power dissipation
2. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. volume
3. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at burn-in condition
4. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. usable output power
Testing Condition 2
:
V
W
:
Prated:
Mode
Components
Location
ohms
LSB :
0 hr
1/4hr
1/2hr
3/4hr
1 hr
1.5hr
2 hr
3 hr
4 hr
corrected temp.(c)
IC
regulator IC
Tuner IC
Aux in
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
IC
regulator IC
Tuner IC
CD
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitor
Tape
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
215577878.xls
HDD
PCB
Transformer
Capacitors
Tuner
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitors
HDD
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
USB
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
/
215577878.xls
:
:
:
Testing Conditions:
1. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. power IC power dissipation
2. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. volume
3. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at burn-in condition
4. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. usable output power
Testing Condition 3
:
V
W
:
Prated:
Mode
Components
Location
ohms
LSB :
0 hr
1/4hr
1/2hr
3/4hr
1 hr
1.5hr
2 hr
3 hr
4 hr
corrected temp.(c)
IC
regulator IC
Tuner IC
Aux in
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
IC
regulator IC
Tuner IC
CD
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitor
Tape
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
215577878.xls
HDD
PCB
Transformer
Capacitors
Tuner
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitors
HDD
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
USB
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
/
215577878.xls
:
:
:
Testing Conditions:
1. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. power IC power dissipation
2. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. volume
3. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at burn-in condition
4. Temp. profile at normal/upper/max (incl. 280Vac) mains voltage operation at max. usable output power
Testing Condition 4
:
V
W
:
Prated:
Mode
Components
Location
ohms
LSB :
0 hr
1/4hr
1/2hr
3/4hr
1 hr
1.5hr
2 hr
3 hr
4 hr
corrected temp.(c)
IC
regulator IC
Tuner IC
Aux in
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
IC
regulator IC
Tuner IC
CD
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitor
Tape
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
215577878.xls
HDD
PCB
Transformer
Capacitors
Tuner
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Capacitors
HDD
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
USB
IC
regulator IC
Tuner IC
Power Transistors
Power MOSFET
Power diodes
Power Inductors
Fuse
Connectors
Optical Pickup
HDD
PCB
Transformer
Transformer
Capacitors
/
215577878.xls
Timing specification
Item
Key press (but not hold)
Key press and hold
Watch dog trigger timer
Time period for FSM key detection after
power up
Time
<0.5s
>=0.5s
1.5s
Within 10s
Check Result
Remark
4s
10s
Standby to active
Source switching
Key response time (with some effect)
Double click interval
3s
3s
Within 1s
1s
7s
0.5s
4s
<1m
5s
>0.5s
2s
<1m
10s
2s
10s
EMC-Matrix CD-RCR
Version: 2
Frequency
in-band:
150 to 280kHz
0.5 to 1.7MHz
3 to 30MHz
65 to 108MHz
20Hz to 20kHz
0 to 4MHz
0 to 4MHz
0 to 4MHz
0 to 10kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
450kHz
10.7MHz
70-120MHz
Rectifier
Motor Carousel.Motor sledge Motor disc Motor Cass. RC-receiver LCD
0.7V
15V
5V
15V
30V
5V
5V
5A pk
1A pk
0.3A pk
1A pk
1A pk
0.5mA pk
100uA
0.1 to 500kHz
36kHz +harm. 75Hz+harm.
X
X
X
X
X
X
X
X
XXX
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
Coil Focus
20mV
1mA
0.1 to 200kHz
X
X
X
X
X
* Ferrite antenna is sensitive magnetic and quite a lot electrical. Frame aerial is less sensitive for electrical field.
Note1: Coils with core are modulated via magnetic fields; thats why transformers induces modulation hum
Note2: Standard axial coils behave like small antennas (sending and receiving)
Page 18 of 39
Coil Track
20mV
1mA
0.1 to 200kHz
Power Amp.
10V
1A
up to 200kHz
Loudspeaker
10V
1A
up to 200kHz
Stabilizer-IC
10mV
10mA
up to 200kHz
CD-driver IC
20mV
1mA
0.1 to 200kHz
AM-IF
1Vrms
455kHz+harm.
