Sie sind auf Seite 1von 24

Nortel Multiservice Switch 7400/9400/15000/20000

New in this Release


Release: PCR 9.1
Document Revision: 03.02
www.nortel.com
NN10600-000
.
Nortel Multiservice Switch 7400/9400/15000/20000
Release: PCR 9.1
Publication: NN10600-000
Document status: Standard
Document release date: 7 November 2008
Copyright 2008 Nortel Networks
All Rights Reserved.
Printed in Canada and the United States of America
While the information in this document is believed to be accurate and reliable, except as otherwise expressly
agreed to in writing NORTEL PROVIDES THIS DOCUMENT "AS IS" WITHOUT WARRANTY OR CONDITION OF
ANY KIND, EITHER EXPRESS OR IMPLIED. The information and/or products described in this document are
subject to change without notice.
Nortel, the Nortel logo, and the Globemark are trademarks of Nortel Networks.
All other trademarks are the property of their respective owners.
.
3
.
Contents
New features 5
9480 Control Processor with Fabric (CD6394) 5
NTP changes 7
New NTPs 7
Retired NTPs 7
Renamed and renumbered documents 7
Restructured documents 8
Documentation media available 9
Internet 9
Documentation CD-ROM 9
New features and enhancements 11
New features in PCR 9.1 11
Platform 13
MSS 9400 Platform (CD6394) 13
2pGE for MSS 7400 and 9400 (CD7074) 13
ATM/Ethernet 13
Egress p-bit IP Marking (CD6014) 13
Ethernet SNMP MIB Support (CD6994) 14
Wireless Backhaul Clock Synch (CD7034) 14
MaxVCC Increase for MS3 1pOC48 FP (CD7156) 14
ATM Call Redirection for EVLS (CD7157) 14
CES 15
DS0 Channelization on 4pOC3/STM-1ch CES FP (CD7754) 15
DS0 Channelization on 2pSTM-1 (CD7755) 15
IP 15
IP Multicast Support on 4p/8pEth100BaseT (CD4034) 15
IP Flow Classification for PQC (CD4134) 15
VIPR XC SNMP MIB Support (CD5634) 15
IP Flow Filtering for PQC (CD6354) 15
RFC 2547/MPLS 16
RFC2547 Route Reflector (CD6454) 16
ATM Pseudowire with Cell Concatenation on GE (CD7075) 16
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
4
TDM Pseudowire over IP Tunnel on GE (CD7077) 16
ATM Pseudowire over IP Tunnel Enhancements (CD7535) 17
Dynamic CAS lspDB Display (CD7814) 17
System 17
MSS File Checksum (CD2867) 17
Provisioning File Protection (CD7158) 18
Standby CP PLL Integrity (CD7494) 18
Enhancements in PCR 9.1 18
Q01464460 FE Hardware limitation when exceeding 2000 VLANs 19
Q01533652 Power on reset alarm 19
Q01614432 MCDN Connectionless timers 19
Q01620787 Proxy ARP support for Bridge Termination 19
Q01651822 Active CP does not raise PLL alarms 19
Q01651999 MLFR group needs an operational link speed 19
Q01651709 LAG group needs an operational lagGroupSpeed 20
Q01652010 Availability does not show degrade when a link in LAG group is
locked 20
Q01679204 Oamenet minor alarm to be raised to major when a standbyline
is out of service 20
Q01717336 Add MAC mod sh hardware failure precheck during upgrade and
CPSO scenarios 20
Q01717337 MAC address card/terminator card 21
Q01736275 VNET CAS (Channel Associated Signalling) enhancement 21
Q01736317 NIS does not support the user-to-user IE in the SETUP or
DISCONNECT messages 21
Q01736728 PppIwf needs a provisionable attribute to respond in the IPCP
negotiation of IP-Address option 21
Q01806186 Hitless BTDS with NSAP for CP Equipment Protection 21
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
5
.
New features
This section describes the new features for PCR 9.1 Nortel Multiservice
Switch 7400/9400/15000/20000.
