Sie sind auf Seite 1von 43

2005 Pontiac Vibe

2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

SPECIFICATIONS
FASTENER TIGHTENING SPECIFICATIONS

Fastener Tightening Specifications Application Front Bumper Fascia to Fender Bolts Front Bumper Fascia to Fender Liner Screws Front Bumper Fascia Upper Mounting Bolts Front Bumper Impact Bar Nuts Rear Bumper Fascia Nuts Rear Bumper Impact Bar Nuts Specification Metric English 5 N.m 44 lb in 5 N.m 44 lb in 5 N.m 44 lb in 36 N.m 26 lb ft 5.5 N.m 49 lb in 36 N.m 26 lb ft

REPAIR INSTRUCTIONS
INSERT REPLACEMENT - FRONT BUMPER FASCIA
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 1: Front Lower Fascia Insert Courtesy of GENERAL MOTORS CORP. Using a small flat-bladed tool, reach into the opening on the front lower fascia and depress the retaining tabs that lock the lower fascia insert.
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 2: Front Lower Fascia Insert Courtesy of GENERAL MOTORS CORP. Position the lower fascia insert retaining tabs to the slots in the front lower fascia. Install the lower fascia insert by pressing into place until the retaining tabs are fully seated.
FASCIA EXTENSION REPLACEMENT - FRONT
Removal Procedure

1. Raise and support vehicle. Refer to Lifting and Jacking the Vehicle in General Information.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 3: Fascia Extension Components Courtesy of GENERAL MOTORS CORP. 2. Remove the push-retainer (1). 3. Remove the screw (3) and washer (4) from bracket (5). 4. Remove the bracket (5) from the front bumper fascia extension (2).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 4: Front Bumper Fascia Extension and Screw Courtesy of GENERAL MOTORS CORP. 5. Remove the screw (2) from the front bumper fascia extension (1).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 5: Removing/Installing Fascia Extension Components Courtesy of GENERAL MOTORS CORP. 6. Remove the nuts (1) from the set screws (2). 7. Remove the screws (5) and washers (4) from the brackets (6). 8. Remove the front bumper fascia extension. Refer to Molding/Nameplate Replacement Exterior Trim in Exterior Trim. 9. Remove the front bumper fascia extension brackets, if necessary.
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

1. Install the front bumper fascia extension brackets, if removed. 2. Install two way tape to the front bumper fascia extension. Refer to Molding/Nameplate Replacement - Exterior Trim in Exterior Trim. 3. Peel back 25.0 mm of the tape liner from both ends. 4. Align front bumper fascia extension to the brackets.

Fig. 6: Removing/Installing Fascia Extension Components Courtesy of GENERAL MOTORS CORP. NOTE: Refer to Fastener Notice in Cautions and Notices.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

5. Install the screws (5) and the washers (4) to the brackets (6). Tighten: Tighten the screws to 5 N.m (44 lb in). 6. Install the nuts (1) to the set screws (2). Tighten: Tighten the nuts to 5 N.m (44 lb in).

Fig. 7: Front Bumper Fascia Extension and Screw Courtesy of GENERAL MOTORS CORP. 7. Install the screw (2) to the front bumper fascia extension (1).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Tighten: Tighten the screw to 2.5 N.m (22 lb in).

Fig. 8: Fascia Extension Components Courtesy of GENERAL MOTORS CORP. 8. Install the bracket (5) to the front bumper fascia extension (2). 9. Install the screw (3) and washer (4) to the bracket (5). Tighten: Tighten the screw to 5 N.m (44 lb in).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

10. Install the push in retainer (1). 11. Remove the tape liner from the rear of the front fascia extension and press down working from the rear to get good adhesion. 12. Lower vehicle.
FASCIA REPLACEMENT - FRONT BUMPER
Tools Required

J 38778 Door Trim Pad and Garnish Clip Remover


Removal Procedure

1. Remove the front fascia extensions, if equipped. Refer to Fascia Extension Replacement Front in Bumpers.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 9: Front Bumper Fascia Components Courtesy of GENERAL MOTORS CORP. 2. 3. 4. 5. 6. 7. 8. 9. Remove the screws (4) and separate the fender liner from the front fascia. Remove the bolts (1) from the top of the front fascia. Remove the screws (3) that separate the front fascia from the fender. Remove the push-in retainers (2) from the bumper fascia using J 38778 . Disconnect the fog lamp electrical connectors. Remove the fascia from the vehicle. Remove the fog lamps. Refer to Fog Lamp Replacement - Front in Lighting Systems. Remove the grilles from the fascia. Refer to Fascia Grille Replacement (Upper) or

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fascia Grille Replacement (Lower) . 10. Remove the fascia inserts. Refer to Insert Replacement - Front Bumper Fascia .

