Beruflich Dokumente
Kultur Dokumente
Lead Time/Availability
April 2013 6 weeks after receipt of order 6 weeks after receipt of order
Product Highlights
Elevation pattern upper sidelobe suppression of typically better than 18 dB across the frequency band and downtilts helps reduce adjacent cell interference and increase data throughput. Nullfill included in the elevation pattern helps maintain signal levels in the coverage area, therefore reducing interference and increasing data throughput. Azimuth beamwidth stability across the frequency band provides better coverage and uniformity of coverage across the band. Horizontally spaced high band array configurations for optimum MIMO performance. Internal Smart Bias Tee allows input of the AISG signal using the antenna RF port, avoiding the need to use AISG jumper cables. The integration of these components in the antenna further reduces the external components and cables that are required on the tower and improves network performance and reliability. No additional phase shift or insertion loss from inclusion of internal Smart Bias Tee for optimum MIMO performance.
Input and Output AISG Connectors included for ease in daisy-chaining RET control to other antennas. Connector caps with O-ring seals for waterproofing connectors not terminated at installation.
www.commscope.com
2013 CommScope, Inc. All rights reserved. All trademarks identied by or are registered trademarks or trademarks, respectively, of CommScope. All specications are subject to change. See www.commscope.com for the most current information. (PA-106618-EN)
Page 1 of 5 3/2013
-5.00
-10.00
-15.00
-5.00 10 dB Beamwidth 698 MHz 125 -10.00 830 MHz 130 960 MHz 120 -15.00
-20.00
-20.00
-25.00
-25.00
-30.00
-170 -150 -130 -110 -90 -70 -50 -30 -10 10 30 50 70 90 110 130 150 170 -180 -160 -140 -120 -100 -80 -60 -40 -20 0 20 40 60 80 100 120 140 160 180
-30.00
-170 -150 -130 -110 -90 -70 -50 -30 -10 10 30 50 70 90 110 130 150 170 -180 -160 -140 -120 -100 -80 -60 -40 -20 0 20 40 60 80 100 120 140 160 180
-5.00
-10.00
-15.00
-5.00 10 dB Beamwidth 1710 MHz 125 -10.00 2110 MHz 120 2690 MHz 105 -15.00
-20.00
-20.00
-25.00
-25.00
-30.00
-170 -150 -130 -110 -90 -70 -50 -30 -10 10 30 50 70 90 110 130 150 170 -180 -160 -140 -120 -100 -80 -60 -40 -20 0 20 40 60 80 100 120 140 160 180
-30.00
-170 -150 -130 -110 -90 -70 -50 -30 -10 10 30 50 70 90 110 130 150 170 -180 -160 -140 -120 -100 -80 -60 -40 -20 0 20 40 60 80 100 120 140 160 180
www.commscope.com
2013 CommScope, Inc. All rights reserved. All trademarks identied by or are registered trademarks or trademarks, respectively, of CommScope. All specications are subject to change. See www.commscope.com for the most current information. (PA-106618-EN)
Page 2 of 5 3/2013
17102690 MHz
17102690 MHz
RF/AISG Ports
www.commscope.com
2013 CommScope, Inc. All rights reserved. All trademarks identied by or are registered trademarks or trademarks, respectively, of CommScope. All specications are subject to change. See www.commscope.com for the most current information. (PA-106618-EN)
Page 3 of 5 3/2013
RVVPX310B1Q
www.commscope.com
2013 CommScope, Inc. All rights reserved. All trademarks identied by or are registered trademarks or trademarks, respectively, of CommScope. All specications are subject to change. See www.commscope.com for the most current information. (PA-106618-EN)
Page 4 of 5 3/2013
Frequency Range, MHzhigh band: 2x17102690 Number of Portshigh band: Gainbottom, dBi: Gaintop, dBi: USLS, dBtypical:
*up to 20 above horizon
4 18.0 - <18*
8 8
Polarization: Horizontal Beamwidth, deg: Electrical Beamtilt, deg: LengthxWidthxDepth, mm: Weight, kg:
Dual Slant 45 65
www.commscope.com
2013 CommScope, Inc. All rights reserved. All trademarks identied by or are registered trademarks or trademarks, respectively, of CommScope. All specications are subject to change. See www.commscope.com for the most current information. (PA-106618-EN)
Page 5 of 5 3/2013
Frequency Range
Band 2 & 3 1710-2690 MHz 890-960 16.5 dBi 1710-1920 1920-2170 2300-2690 16.8 dBi 17.2 dBi > 14dB Dual Slant 45 62 8 62 8.2 62 7.2 62 5.8 18 dBi
16 dBi
67 9.8
65 8.8
> - 22 dB typical 0 - 10 continuous, bands independently adjustable < -18 dB < -18 dB typical up to 20 above horizon > 25 dB > 25 dB > 30 dB 300W average per port 50 ohm DC grounded inner/ outer conductor 6 x 7 - 16 DIN female Internal motor and manual override. Internal Bias T Port 1 Band 1.