Receivers
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
Page 19 of 39
Frequency
in-band:
150 to 280kHz
0.5 to 1.7MHz
3 to 30MHz
65 to 108MHz
20Hz to 20kHz
0 to 4MHz
0 to 4MHz
0 to 4MHz
0 to 10kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
450kHz
10.7MHz
70-120MHz
FM-IF
1Vrms
Control-uP
5V
2mA
10.7MHz+harm. 0 to 150MHz
CD-uP
5V
10mA
0 to 150MHz
CD dig.servo
5V
15mA
0 to 150MHz
CD-decoder
5V
20mA
0 to 150MHz
CD-DA
5V
3mA
0 to 150MHz
Wires
Volt.multiplier
to ECO5
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
Page 20 of 39
X
X
Ant. LW
*
Ant. MW
*
Ant. Tel. SW
Ant. Tel. FM
Head Rec/Pb
CD diode array
CD diode wires
CD HF-amp
CD driver IC
Tape Pb-IC
AF-wires
Power-amp
dig Vol. IC
Trans.amps
AM-Osc/Mix
AM-IF
FM-IF
FM-Osc/Mix
Sockets
Tapedrive
CD-drive
Bat. contacts
Keys
Display
Aerials
CD Doorswitc.
rnal -->
Frequency
in-band:
150 to 280kHz
0.5 to 1.7MHz
3 to 30MHz
65 to 108MHz
20Hz to 20kHz
0 to 4MHz
0 to 4MHz
0 to 4MHz
0 to 10kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
20Hz to 20kHz
ESD
4kV
3A pk
to 300MHz
ESD
15kV
10A pk
to 300MHz
0
X
X
X
X
450kHz
10.7MHz
70-120MHz
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
Mains spike
1.5kV
Radiation
up to 7V/m
Cond. I & U
3V on CDN
1 to 30MHz
150k to 1GHz
150k to 1GHz
X
X
X
X
XX
X
XX
X
X
X
XX
X
X
X
X
X
X
X
XX
XX
XX
XX
Page 21 of 39
SUPPLY VOLTAGE:
127/240V(60/50Hz)
DEVIATION:
SPEAKER
KHZ
DATE:
ohm
AUDIO FREQ:
REF. OUTPUT:
500
mW
HZ
BAND SECTION:
after modify:
13. Channel Balance
TAPE 0dB
+/-3
dB
CD 0dB
+/-3
-1
dB
+/-3
-2
dB
FM 67.5KHz Deviation
+/-3
-2
dB
REF
REF
dB
AUX 500
Output Power at reference & 10% THD versus Volume Position (different sound modes)
40
40
40
40
40
40
39
39
120
39
38
110
36
100
31
90
80
26
70
21
60
50
16
40
11
30
20
6
10
0
1
40
40
40
40
6
Column C
10
11
40
40 POW. X VOL.
40 POS. (127V) 40
FW-M371
- ROCK-
120
38
36
110
35
34
100
31
90
80
26
70
21
60
50
16
40
11
30
20
10
1
0
16 Hz
31.5 Hz
63 Hz
125 Hz
500
Hz E
Column
Column F
1 Khz
2 Khz
4 Khz
8 Khz
16 Khz
45
40
250 Hz
40
40
40
40
40
40
40
40
120
40
40
40
110
100
35
90
80
70
25
60
20
50
15
40
30
10
20
5
10
0
16 Hz
31.5 Hz
63 Hz
125 Hz
250 Hz
500 Hz
Column G
Column H
1 Khz
2 Khz
4 Khz
8 Khz
16 Khz
POT.(W)
VOL.(STEP)
30
50
15
40
30
10
20
5
10
0
16 Hz
31.5 Hz
63 Hz
125 Hz
250 Hz
500 Hz
Column G
Column H
1 Khz
2 Khz
4 Khz
8 Khz
16 Khz
40
40
40
40
40
40
40
40
40
120
110
39
100
38
90
80
70
36
60
35
35
35
50
POT.(W)
VOL.(STEP)
37
40
34
30
20
33
10
32
0
16 Hz
31.5 Hz
63 Hz
125 Hz
250 Hz
VOL
1 Khz
2 Khz
4 Khz
8 Khz
16 Khz
POT
JAZZ(DBB OFF)
Freq.
500 Hz
ROCK(DBB OFF)
TECHNO(DBB OFF)
OPTIMAL(DBB OFF)
Vol.
Pot.
Vol.
Pot.
Vol.
Pot.
Vol.
Pot.