Fig. 10: Upper and Lower Fascia Screws Courtesy of GENERAL MOTORS CORP. 11. Remove the 10 screws from the upper and lower fascias, if equipped with a 2-piece fascia.
Installation Procedure

Fig. 11: Upper and Lower Fascias Screws Courtesy of GENERAL MOTORS CORP.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

1. Assemble the upper and lower fascias with the 10 screws, if equipped with 2-piece fascia. 2. Install the fascia inserts. Refer to Insert Replacement - Front Bumper Fascia . 3. Install the grilles. Refer to Fascia Grille Replacement (Upper) or Fascia Grille Replacement (Lower) . 4. Install the fog lamps. Refer to Fog Lamp Replacement - Front in Lighting Systems. 5. Position the fascia to the vehicle. 6. Connect the fog lamp electrical connectors.

Fig. 12: Front Bumper Fascia Components Courtesy of GENERAL MOTORS CORP. 7. Install the push-in retainers (2) to the front fascia.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

NOTE:

Refer to Fastener Notice in Cautions and Notices.

8. Install the bolts (1) to the front fascia. Tighten: Tighten the fascia bolts to 5 N.m (44 lb in). 9. Install the screws (3) that connect the front fascia to the fender. Tighten: Tighten the fascia to fender screws to 5 N.m (44 lb in). 10. Install the screws (4) that connect the front fascia to the fender liners. Tighten: Tighten the fascia to fender liner screws to 5 N.m (44 lb in). 11. Install the front fascia extensions, if removed. Refer to Fascia Extension Replacement Front in Bumpers.
FASCIA GRILLE REPLACEMENT (UPPER)
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 13: Fascia Grille Bolts and Retainers Courtesy of GENERAL MOTORS CORP. 1. Remove the 3 push in retainers (1) from the front upper fascia (4). 2. Remove the 2 bolts (2) from the front upper fascia (4). 3. Using a small flat-bladed tool, reach into the opening behind the front fascia and depress the retaining tabs that lock the front fascia grille (3) to the front fascia (4). 4. Remove the grille (3) from the front fascia (4).
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 14: Fascia Grille Bolts and Retainers Courtesy of GENERAL MOTORS CORP. 1. 2. 3. 4. Position the grille retaining tabs to the slots in the front upper fascia (4). Install the grille (3) by pressing into place until the retaining tabs are fully seated. Install the 3 push in retainers (1) to the front upper fascia (4). Install the 2 bolts (2) to the front upper fascia (4).

FASCIA GRILLE REPLACEMENT (LOWER)


Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 15: Front Lower Fascia Courtesy of GENERAL MOTORS CORP. Using a small flat-bladed tool, reach into the opening on the front lower fascia (1) and depress the retaining tabs that lock the lower fascia grille (2).
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 16: Front Lower Fascia Courtesy of GENERAL MOTORS CORP. Position the grille retaining tabs to the slots in the front lower fascia (1). Install the grille (2) by pressing into place until the retaining tabs are fully seated.
IMPACT BAR REPLACEMENT - FRONT BUMPER
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 17: Impact Bar and Nuts Courtesy of GENERAL MOTORS CORP. 1. Remove the front bumper fascia. Refer to Fascia Replacement - Front Bumper . 2. Remove the front bumper fascia energy absorber from the front bumper impact bar. 3. Remove the 4 nuts (2) which secure the front bumper impact bar.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 18: Removing Impact Bar Courtesy of GENERAL MOTORS CORP. 4. Remove the front bumper impact bar (1) from the front bumper impact bar outer brackets.
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 19: Impact Bar and Nuts Courtesy of GENERAL MOTORS CORP. NOTE: Refer to Fastener Notice in Cautions and Notices.