Attention: Some new features may be documented but are not yet
supported. For feature support details, see the Nortel Multiservice Switch
Release Notes.
To find out the feature impacts on and other changes to the documentation
suite, see "NTP changes" (page 7).
Navigation
"9480 Control Processor with Fabric (CD6394)" (page 5)
9480 Control Processor with Fabric (CD6394)
This feature introduces a new Multiservice Switch shelf based on
Multiservice Switch (MSS) 7400 and a new control processor with fabric
(CPF). The MSS 9480 shelf is based on the MSS 7480 platform but offers
greater backplane capacity. Function processors (FPs) that are supported
on MSS 7400 are also compatible with this new shelf.
For more information, see the following:
Nortel Multiservice Switch 7400/9400 Hardware Fundamentals
Nortel Multiservice Switch 7400/9400 Hardware Installation,
Maintenance, and Upgrade
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
6 New features
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
7
.
NTP changes
This section identifies changes to the Nortel Multiservice Switch
documentation suite for PCR 9.1. For additional feature information and
last-minute post-publication changes, see the Nortel Multiservice Switch
Release Notes.
Navigation
"New NTPs" (page 7)
"Retired NTPs" (page 7)
"Renamed and renumbered documents" (page 7)
"Restructured documents" (page 8)
New NTPs
There were no new documents for this release.
Retired NTPs
The following documents are Job Aids and are no longer included in the
PCR 9.1 release:
Nortel Multiservice Switch 7400/9400/15000/20000 CommandsJob
Aid NN10600-053
Nortel Multiservice Switch 7400/9400/15000/20000 FundamentalsFra
me Relay UNI Job Aid NN10600-905
Nortel Multiservice Switch 7400/9400/15000/20000 FundamentalsFra
me Relay NNI Job Aid NN10600-906
Renamed and renumbered documents
With the introduction of the Multiservice Switch 9480 control processor with
fabric feature, all documents pertaining to MSS 7400 have been renamed
to include 9400 in their titles. All documents pertaining to Multiservice
Switch 7400/15000/2000 have been renamed to Nortel Multiservice Switch
7400/9400/15000/20000.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
8 NTP changes
Restructured documents
There were no documents that underwent major restructuring for this
release.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
9
.
Documentation media available
This section describes the current delivery methods for Multiservice Switch
documentation.
Navigation
"Internet" (page 9)
"Documentation CD-ROM" (page 9)
Internet
Over the Internet, you can use Nortels support website at
www.nortel.com/support to view, do a suite-wide search, or download
documents in PDF format.
To register for access to Multiservice Switch documents, contact your
Nortel account representative or go to www.nortel.com/register.
Documentation CD-ROM
The CD-ROM contains the current release of Multiservice Switch
documentation in PDF format. Installation instructions are provided on the
CD-ROM. Your Nortel account representative needs to place an order for
you to receive the CD-ROMs. Depending on which Performance Pack
support package you have, you receive either one copy or up to five
copies of the documentation CD-ROMs.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
10 Documentation media available
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
11
.
New features and enhancements
This chapter provides information about new hardware, new software and
enhancements that are supported in PCR 9.1.
Attention: There is new hardware introduced in the PCR 9.1 release.
PCR 9.1 introduces new software that supports the hardware identified
in Table 6. Please refer to the associated software feature in Table 7
which indicates the status of this feature at CA.This includes Beta and GA
hardware. Availability of hardware is controlled by the availability in the
order book.
Feature PEC Platform supported Feature number
MSS 9400 Platform see attention below 9400 CD6394
2pGE for MSS 7400
and 9400
NTNS70AG 7400, 9400 CD7074
Attention: Please see your price book and ordering catalogue for
configuration specification.
New features in PCR 9.1
The table below lists all features supported in PCR 9.1 for Nortel
Multiservice Switch 7400, 9400, 15000, and 20000.
Table 1
New Hardware supported by PCR 9.1
# Feature 7400 9400 15000 20000
Platform
1 MSS 9400 Platform (CD6394) NA CA NA NA
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
12 New features and enhancements
Table 1
New Hardware supported by PCR 9.1 (contd.)