16 Hz
40
60
40
60
40
63
40
62
31.5 Hz
40
60
40
60
40
63
40
62
63 Hz
40
60
40
67
40
60
40
60
125 Hz
40
67
40
101
40
95
40
100
250 Hz
40
108
40
105
40
98
40
100
500 Hz
40
111
40
108
40
105
40
103
1 Khz
40
112
40
110
40
105
40
105
2 Khz
39
108
40
110
40
104
40
105
4 Khz
8 Khz
39
38
108
101
38
34
108
105
40
40
101
100
40
35
105
90
16 Khz
39
90
35
101
40
80
35
100
Equipments used :
Others
CD mode
Audio Signals Disc 1
6 ohms resistive load
POT.(
VOL.(S
60
20
Test Items:
Remarks
India Requirement
Brazil Requirement
Brazil Requirement
Output Power at 10% THD versus Volume Position (Mains 246/127 Vac)
Sample No.1
40
40
40
39
39
38
120
110
36
100
31
90
80
26
70
21
60
50
16
40
11
30
20
10
0
1
40
40
40
40
6
Column C
10
11
120
38
36
34
35
110
100
31
90
80
26
70
21
60
50
16
40
11
30
20
10
1
16 Hz
31.5 Hz
63 Hz
125 Hz
250 Hz
E1 Khz
500 Column
Hz
Column F
0
2 Khz
4 Khz
8 Khz
16 Khz
45
40
40
40
40
40
40
40
40
40
120
40
40
40
110
100
90
30
80
70
25
60
20
50
15
40
30
10
20
5
10
0
16 Hz
40
40
31.5 Hz
40
63 Hz
40
125 Hz
250 Hz
500 Column
Hz
G1 Khz
Column H
40
2 Khz
4 Khz
8 Khz
40
120
110
39
100
38
90
80
37
70
36
60
35
35
35
50
40
34
30
20
33
10
32
0
16 Hz
31.5 Hz
63 Hz
125 Hz
250 Hz
500 Hz
VOL
JAZZ(DBB OFF)
ROCK(DBB OFF)
1 Khz
2 Khz
4 Khz
8 Khz
16 Khz
POT
Freq.
16 Hz
31.5 Hz
63 Hz
125 Hz
250 Hz
500 Hz
1 Khz
2 Khz
4 Khz
8 Khz
Vol.
40
40
40
40
40
40
40
39
39
38
Pot.
60
60
60
67
108
111
112
108
108
101
Vol.
40
40
40
40
40
40
40
40
38
34
Pot.
60
60
67
101
105
108
110
110
108
105
Vol.
40
40
40
40
40
40
40
40
40
40
Pot.
63
63
60
95
98
105
105
104
101
100
Vol.
40
40
40
40
40
40
40
40
40
35
Pot.
62
62
60
100
100
103
105
105
105
90
16 Khz
39
90
35
101
40
80
35
100
Equipments used :
Others
POT.(W)
VOL.(STEP)
16 Khz
POT.(W)
VOL.(STEP)
35
150
130
Potncia (W)
110
90
70
50
30
10
-10
Frequncia
63 Hz
125 Hz
1 KHz
10 KHz
95 V
67.00
67.00
71.00
81.00
110 V
78.00
89.00
89.00
105.00
Equipments used :
MAINS MAX ON
127 V
140 V
89.00
90.00
105.00
113.00
108.00
117.00
130.00
140.00
220 V
90.00
105.00
105.00
135.00
240 V
90.00
113.00
117.00
140.00
Others
Sample No.2
M X. POT. P/ M X. VOL.
35 150
30 130
25 110
20 90
70
15
50
10
30
5
10
0100-10
Hz
Frequncia
100 Hz
125 Hz
1 KHz
10 KHz
95 V
70.00
70.00
71.00
80.00
95 V
110 V
75.00
78.00
90.00
105.00
125 Hz
110 V
220 V
90.00
100.00
105.00
121.00
127 V
240 V
100.00
101.00
108.00
121.00
140 V 1 KHz
220 V
240 V
10 KHz
Model Number
Brand Name
Model Name
Is your Organization the OEM?
If not Who Is?
Initial Date of Manufacture
Date No Longer Manufactured
Date Available on the Market
Manufacturer Suggested Retail Price
To what major markets is sold
US, Canada, Mexico
Is the Product Shipped with Energy Star Label?
On top/front of product?
In Product Literature?
On Product packaging/box?
On Internet Site?
