Beruflich Dokumente
Kultur Dokumente
___________________________________________________________________________________________
2. HAZARDS IDENTIFICATION
Emergency Overview
Flammable. Irritant. May be harmful if swallowed.
Principal Routes of Exposure Eyes. Ingestion. Inhalation. Skin absorption. Skin contact.
Skin Direct contact may cause the following effects. Skin Irritation. Dermatitis. May be
absorbed through the skin in harmful amounts.
Inhalation Shortness of breath. Dizziness. Light headedness. May cause irritation to the lungs.
Central nervous system effects.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Page 1 / 7
Product code 91911 Product name Heavy Duty Chain Lubricant
___________________________________________________________________________________________
Eye contact Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes. Seek medical attention.
Inhalation Remove to fresh air. Provide oxygen if breathing is difficult. If not breathing, give
artificial respiration. Keep warm and quiet. Seek medical attention.
Page 2 / 7
Product code 91911 Product name Heavy Duty Chain Lubricant
___________________________________________________________________________________________
Environmental precautions
Do not allow material to contaminate ground water system. Local authorities should be advised if significant spillages
cannot be contained. Do not flush into surface water or sanitary sewer system. Should not be released into the
environment.
Handling
Keep container closed when not in use.
Storage
Keep container tightly closed. Keep away from direct sunlight. Keep away from open flames, hot surfaces and sources of
ignition. Store in temperatures below 120 degrees F.
Exposure limits
Chemical Name OSHA PEL (TWA) OSHA PEL (Ceiling) ACGIH OEL (TWA) ACGIH OEL (STEL)
Chlorinated Paraffin - - - -
Petroleum distillates, - - - -
hydrotreated heavy
naphthenic
Stoddard solvent 2900 mg/m³ - 100 ppm -
500 ppm
L.P.G. (liquified 1000 ppm - 1000 ppm 2500 ppm
petroleum gas) 1800 mg/m³
Hygiene measures
General industrial hygiene practice.
Respiratory protection
When workers are facing concentrations above the exposure limit they must use appropriate certified respirators.
Page 3 / 7
Product code 91911 Product name Heavy Duty Chain Lubricant
___________________________________________________________________________________________
Hand protection
Gloves are recommended to prevent prolonged or repeated contact. Chemical resistant gloves.
Eye protection
ANSI approved safety glasses or splash goggles with face shield are recommended.
Stability
Stable under normal conditions.
Conditions to avoid
Heat, flames and sparks.
Materials to avoid
Strong oxidizing agents. Alkalis. Strong mineral acids.
Polymerization
Will not occur.
Synergistic Products
No information available.
Component Information
Page 4 / 7
Product code 91911 Product name Heavy Duty Chain Lubricant
___________________________________________________________________________________________
Petroleum distillates, - - -
hydrotreated heavy
naphthenic
64742-52-5
Stoddard solvent - - -
8052-41-3
L.P.G. (liquified petroleum - - -
gas)
68476-85-7
Carcinogenic effects
No information available.
Chemical Name ACGIH OEL - IARC NTP - Known NTP - Suspected OSHA RTK
Carcinogens Carcinogens Human Carcinogens
Carcinogens
Chlorinated Paraffin - - - - -
Petroleum distillates, - - - - -
hydrotreated heavy
naphthenic
Stoddard solvent - - - - -
L.P.G. (liquified petroleum - - - - -
gas)
Ecotoxicity effects
No information available
Page 5 / 7
Product code 91911 Product name Heavy Duty Chain Lubricant
___________________________________________________________________________________________
DOT
Consumer commodity ,ORM-D,
TDG
AEROSOLS, Class 2.1,UN1950,PG
IMDG/IMO
Aerosols,UN1950,PG
IATA
Aerosols, flammable,UN1950
Hazard Class 2.1
MEX
UN1950 Aerosols,2.2,
State Regulations
International Inventories
CPRC This product has been classified in accordance with the hazard criteria of the
Controlled Product Regulations and the MSDS contains all of the information
required by the Controlled Product Regulations
Page 6 / 7
Product code 91911 Product name Heavy Duty Chain Lubricant
___________________________________________________________________________________________
NFPA HMIS
Health 2 Health -
Flammability 4 Flammability -
Reactivity 0 Physical Hazard -
Protection -
The information accumulated herein is believed to be accurate, but is not warranted to be, whether originating with the
company or not. Recipients are advised to confirm in advance of need that the information is current, applicable, and
suitable to their circumstances.
Page 7 / 7