Beruflich Dokumente
Kultur Dokumente
Question: HSRP has been configured between DSW1 and DSW2. DSW1 is configured to be active router but
2
1. ASW1 2. Port Security 3. Issue no switchport-security mac-address 0000.0000.0001 command followed by shutdown and not shut on fa1/0/1 on ASW1 1. ASW1 2. Access VLAN 3. Issue using inter range fa0/1-2 switchport access vlan 10 1. ASW1 2. Switch to switch connectivity 3. Issue switchport trunk allowed vlan 10,200 on inter port channel 13 and port channel 23
IP Client 1 169.X.X.X
Ipconfig on C1
1. R1 2. BGP 3. Under the BGP proccess, delete neighbor 209.56.200.226 remote-as 65002 and enter neighbor 209.65.200.226 remote-as 65002
1. R1 2. IP Access list 3. Add permit statement for 209.65.200.224network in ACL 30 1. R1 2. NAT 3. Add permit 10.2.0.0 statement in nat_pool access-list 1. R1 2. IPv4 OSPF Routing 3. Ip ospf authentication message-digest command has to be added on s0/0/0/0.12
IP C1 10.X.X.X C1 can`t ping default gw 1. DSW1 2. VLAN Access MAP VACL 3. Remove vlan filter test1 from DSW1 1. R4 2. IPv4 EIGRP Routing 3. Remove Passive interface under EIGRP 10.
1. R4 2. Route redistribution 3. Change the name in the redistribute command under OSPF precess to EIGRP->OSPF on R4 or delete the redistribute route-map EIGRP to OSPF and enter EIGRP->OSPF 1. R4 2. EIGRP 3. Change EIGRP AS number from 1 to 10 on R4 or change the AS on EIGRP routing proccess from 1 to 10 to much the AS number used DSW1 and DSW2
Question: DSW1 and R4 cannot ping R2s loopback or R2s s0/0/0/0.12 IPV6 address. Initial TSHOOT shows and R2is not ans OSPFv3 neighbor on R3 1. R2 2. OSPFv3 3. Add ipv6 ospf 6 area 0 under s0/0/0/0,23 on R2
C1 ping defalt f gw & R4, ping to s0/0/0,34 failed C1 ping df gw,R4 & s0/0/0,34 &EIGRP redistribute is OK