2 2pGE for MSS 7400 and 9400
(CD7074)
CA CA NA NA
ATM/Ethernet
3 Egress p-bit IP Marking (CD6014) CA CA CA CA
4 Ethernet SNMP MIB Support (CD6994) CA CA CA CA
5 Wireless Backhaul Clock Synch
(CD7034)
CA CA CA CA
6 MaxVCC Increase for MS3 1pOC48 FP
(CD7156)
NA NA CA CA
7 ATM Call Redirection for EVLS
(CD7157)
CA CA CA CA
CES
8 DS0 Channelization on 4pOC3/STM-1ch
CES FP (CD7754)
NA NA CA CA
9 DS0 Channelization on 2pSTM-1
(CD7755)
Beta Beta NA NA
IP
10 IP Multicast Support on
4p/8pEth100BaseT (CD4034)
CA CA NA NA
11 IP Flow Classification for PQC
(CD4134)
CA CA CA CA
12 VIPR XC SNMP MIB Support (CD5634) CA CA CA CA
13 IP Flow Filtering for PQC (CD6354) CA CA CA CA
RFC 2547/MPLS
14 RFC2547 Route Reflector (CD6454) CA CA CA CA
15 ATM Pseudowire with Cell
Concatenation on GE (CD7075)
CA CA CA CA
16 TDM Pseudowire over IP Tunnel on GE
(CD7077)
CA CA CA CA
17 ATM Pseudowire over IP Tunnel
Enhancements (CD7535)
CA CA CA CA
18 Dynamic CAS lspDB Display (CD7814) CA CA CA CA
System
19 MSS File Checksum (CD2867) CA CA CA CA
20 Provisioning File Protection (CD7158) CA CA CA CA
21 Standby CP PLL Integrity (CD7494) CA CA CA CA
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
ATM/Ethernet 13
Platform
MSS 9400 Platform (CD6394)
This feature introduces an evolution to the successful Multiservice Switch
7400 platform. Based on the Multiservice Switch 7480, it provides a
system with 14 FP slots and 2 CP/Fabric (CPF) slots. It also introduces a
new CP/Fabric card based on new processor daughter cards. The CPF
Fabric terminates and switches 800 Mbps of traffic from each slot.
The new architecture will allow the direct re-use of most existing
Multiservice Switch 7400 FPs, features and services. Please reference the
Multiservice Switch 7400 and 9400 NTPs for specific information about
which FPs are supported. This new platform is fully supported by the
standard PCR software stream and is fully integrated in MDM.
2pGE for MSS 7400 and 9400 (CD7074)
This feature introduces a new 2-port Gigabit Ethernet (GE) (NTNS70AG)
with optical interface on Multiservice Switch 7400 and 9400 platforms.
In general, the FP supports the same services as the 4pGE on the
Multiservice Switch 15000. The following are key capabilities:
2 full-duplex ports
Small form-factor pluggable (SFP) optics [SX, LX, and ZX]
IEEE 802.3 compliant
IEEE VLAN support (802.1Q)
LAG (802.3ad)
Port and VLAN statistic monitoring
ATM Pseudowire capabilities
ATM/Ethernet
Egress p-bit IP Marking (CD6014)
The Ethernet p-bits egress marking feature builds on and enhances
the traffic management capability of the Ethernet RFC2547 and VIPR
networking solutions. The use of the p-bits will enable the support of
multiple service classes into a single MSS Ethernet link. The Ethernet
User Priority bits field (commonly referred to as p-bits) in the header of
IEEE 802.1Q tagged frames may be marked by the MSS network based
on layer 3 QoS indicators (packets IP DiffServ value or MPLS EXP bits
value) to communicate the frame class of service and/or drop precedence
to the optical Ethernet network. This feature is available on both the MSS
7400 4pEth100BaseT and 8pEth100BaseT FPs, on the MSS 9400 2pGe
FP, and on the MSS 15000 and 20000 4pGe FP
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
14 New features and enhancements
Ethernet SNMP MIB Support (CD6994)
This feature introduces Enterprise MIB support for the following MIBs and
component classes.
