Sie sind auf Seite 1von 7

P8.20 A WT305 x 41 standard steel shape is used to support the loads shown on the beam in Figure P8.20a.

The dimensions from the top and bottom of the shape to the centroidal axis are shown on the sketch of the cross section (Figure P8.20b). Consider the entire 10 m length of the beam and determine (a) the maximum tension bending stress at any location along the beam, and (b) the maximum compression bending stress at any location along the beam.

P8.21 A steel tee shape is used to support the loads shown on the beam in Figure P8.21a. The dimensions of the shape shown in FigureP8.21b are d= 450mm, bf = 300mm,tf = 25mm,and tw = 16 mm. Consider the entire 7.5 m length of the beam and determine (a) the maximum tension bending stress at any location along the beam, and (b) the maximum compression bending stress at any location along the beam

P8.26 The steel beam in Figure P8.26a/27a has the cross section shown in Figure P8.26b/27b. The beam length is L = 6.0 m, and the cross-sectional dimensions are d = 350 mm, bf =

205 mm, tf = 14 mm, and tw = 8 mm. Calculate the largest intensity of distributed load w0 that can be supported by this beam if the allowable bending stress is 200 MPa.

P8.29 A W410 x 60 standard steel shape is used to support the loads shown on the beam in Figure P8.29. The shape is oriented so that bending occurs about the strong axis. Determine the magnitude and location of the maximum bending stress in the beam.

P9.11 A 5 m long simply supported wood beam carries a uniformly distributed load of 12 kN/m, as shown in Figure P9.11a. The cross-sectional dimensions of the beam are shown in Figure P9.11b. (a) At section aa, determine the magnitude of the shear stress in the beam at point H. (b) At section aa, determine the magnitude of the shear stress in the beam at point K.

(c) Determine the maximum horizontal shear stress that occurs in the beam at any location within the 5 m span length. (d) Determine the maximum compression bending stress that occurs in the beam at any location within the 5 m span length.

P9.21 The cantilever beam shown in Figure P9.21a/22a is subjected to a concentrated load of P = 350 kN. The

cross-sectional dimensions of the wide-flange shape are shown in Figure P9.21b/22b. Determine (a) the shear stress at point H, which is located 120 mm below the centroid of the wide-flange shape. (b) the maximum horizontals hear stress in the wide-flange shape.

P9.25 The internal shear force V at a certain section of an aluminum beam is 8 kN. If the beam has the cross section shown in Figure P9.25, determine (a) the shear stress at point H, which is located 30 mm above the bottom surface of the tee shape.

(b) the maximum horizontal shear stress in the tee shape.

Das könnte Ihnen auch gefallen