8 pin male and female IN/OUT pair. Bands cascaded SRET
MAXIMUM ENVIRONMENTAL RATINGS Humidity Lateral Loading (Front) Lateral Loading (Rear) Rain Rated Wind Velocity Temperature 95% RH @ +30C 1.32 kN @ 160 km/h 1.12 kN @ 160 km/h 140 mm per hour 200 km/h -40C to +70C
180
3 0
150
3 0
-10
-20
-30
180
-10
-20
-30
-150
-30
-150
-30
-120 -90
-60
-120 -90
-60
150
3 0
150
3 0
180
-10
-20
-30
180
-10
-20
-30
-150
-30
-150
-30
-120 -90
-60
-120 -90
-60
Last Modied: 20/02/2013 W: www.argusantennas.com E: info@argusantennas.com Argus Technologies is continually improving products. Specications may change at any time without notice.
Frequency Range
1710-2690 MHz 890-960 16.5 dBi 1710-1920 1920-2170 2300-2690 16.8 dBi 16.5 dBi 17.2 dBi 16.9 dBi > 14dB Dual Slant 45 62 8 62 8.2 62 7.2 62 5.8 18 dBi 17.7 dBi
16 dBi
67 9.8
65 8.8
> - 22 dB typical 0 - 10 continuous, bands independently adjustable < -18 dB < -18 dB typical up to 20 above horizon > 25 dB > 25 dB > 30 dB 300W average per port 50 ohm DC grounded inner/ outer conductor 10 x 7 - 16 DIN female Internal motor and manual override, Internal Bias-T from Port 1 Band 1
8 pin male and female IN/OUT pair. Bands cascaded SRET
Adjustable Clamps
9 0 6 0
UV Stabilised ASA
180 0 -10 -20 -30 0 180 0 -10 -20 -30 0
MAXIMUM ENVIRONMENTAL RATINGS Humidity Lateral Loading (Front) Lateral Loading (Rear) Rain Rated Wind Velocity Temperature 95% RH @ +30C 1.32 kN @ 160 km/h 1.12 kN @ 160 km/h 140 mm per hour 200 km/h -40C to +70C
-150
-30
-150
-30
-120 -90
-60
-120 -90
-60
150
3 0
150
3 0
180
-10
-20
-30
180
-10
-20
-30
-150
-30
-150
-30
-120 -90
-60
-120 -90
-60
Last Modied: 04/02/2012 W: www.argusantennas.com E: info@argusantennas.com Argus Technologies is continually improving products. Specications may change at any time without notice.
Frequency Range
1710-2690 MHz 890-960 16.8 dBi 1710-1920 1920-2170 2300-2690 16.5 dBi 16.2 dBi 17 dBi 16.7 dBi > 14dB Dual Slant 45 60 8 - 22 dB 65 8.2 62 7.2 60 5.8 18 dBi 17.7 dBi
16 dBi
63 9.8
62 8.8
0 - 10 continuous, bands independently adjustable > -18 dB typical > 25 dB > 25 dB > 30 dB 250W average per port < -150dBc (2 x 43 dBm)
MECHANICAL DATA Antenna Dimensions Packed Dimensions Weight Radome Material 2495 x 630 x 244 mm 2680 x 700 x 320 mm 65 kg UV Stabilised ASA
-150 180 0 -10 150
30
150
30
-20
-30
180
-10
-20
-30
-30
-150
-30
Humidity Lateral Loading (Front) Lateral Loading (Rear) Rain Rated Wind Velocity Temperature MOUNTING OPTIONS T-125-GL
95% RH @ +30C 1.80 kN @160 km/h 2.0 kN @160 km/h 140 mm per hour 200 km/h -40C to +70C
180 0 -10 -20 -30 150 120
Azimuth
90 60
120
Elevation
9 0 6 0
30
150
3 0
180
-10
-20
-30
Adjustable Clamps
-150
-30
-150
-30
-120 -90
-60
-120 -90
-60
Last Modied: 09/11/2012 W: www.argusantennas.com E: info@argusantennas.com Argus Technologies is continually improving products. Specications may change at any time without notice.
Number of Beams
(*)
Frequency Band(s) Polarization Customer Specific Variable Number of Elements
CV3
08.10
B1
DOWNTILT OPTIONS F = Fixed Electrical Tilt M = Manual Electrical Tilt R = Remote Electrical Tilt B = RET Integrated Bias Tee B1 = RET Integrated Bias Tee on Port 1, Band 1 B2 = RET Integrated Bias Tee on Port 3, Band 2 Please refer to product data sheet for more information.
NUMBER OF BEAMS = Standard Single Band Antenna 2 = 2 horizontal beams (Dual Beam) 5 = 5 horizontal beams 2X9 = Two rows of 9 horizontal beams FREQUENCY BAND(S) (MHz) B = 1920~2690 C = 824 (or 790)~960 H = 1525~1710 L = 2300~2700 N = 1710~2170 R = 698~960 R2 = 2 x 698~960 S = 3300~3800 U = 698894 V = 1710-2690 V3 = 3 x 1710-2690 V4 = 4 x 1710-2690
ANTENNA TYPE P = Panel N = Omni POLARIZATION X = 45 Dual Slant A = Vertical HORIZONTAL BEAMWIDTH () 2 = 33 (approximately) 3 = 65 (approximately) 4 = 90 (approximately) 6 = 120 (approximately) NUMBER OF ELEMENTS 8 = 8 (shown above for C Band) 10 = 10 (shown above for V Band) (Number of elements indicates the level of antenna gain. The gain is higher in the N Band in the example shown above.)