Nortel-MsCarrier-MscPassport-LanDrivers MIB
LanApplication
LanApplication Framer
Nortel-MsCarrier-MscPassport-LanDrivers-LanBase MIB
LanApplication EthernetStatistics
LanApplication Vlan
LanApplication Vlan EthernetStatistics
LanApplication EthernetPolicy
LanApplication EthernetUserPriorityMarking1
Wireless Backhaul Clock Synch (CD7034)
This feature provides a timing service for Multiservice Switch wireless
backhaul synchronization. The feature enhances the ATM and/or TDM
Pseudowire (PW) solutions by distributing the clocking information from
the RNC-site Multiservice Switch Gateway to the remote cell-site devices
over the IP/Ethernet access network.
The Multiservice Switch Core Pseudowire node obtains its Master clock
from the Network Clock Synchronization (NCS) system. This clock is
then distributed to the remote cell-site gateways using a special Timing
Pseudowire over the IP/Ethernet network. The cell-site gateways recovers
the master clock and uses it as the Transmit clock on the outgoing E1/T1
interfaces to the 2G and 3G wireless stations.
This feature requires hardware capabilities introduced on the 4pGE FP
version NTPN49AG.
MaxVCC Increase for MS3 1pOC48 FP (CD7156)
This feature increases the maximum supported connection number from
16000 to 45000 in the 1-port OC-48/STM-16 mode of the NTHW46 FP.
ATM Call Redirection for EVLS (CD7157)
This feature addresses the issue of resiliency of the destination CPE
devices by provisioning two destination addresses for an EVC SPVC:
a primary address and a secondary (backup) address, for connections
originating as part of the EVLS application. The connection is first routed
to the destination using the primary destination address, and if it is
unsuccessful, the secondary address is used.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
IP 15
This feature is supported for SPVCs under a LAN/VLAN EVC and ETS
EAtmTrsp generated SPVCs.
CES
DS0 Channelization on 4pOC3/STM-1ch CES FP (CD7754)
This feature introduces basic structured CES services to the 4 port OC- 3
Channelized CES/ATM/IMA FP (NTPN27).
DS0 Channelization on 2pSTM-1 (CD7755)
This feature introduces basic structured CES services to the 2 port STM-1
Optical Channelized CES/ATM/IMA FP (NTNQ96).
IP
IP Multicast Support on 4p/8pEth100BaseT (CD4034)
This feature enables the existing VIPR IP Multicast solution on
the Multiservice Switch 7400 and the Multiservice Switch 9400
4pEth100BaseT (NTNQ95xx) and 8pEth100BaseT (NTNQ92xx) Ethernet
FPs. This matches the capability already provided by other FPs.
IP Multicast support for 4p/8pEth100BaseT FPs is only implemented at
port level LAN mode. No VLAN support is provided.
As well, this feature also provides IP Multicast on VpnXc card for
Multiservice Switch 15000 and Multiservice Switch 20000.
IP Flow Classication for PQC (CD4134)
This feature enables Service Providers to classify IP traffic arriving on
supported VIPR VR, RFC 2547 VRF, or RFC 2764 CVR PQC FP IP
interfaces using multi-field classification.
User-configured rules can be defined to mark the incoming packets DSCP
based on a combination of Layer 3 and 4 protocol header fields, such as
TCP and UDP port numbers. The action resulting from classification is the
possible modification of the packets PHB and DSCP.
VIPR XC SNMP MIB Support (CD5634)
This feature enables VIPR specific standard MIBs access when VIPR
solution is residing on XC. The set of standard MIBs supported is
equivalent to those supported for the customer VRs in the VR component
data model.