1. Install the front bumper impact bar (1) to the front bumper impact bar outer brackets. Secure the impact bar with the 4 nuts (2). Tighten: Tighten the front bumper impact bar nuts to 36 N.m (26 lb ft). 2. Install the front bumper fascia energy absorber from the front bumper impact bar. 3. Install the front bumper fascia. Refer to Fascia Replacement - Front Bumper .
ENERGY ABSORBER REPLACEMENT - FRONT
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 20: Front Energy Absorber Courtesy of GENERAL MOTORS CORP. 1. Remove the front bumper fascia. Refer to Fascia Replacement - Front Bumper . 2. Remove the front bumper fascia energy absorber (1) from the front bumper impact bar.
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 21: Front Energy Absorber Courtesy of GENERAL MOTORS CORP. 1. Install the front bumper fascia energy absorber (1) to the front bumper impact bar. 2. Install the front bumper fascia. Refer to Fascia Replacement - Front Bumper .
FASCIA EXTENSION REPLACEMENT - REAR
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 22: Rear Fascia Extension, Screws and Spacers Courtesy of GENERAL MOTORS CORP. 1. Remove the screws (3) and spacers (1) from the left and right sides of the rear bumper fascia extension (2).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 23: Rear Fascia Extension Screws and Washers Courtesy of GENERAL MOTORS CORP. 2. Remove the lower screws and washers from the rear bumper fascia extension. 3. Remove the rear bumper fascia extension and two way tape. Refer to Molding/Nameplate Replacement - Exterior Trim in Exterior Trim.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 24: Rear Fascia Extension Components Courtesy of GENERAL MOTORS CORP. 4. Remove the rear bumper fascia extension screws (5), washers (4) and brackets (3) from rear fascia, if necessary. 5. Remove the Remove the U-clips (2) from the rear fascia (1), if necessary.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 25: Rear Fascia Extension Components Courtesy of GENERAL MOTORS CORP. 6. Remove the nuts (2), bolts (5), washers (3) and brackets (4) from the rear fascia (1), if necessary.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 26: Rear Fascia Extension U-clips Courtesy of GENERAL MOTORS CORP. 7. Remove the U-clips from the left and right sides of the rear fascia, if necessary.
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 27: Rear Fascia Extension U-clips Courtesy of GENERAL MOTORS CORP. 1. Install the U-clips to the left and right sides of the rear fascia, if removed.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 28: Rear Fascia Extension Components Courtesy of GENERAL MOTORS CORP. NOTE: Refer to Fastener Notice in Cautions and Notices.

2. Install the brackets (4), bolts (5), washers (3) and nuts (2) to the rear fascia (1), if removed. Tighten: Tighten the nuts to 5 N.m (44 lb in).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 29: Rear Fascia Extension Components Courtesy of GENERAL MOTORS CORP. 3. Install the U-clips (2) to the rear fascia (1), if removed. 4. Install the rear bumper fascia extension brackets (3) to the rear fascia (1), if removed. 5. Install the screws (5) and washers (4) to the brackets (3), if removed. Tighten: Tighten the screws to 5 N.m (44 lb in). 6. Install two way tape to the rear fascia extension. Refer to Molding/Nameplate Replacement - Exterior Trim in Exterior Trim. 7. Peel back 25.0 mm of the two way tape liner from each end. 8. Position the rear fascia extension to the rear fascia and align to mounting holes.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 30: Rear Fascia Extension Screws and Washers Courtesy of GENERAL MOTORS CORP. 9. Install the lower screws and washers to the rear bumper fascia extension. Tighten: Tighten the lower screws to 5 N.m (44 lb in).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 31: Rear Fascia Extension, Screws and Spacers Courtesy of GENERAL MOTORS CORP. 10. Install the spacers (1) and screws (3) to the left and right sides of the rear bumper fascia extension (2). Tighten: Tighten the screws to 2.5 N.m (22 lb in). 11. Remove the two way tape liner from the rear bumper fascia extension, while pressing down for good adhesion.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

FASCIA REPLACEMENT - REAR BUMPER


Tools Required

J 38778 Door Trim Pad and Garnish Clip Remover


Removal Procedure

1. Remove the rear bumper fascia extension, if equipped. Refer to Fascia Extension Replacement - Rear .

Fig. 32: Rear Bumper Fascia Components Courtesy of GENERAL MOTORS CORP.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

2. Open the lift gate. 3. Remove the rear door sill plate. Refer to Door Sill Plate Replacement - Liftgate in Interior Trim. 4. Remove the 4 rear bumper fascia nuts (1) from the rear sill. 5. Remove the 4 push-in retainers (3) from the rear bumper fascia (5), using the J 38778 . 6. Remove the 2 screws (2) from the top right and left upper fascia. 7. Remove the 2 screws (5) and retainers (4) from the right and left upper fascia. 8. Disconnect the backup lamp electrical connectors. Refer to Backup Lamp Replacement in Lighting Systems. 9. Remove the rear bumper fascia (6) from the vehicle. 10. Remove the backup lamps from the vehicle, if required. Refer to Backup Lamp Replacement in Lighting Systems.
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 33: Rear Bumper Fascia Components Courtesy of GENERAL MOTORS CORP. 1. Install the backup lamps to the rear fascia, if removed. Refer to Backup Lamp Replacement in Lighting Systems. 2. Position the rear fascia (6) to the vehicle. 3. Install the 2 retainers (4) and screws (5) to the right and left upper fascia. 4. Install the 2 screws (2) to the right and left upper fascia corners. 5. Install the 4 push-in retainers (3) to the rear fascia (6). NOTE: Refer to Fastener Notice in Cautions and Notices.

