Beruflich Dokumente
Kultur Dokumente
1041-C 17th Ave. P.O.Box 2790 Santa Cruz, CA 95062 USA 408-462-5745
FAX
408-462-5357
Date
Scale
1:1
Revisions Date
July 18, 1987 March 11, 1991
Detail
update box molds to match dim. (orig. mold 6.156" x .610") update dim. for base molding
Tuttle Fin Box System - Fin Box Mold Dimensions Reference Dimensions Top - Box Part mold 4.361"/110.77 mm Top - Installed mold 4.376111.15 mm (tolerance .010"/.25 mm)
Notes Mold sides to be flat and parallel The lower edge must be thickner if there is any taper Top and bottom of mold to be square and straight Angle to be 80 for either Box Part or Installed mold Top dim. supplied for reference - angle spec. governs Top dim. is at 5.000"127 mm vertical length with 80 angle
80
A
Base Length - Fin Box Part only 6.125" (tolerance -0, +.004") 155.6 mm Base Length - As installed in board 6.140" 156 mm
.625" 15.9 mm
R=.25" 6.35 mm
.625" 15.9 mm
2.0"
1.25"
80
Clear hole
80
The foil may be positioned anywhere on the base, or may overlap the ends of the box.
Date
Scale
1:1
Drawn by
Date
Nov. 15, 1987 March 11, 1991 October 1992 May 1993
Revisions
update drawings to match mold dim. (orig. mold 6.156" x .610") update base dim. for molding add threaded insert dim./locaton add tolerances
Waterat Sailing Equipment/Fin Works 1041-C 17th Ave. P.O.Box 2790 Santa Cruz, CA 95062 USA 831-462-5745 831-462-0669 Fax 831-462-5357
90 4.135 105.038 .724 18.388 .491 12.471 .709 18.000 2.698 68.521 2.657 67.480 .472 12.000 Center of original base 1.260 32.000 2.038 51.768
80
80
6.140 155.956
Crossnuts - 9 mm OD Thread - US, Asutralia, Canada - 1/4-20 Japan, Europe - 6 mm Hole for screw - 7.5 mm Hole length - 32 mm (allows for a longer screw to be used)