IP Flow Filtering for PQC (CD6354)
The IP Flow Filtering feature enables the Service Provider to restrict
admission of IP packets arriving on VIPR, RFC2547, and RFC2764
solutions on PQC2 and PQC12 FPs on the Multiservice Switch 7400,
9400, 15000, and 20000 platforms.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
16 New features and enhancements
Filter profiles are used to define a collection of user configurable rules
that specify match criteria on combinations of the following fields: DSCP,
IP protocol (e.g. TCP, ICMP), IP source and destination, and TCP/UDP
port source and destination. Wildcarding and ranges are supported for
Layer 3 and 4 packet fields. Each rule has a permit or deny action, and a
user-configurable priority number. Any number of interfaces can share one
filter profile configured on the same VR or VRF.
RFC 2547/MPLS
RFC2547 Route Reector (CD6454)
This feature introduces Route Reflectors in a BGP/MPLS VPN network
(RFS 2547 IP VPN solution) eliminating the need for the Service Provider
to maintain a fully meshed network, hence improving the scalability of the
network. MPLS VPN route reflector deployments can be done in one of
two ways. In both cases an eXtender Card (XC) is required.
Dedicated Multiservice 7400/9400:
In this deployment, the 7400/9400 is running the MPLS VPN route reflector
functions exclusively. Networking interfaces can be FE or supported ATM
MPLS PQC FPs.
Multiservice Switch 15000, or 20000, P node with MPLS VPN route
reflector:
In this deployment, a Multiservice Switch 15000, or 20000 P node can run
the MPLS VPN route reflector functionally. PE node functionality is not
supported with MPLS VPN route reflector functionality.
ATM Pseudowire with Cell Concatenation on GE (CD7075)
This feature delivers the cell concatenation functionality as an
enhancement to the ATM Pseudowire solution delivered in PCR 8.2
(CD6814). Cell concatenation allows for multiple ATM cells to be placed
inside one pseudowire packet leading to increased Ethernet link efficiency.
TDM Pseudowire over IP Tunnel on GE (CD7077)
This feature enables the wireless network operators to replace existing
expensive TDM facilities with less costly IP/Ethernet transport. This feature
builds on the Multiservice Switch Circuit Emulation Service (CES) over
ATM and ATM Pseudowire over IP Tunnel on 2pGE and 4pGE features
enabling the consolidation of 2G and 3G traffic over the same packet
network infrastructure.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
System 17
The feature supports transport of ingress TDM bits (including framing bits
if any) from each T1/E1 over a single PW connection. It also supports
transport of bits from N of DS0 timeslots in a T1/E1 frame over a single
PW connection.
ATM Pseudowire over IP Tunnel Enhancements (CD7535)
This phase of the solution implements a number of significant
enhancements to the ATM Pseudowire solution delivered in PCR 8.2.
(CD6814) The enhancements increase network efficiency, solution
reliability, and network scalability.
The major enhancements are:
Carrier Grade (hot CP switchover)
QoS (user-configurable DSCP marking)
Networking Enhancements (dynamic IP Routing, multiple RTRs)
Platform (XC) support
Scalability
OAM Enhancements (FP fault propagation & BFD enhancements)
Statistics enhancements
Sequence number optionality
Dynamic CAS lspDB Display (CD7814)
This feature enables the Multiservice Switch network operators to
display, monitor, and examine MPLS Transport LSPs within MPLS
network and/or RFC2547 network. It meets the increasing demands
of needing to know real time dynamic MPLS and/or RFC2547 network
transportation information for network operations and maintenance,
network troubleshooting, network performance assessments and
evaluations.
System
MSS File Checksum (CD2867)
This feature implements a CRC (Cyclic Redundancy Check) mechanism
to detect corrupted files that were transferred to the Multiservice Switch.
The feature applies to:
Application files transferred to the Multiservice Switch using the CAS
interface.
Provisioning files which were backed up off-switch and then transferred
back to the Multiservice Switch via FTP.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
18 New features and enhancements
Provisioning File Protection (CD7158)
This feature expands the MSS File Checksum feature (CD2867) to cover
provisioning files of type asciiFlat. This feature also introduces an admin
level provisionable attribute under the prov component which, when set,
only allows provisioning view operations to proceed when the associated
provisioning files have been saved with a checksum.