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

6. Install the 4 rear bumper fascia nuts (1) to the rear sill. Tighten: Tighten the rear bumper fascia nuts to 5.5 N.m (49 lb in) 7. Install the rear sill plate. Refer to Door Sill Plate Replacement - Liftgate in Interior Trim. 8. Install the rear bumper fascia extension, if removed. Refer to Fascia Extension Replacement - Rear . 9. Close the lift gate.
ENERGY ABSORBER REPLACEMENT - REAR
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 34: Rear Energy Absorber, Bumper Impact Bar and Center Reinforcement Courtesy of GENERAL MOTORS CORP. 1. Remove the rear bumper fascia. Refer to Fascia Replacement - Rear Bumper . 2. Remove the rear bumper fascia energy absorber (3) from the rear bumper impact bar (1). 3. Remove the rear bumper bar center reinforcement (2) from the rear fascia energy absorber (3).
Installation Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 35: Rear Energy Absorber, Bumper Impact Bar and Center Reinforcement Courtesy of GENERAL MOTORS CORP. 1. Install the rear bumper bar center reinforcement (2) to the rear fascia energy absorber (3). Install the rear bumper fascia energy absorber (3) to the rear bumper impact bar (1). 2. Install the rear bumper fascia. Refer to Fascia Replacement - Rear Bumper .
IMPACT BAR REPLACEMENT - REAR BUMPER
Removal Procedure

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Fig. 36: Rear Bumper Impact Bar Components Courtesy of GENERAL MOTORS CORP. 1. Remove the rear bumper fascia. Refer to Fascia Replacement - Rear Bumper . 2. Remove the rear bumper fascia energy absorber. Refer to Energy Absorber Replacement - Rear . 3. Remove the following components from the vehicle: The 4 nuts (2) The rear bumper impact bar (1) The 4 push-in retainers (3) and the 2 rear bumper stays (4) from the impact bar (1), if necessary

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

Installation Procedure

Fig. 37: Rear Bumper Impact Bar Components Courtesy of GENERAL MOTORS CORP. NOTE: Refer to Fastener Notice in Cautions and Notices.

1. Install the 2 rear bumper stays (4) and the push-in retainers (3) to the impact bar (1), if removed. Install the rear bumper impact bar (1) to the vehicle. Secure the impact bar with 4 nuts (2). Tighten: Tighten the rear bumper impact bar nuts to 36 N.m (26 lb ft).

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

2. Install the rear bumper fascia energy absorber. Refer to Energy Absorber Replacement Rear . 3. Install the rear bumper fascia. Refer to Fascia Replacement - Rear Bumper .

DESCRIPTION AND OPERATION


BUMPER AND FASCIA DESCRIPTION

The front bumper fascia and rear bumper fascia are made of urethane. The urethane bumpers withstand minor impact and the bumpers return to their original shape. Refer to Plastic Panel Information and Repair for fascia repair and/or Paint/Coatings for fascia refinishing. Use care around theft deterrent labels.
Energy Absorbing - Bumpers

The front and the rear bumpers contain energy absorbers which are made of a polystyrene material. The energy absorbers are positioned between the bumper impact bar and the bumper fascia. The vehicle bumpers are designed to withstand a collision into a fixed barrier at 8 km/h (5 mph) with minimal damage. After absorbing the energy of a minor collision, these bumper system restore themselves to their original position.
THEFT DETERRENT LABEL DESCRIPTION

Federal law requires General Motors to label major parts of the vehicle with a theft deterrent label. The theft deterrent label is permanently affixed to the interior surface of the front and rear bumper fascias and contains the complete vehicle identification number (VIN). IMPORTANT: Theft deterrent labels are not to be defaced, removed or covered over. These labels must be shielded from paint, rustproofing, and undercoating (dealer preparation included). For further information on theft deterrent labels, refer to Labeling - Anti-Theft in General Information.

SPECIAL TOOLS AND EQUIPMENT


SPECIAL TOOLS

Special Tools Illustration Part Number/Description

2005 Pontiac Vibe


2005 ACCESSORIES & EQUIPMENT Bumpers - Vibe

J 38778 Door Trim Pad and Garnish Clip Remover

Das könnte Ihnen auch gefallen