If the answer to any of the above is No, Please explain
If not self tested, please specify Testing Facility
Date Tested
Product Type (AUDIO, Television or Digital Television)
Product Image
Product Description
*Watts in Standby
Has an illuminated display? (Yes/No)
Number of Standby Modes
If More than one mode, please explain
Power Supply Rated Power Watts
Power Supply Type I (Linear/Switch)
Power Supply Type II (Internal/External)
Power Supply Single Voltage (Rated Amps)
Power Supply Multiple Voltage (rated Amps)
Power Supply Efficiency at 25% of rated load
Power Supply Efficiency at 50% of rated load
Power Supply Efficiency at 75% of rated load
Power Supply Efficiency at 100% of rated load
Watts drawn in No Load
Technology (Analog, Digital, Both)
Tier
Screen Size (Inches)
Screen Type (Plasma, LCD, Standard)
Number of Heads
Mono/Stereo
Hi Fi (Yes or no)
Digital Video inputs (DVI Firewire, iLink)
PIP (Yes/no/Na)
Flat Screen (Yes/No)
Wide Screen (Yes/No/Na)
Home Theater Ready (Yes/No/Na)
Commercial Skip Function (Yes/No/Na)
Digital Tuner ( Yes/No/Na)
Height
Width
Depth
SELF TESTED
AVAILABLE @ WWW.PHILIPSUSA.COM
N/A
N/A
N/A
N/A
Energy consumption
AR17-Cxx-5051-xxx
Philips
Power source
Mains
Battery
wk/yr
52
0
h/wk
132.9
24.3
2.9
1.8
6.1
0
Mains use
4.1 Function
Standby/off
Tuner
Tape play
tape record
CD play
Display dim
AC SUPPLY VOLTAGE(V)
Consumption per year
4.2 Function
Standby/off
Tuner
Tape play
tape record
CD play
Display dim
Total / year
Percentage score
Title of benchmark
Sony
DVD
Panasonic
Philips
Philips
DATE:
Philips
Philips
hr/yr
8760
0
KiloWatt
1000
Unit
[W]
[W]
[W]
[W]
[W]
[W]
[W]
Unit
[kWh/yr]
[kWh/yr]
[kWh/yr]
[kWh/yr]
[kWh/yr]
[kWh/yr]
[kWh/yr]
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
[%]
100.0
#DIV/0!
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
#DIV/0! #DIV/0!
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
#DIV/0!
#DIV/0!
#DIV/0!
31
Energy consumption
AR17-Cxx-5051-xxx
Energy
percentage score
120.0
100.0
80.0
[%]
60.0
100.0
40.0
20.0
0.0
0
Title of benchmark
32
Energy consumption
AR17-Cxx-5051-xxx
Display dim
CD play
Tape play
Tuner
1
1
[kWh]
Standby/off
1
0
0
0
0
0
0
Title of benchmark
33
Test Condition: SG. Any. (Horizontal) / All Sets use Pigtail 1.5m (Horizotal straight to the rear)
91
STATION
DUT
SET Ref.14.0
LX3600
Set
92.5
93.5
93.9
94.6
98.3
100.7
101.3
102.6
106.4
107.1
(Pigtail
1.5M) 12.0
13.0
FWD570 Reworked
Set#2
18.0
13.0
13.0
FWD39 Reworked
Set#2
18.0
13.0
13.0
12.0
10.0
11.0
14.0
12.0
12.0
12.0
14.0
12.0
10.0
11.0
14.0
14.0
14.0
13.0
14.0
12.0
10.0
11.0
12.0
12.0
14.0
14.0
14.0
25
23
21
LX3600 Ref. Set (Pigtail
1.5M)
19
17
15
13
11
9
7
5
91
92.5 93.5 93.9 94.6 98.3 100.7 101.3 102.6 106.4 107.1
Lvl
[T1]
-16.28
dBA
101.59118236
RBW
kHz
dBA
VBW
kHz
MHz
SWT
5.8
Att
dB
Marker
Ref
Unit
dBA
20
20
Lvl
[T1]
-19.86
dBA
90.29358717
RBW
kHz
dBA
VBW
kHz
MHz
SWT
5.8
RF
Att
Unit
dB
dBA
20
A
15
15
10
10
IN1
1AP
1VIEW
-5
-5
-10
-10
D1
-15
-15
dBA
IN1
1AP
1VIEW
D1
-15
-15
dBA
1
-20
-20
-25
-25
-30
-30
Center
Date:
97.75
MHz
2.APR.2005
2.05
23:51:03
MHz/
Span
20.5
MHz
Center
Date:
97.75
MHz
2.APR.2005
2.05
23:47:52
MHz/
Span
20.5
MHz
Lvl
[T1]
-21.48
dBA
104.87775551
RBW
kHz
dBA
VBW
kHz
MHz
SWT
5.8
RF
Att
Unit
dB
dBA
20
A
15
SGL
10
IN1
1AP
-5
-10
D1
-15
-15
dBA
-20
-25
-30
Center
Date:
97.75
MHz
2.APR.2005
2.05
22:34:34
MHz/
Span
20.5
MHz
dB
dBA
A
IN1
1AP
20.5
MHz