Standby CP PLL Integrity (CD7494)
The Standby CP PLL Integrity feature enhances the visibility of the standby
CPs clock integrity. With this feature, if there is no proper clock source
on the standby CP, the active CP cannot perform a CP switchover. As
well, the feature introduces an automatic mechanism to switchover to the
standby CP if the network clock sync is lost on the active CP.
Enhancements in PCR 9.1
The table below lists all enhancements supported in PCR 9.1 for Nortel
Multiservice Switch 7400, 9400, 15000, and 20000.
Table 2
Enhancements in PCR 9.1
CR # Enhancement
Q01464460 FE Hardware limitation when exceeding 2000 VLANs
Q01533652 Power on reset alarm
Q01614432 MCDN Connectionless timers
Q01620787 proxy ARP support for AtmMpe Bridge Termination protocol ports
Q01651822 Active CP does not raise PLL alarms
Q01651999 MLFR group needs an operational link speed
Q01651709 LAG group needs an operational lagGroupSpeed
Q01652010 Availability does not show degrade when a link in LAG group is locked
Q01679204 Oamenet minor alarm to be raised to major when a standby line is out of
service
Q01717336 Add MAC mod sh hardware failure precheck during upgrade and CPSO
scenarios
Q01717337 MAC address card/terminator card
Q01736275 VNET CAS (Channel Associated Signalling) enhancement
Q01736317 NIS does not support the user-to-user IE in the SETUP or DISCONNECT
messages
Q01736728 PppIwf responds with a configure ack when IP address option is sent with 0
Q01806186 Hitless BTDS with NSAP for CP Equipment Protection
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
Enhancements in PCR 9.1 19
Q01464460 FE Hardware limitation when exceeding 2000 VLANs
A new Engineering Alarm is introduced by this enhancement. Multiservice
Switch 4pEth100BaseT and 8pEth100BaseT Functional Processors have a
hardware limitation. The recommended number of VLANs per card is no
more than 2000. On these Functional Processors the new Engineering
Alarm is raised when there are insufficient resources.
Multiservice Switch 4pGe Functional Processors have a similar hardware
limitation. The recommended number of VLANs per card is no more than
4000. On these Functional Processors the new Engineering Alarm is
raised when there are insufficient resources.
The unexpected Ethernet services media comes up as "Locked/
Disabled/Idle" and can not recover automatically. For recovering from the
resource exhaustion, please refer the NTPs.
Q01533652 Power on reset alarm
Description: This enhancement appends text to the existing card enable
alarm 70120100, for ppc cards only, when the last card reset was a
power-on reset. When the last card reset was not a power-on reset, the
alarm appears unchanged. The alarm on i960 cards is unchanged - the
information about the type of reset is not available on i960 cards, so this
enhancement is not supported on i960.
Q01614432 MCDN Connectionless timers
Description: The MCDN connectionless timers values are changed to be
global variables instead of constants.
Q01620787 Proxy ARP support for Bridge Termination
Description: This enhancement modifies the existing proxy ARP
implementation so that Bridge Termination is also supported.
Q01651822 Active CP does not raise PLL alarms
Description: This enhancement updates the message alarm text for better
fault isolation and faster service recovery.
Q01651999 MLFR group needs an operational link speed
Description: For consistency with IMA and MLPPP, this enhancement
introduces an additional operational speed attribute to show the
aggregated speed for the number of links in the MLFR group. This
attribute will enable a customer to quickly determine if they have an issue
on one of their links without having to drill down to the lk/* component.
This applies to both 7400, 9400 and 15000 that supports MLFR
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
20 New features and enhancements
Q01651709 LAG group needs an operational lagGroupSpeed
Description: For consistency with IMA and MLPPP, this enhancement
introduces an additional operational speed attribute to show the
aggregated speed for the number of links in the LAG group. This attribute
will enable a customer to quickly determine if they have an issue on one of
their links without having to drill down to the lk/* component. This applies
to both 7400, 9400 and 15000 that supports LAG.
