provided with progressive ferrule compression couplings on either side SN 469
Dimensions in mm
Straight-way type valves according to this standards sheet can be used for such fluids as: cold water and hot water * up to 80 C, max. PN 10 bar. compressed air, mineral oils and fuel oils of quality classes EL and L up to 80 C, max. PN 6 bar.
* pay attention to the kind of water and to possible additions
Shape DV Straight-way type valve
Designation of a straight-way type valve, shape DV, for pipe outer diameter of 18 mm provided with progressive ferrule P of light-duty series L:
Straight-way type valve SN 469 - DV18 - PL
Designation Pipe D Thread of union nut M H h L l s1 s2 s3 Weight kg/piece DV 6 - PL 6 M 12 x 1,5 117 88 14 0,33 DV 10 - PL 10 M 16 x 1,5 65 7 119 90 22 19 21 0,35 DV 18 - PL 18 50 M 26 x 1,5 126 94 27 32 25 0,60 DV 22 - PL 22 M 30 x 2 67 8 140 108 32 36 32 0,85 DV 28 - PL 28 60 M 36 x 2 95 158 125 41 41 38 1,23 DV 35 - PL 35 70 M 45 x 2 102 10 188 145 50 50 47 1,95
Material: Housing, valve disk and male stud made of brass. Progressive ferrules and union nuts made of steel. Shut-off seal made of NBR (e.g. Perbunan).
Normung The reproduction, distribution and utilization of this document as well as the disclosure of its content to others without prior explicit written consent of SMS Demag AG is prohibited. Holder has to protect this document against unauthorized withdrawal of third parties. Offenders will be held liable for the payment of damages. All rights reserved in case of patent/utility model/trademark protection. 18.08.01 D l i f t h l L s2 s1 s3 p i p e M H
N o
g u a r a n t e e
c a n
b e
g i v e n
i n
r e s p e c t
o f
t h i s
t r a n s l a t i o n
I n
a l l
c a s e s
t h e
l a t e s t
G e r m a n - l a n g u a g e
v e r s i o n
o f
t h i s
s t a n d a r d
s h a l l
b e
t a k e n
a s
a u t h o r i t a t i v e
T h i s
c o p y
w i l l
n o t
b e
u p d a t e d
i n
c a s e
o f
c h a n g e s !
Page 2 SN 469 : 2006-12
Exclusion from use in SAP This standard is not applicable when drawing and parts lists are prepared in SAP. The above-mentioned parts are stored in SAP as catalogue master data and are additionally made available in PartSolutions.
Revision of December 2006 Previous editions Addition of Exclusion from use in SAP 1997-05