Q01652010 Availability does not show degrade when a link in LAG
group is locked
Description: When a link under LAG group is locked or disabled, the
availabilityStatus attribute of LAG group does not show degraded. For
consistency with IMA and MLPPP, this functionality will enable a customer
to quickly determine if one of the links under LAG group is having an issue
(i.e. locked or physically down) without having to drill down to the lk/*
component. This applies to both 7400, 9400 and 15000 that supports LAG.
Q01679204 Oamenet minor alarm to be raised to major when a
standbyline is out of service
Description: This enhancement raises a Oamenet minor alarm to a major
when a standby line is out of service.
Q01717336 Add MAC mod sh hardware failure precheck during
upgrade and CPSO scenarios
Description:This enhancement prevents a CP switchover (either
controlled, or during a migration) when there is a MAC address module
hardware fault present in the system.
This enhancement prevents a CP switchover (either controlled, or during a
migration) when there is a MAC address module hardware fault present in
the system.
If a MAC address module hardware fault is present when any of the
following commands are issued, the command will fail with the proper error
response:
switch lp/0
reset/restart lp/0
reset/restart sh ca/<active CP card num>
If a MAC address module hardware fault is present when any of the
following operations occur, activation will fail with the proper error
response:
Hitless Software Migration, (only on MSS 15000/20000)
Hitless Software Removal on CP (only on MSS 15000/20000)
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
Enhancements in PCR 9.1 21
Hitless Software Patching on CP (only on MSS 15000/20000)
Classic migration
Warm software migration (only on MSS 7000)
Q01717337 MAC address card/terminator card
Description: This enhancement reduces the interval for checking the
MAC address card/terminator card from every 2 hours to every 30 minutes.
Q01736275 VNET CAS (Channel Associated Signalling) enhancement
Description: This enhancement adds a new value to the callRouting
attribute under vroute idm. This value is used only in the case of CAS
signalling. When the CAS PBX seizes a channel, if digits are provisioned
under the idm component, the Multiservice Switch will insert the digits and
then route the call.
Q01736317 NIS does not support the user-to-user IE in the SETUP or
DISCONNECT messages
Description:The enhancement provides the following support:
codeset 0 user-to-user IE in the Setup and Disconnect messages;
the forwarding of UUI in the first call clearing message(Disconnect),
while the call is still in the call proceeding state, prior to the active state;
the minimum length for UUI IE - 35 bytes;
the maximum length for UUI IE - 131 bytes.
Q01736728 PppIwf needs a provisionable attribute to respond in the
IPCP negotiation of IP-Address option
Description: This enhancement creates an IP address provisionable
attribute under the PppIwf NCP component, which will store the remote
IP address and be used to respond to the IP Address option of the IPCP
configure request message.
Q01806186 Hitless BTDS with NSAP for CP Equipment Protection
Description: This enhancement supports BTDS with NSAP for a hot CP
switchover.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
22 New features and enhancements
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
NN10600-000 03.02 Standard
7 November 2008
Copyright 2008 Nortel Networks
.
Nortel Multiservice Switch 7400/9400/15000/20000
New in this Release
Copyright 2008 Nortel Networks
All Rights Reserved.
Printed in Canada and the United States of America
Release: PCR 9.1
Publication: NN10600-000
Document status: Standard
Document revision: 03.02
Document release date: 7 November 2008
To provide feedback or to report a problem in this document, go to www.nortel.com/documentfeedback.
www.nortel.com
While the information in this document is believed to be accurate and reliable, except as otherwise expressly agreed to in writing
NORTEL PROVIDES THIS DOCUMENT "AS IS" WITHOUT WARRANTY OR CONDITION OF ANY KIND, EITHER EXPRESS
OR IMPLIED. The information and/or products described in this document are subject to change without notice.
Nortel, the Nortel logo, and the Globemark are trademarks of Nortel Networks.
All other trademarks are the property of their respective owners.
.

Das könnte Ihnen auch gefallen