Sie sind auf Seite 1von 4

International Journal of Advanced Research in Engineering and Technology (IJARET), ISSN 0976

6480(Print), ISSN 0976 6499(Online) Volume 5, Issue 6, June (2014), pp. 121-124 IAEME
121











EARTHQUAKE RESISTANT HIGH RISE BUILDINGS NEW CONCEPT


Dharane Sidramappa Shivashaankar

Assistant Professor in Civil Engineering Department SVERIs College of Engineering Pandharpaur,
Maharashtra India

Patil Raobahdur Yashwant

Assistant Engineer Grade I, Public Works Projects (pvt) Subdivision Pune,
Maharashtra, India



ABSTRACT

The very important factor in design of earthquake resistant high rise building is that the dead
load should be less, the structure should be monolithic and as for as possible the center of gravity
should be shifted as lower level. Also The important aspect of this research paper is that if the
ferrocemnet cavity walls filled with water will absorb the energy developed in earthquakes as the
motion of water waves are opposite to motion of structure when it vibrates in horizontal direction or
oscillates because of its inertia force. Because of this reason the ferrocement cavity walls plays very
important role in small structures as well as in high rise buildings, which makes the building safer,
fire resistant, economical along with sound and thermal insulation property.
The new concept in the design and construction of high rise building is that to shift the center
of gravity of the whole structure should be shifted to its lower level by providing the water tanks on
each floor instead of providing at top of the building. Also if these water tanks are constructed by
ferrocement cavity walls as per the requirement will fulfill both the conditions required for making
the high rise buildings to make safer in earthquakes. e.g. it will shift the center of gravity at its lower
level as well as the water stored in the cavity walls will absorbs the earthquake forces as the water
waves oscillates in opposite direction of the force developed by the earthquake when the structure
vibrates in horizontal direction or oscillates.
Ferrocement is a versatile material and can be used on self-help basis. The ferrocement walls
are economical as well as it gives better earthquake performance. In addition to this the earthquake
performance, sound and thermal insulation property can be improved by constructing the
ferrocement cavity walls. If these ferrocement cavity walls filled with water improves the further
earthquake performance. Also ferrocement cavity walls are economical and can be constructed on
self-help basis. This paper also presents the construction procedure of ferrocement cavity wall.
INTERNATIONAL JOURNAL OF ADVANCED RESEARCH
IN ENGINEERING AND TECHNOLOGY (IJARET)


ISSN 0976 - 6480 (Print)
ISSN 0976 - 6499 (Online)
Volume 5, Issue 6, June (2014), pp. 121-124
IAEME: http://www.iaeme.com/IJARET.asp
Journal Impact Factor (2014): 7.8273 (Calculated by GISI)
www.jifactor.com

IJARET
I A E M E
International Journal of Advanced Research in Engineering and Technology (IJARET), ISSN 0976
6480(Print), ISSN 0976 6499(Online) Volume 5, Issue 6, June (2014), pp. 121-124 IAEME
122

Keywords: Ferrocement, Cavity Wall, Earthquake Performance, Sound and Thermal Insulation.

INTRODUCTION

In civil engineering structures the various types of bricks and blocks are in use for the
construction of partition walls in framed structures. Day by day the cost of earth bricks and concrete
blocks are increasing as well as they do not give the better property like sound and thermal insulation
property. Also the earthquake performances of these types of walls are poor. To overcome these
limitations the ferrocement cavity walls can be used.
The very important factor in design of earthquake resistant structures is that the dead load
should be less, the structure should be monolithic and as for as possible the center of gravity should
be shifted as lower level.
The important aspect of this research paper is that if the ferrocemnet cavity walls filled with
water willabsorb the energy developed in earthquakes as the motion of water waves are opposite to
motion of structure when it vibrates in horizontal direction or oscillates because of its inertia force.
Because of this reason the ferrocement cavity walls plays very important role in small structures as
well as in high rise buildings, which makes the building safer, fire resistant, economical along with
sound and thermal insulation property.
The water tanks designed and constructed at each floor shifts the center of gravity at lower
level as wall water tanks designed in cavity wall improve the better earthquake performance of high
rise buildings as the motion of water waves in the water tanks are opposite to the motion of structure
due to earthquake forces.

DEFINITION

American concrete institute committee defines ferrocement as a type of thin wall reinforced
concrete Construction where in usually hydraulic cement is reinforced with layers of continuous and
relatively small diameter mesh.

TECHNOLOGY

Ferrocement construction requires less skilled personnel and can be constructed on self-help
basis. Hence it hasgained popularity throughout the world. The wire meshes are usually 0.5 mm t0
1mm in diameter and spaced at 5mm to25mm apart and volume of mesh ranges 1% to 8% of the
total volume of the structural element. The thickness offerrocement section varies from 10mm to 40
mm. The cover to the outermost layer of wires is usually 1.5 mm to 2 mm.The cement mortar
consists of ordinary Portland cement, water and fine aggregate, generally below 5mm to 7 mm in
size isoften around 2mm in order to permit a more closely spaced mesh. The mesh may be made of
metallic material or other suitable material.

APPLICATIONS

The confidence in the behavior of the material has increased with wide range of applications.
Though the materialproperties are not fully investigated, its applications are increasing to a great
extent. Many marine structures were constructed with ferrocement and it is finding place in
terrestrial structures also in recent years. Ferrocement initially gained popularity with the
construction of small boats. Almost during the same period corrugated sheets made of ferrocement
were used as roof element in place of conventional asbestos sheet in Sri-Lanka which are 25%
economical thatthe conventional one. Also it facilitates repair of damaged zones simply by
International Journal of Advanced Research in Engineering and Technology (IJARET), ISSN 0976
6480(Print), ISSN 0976 6499(Online) Volume 5, Issue 6, June (2014), pp. 121-124 IAEME
123

plastering. It is also used for complex curveunits, curved panels, shells or domes, septic tanks, tanks
for storage of water, oil or grains, fishing boats, small vessels, roof or wall panels for low cost
housing, bio-gas holders ,sewers and pipes etc.

CAVITY WALL

Ferrocement cavity wall consists of two wythes of ferrocement walls separated by air space
connected by corrosion resistant metal ties. The thickness of external and internal ferrocement
wythes may be from 12 mm to 25mm separated by air cavity of thickness depending upon the
requirement of sound, thermal insulation. The thickness of cavity also depends on the earthquake
zone when these ferrocement cavity walls will fill with water after construction to absorb the
earthquake forces.

CONSTRUCTION

The cavity wall consist of

1. Vertical and horizontal spacer bars
2. Welded mesh on two sides of the wall
3. Car board to support the external plastering/concreting work
4. Sand which will be filled inside the cavity to increase the internal support for plastering
5. Top and bottom openings which gives the facility to fill the sand and remove the sand after
completion of constriction of cavity wall
6. The same watertight top and bottom openings with end caps can be used to fill the cavity by
water to increase the earthquake performance, sound and heat insulation and fire resistance of
the building.

The construction of cavity wall consists of following steps

1. First oninside and outside planes of cavity wall thevertical and horizontal mild steel spacer bars
are placed at the time of constructing the beams and columns (including plinth beam) so that
the structure will become more monolithic and give the better earthquake performance.
2. The small thick card boards which are generally used for packing purposes can placed on inside
sides of the vertical and horizontal spacer bars and can be tied with the spacer bars. So that the
sand which will be filled to give the support for external plastering will not be drained out.
3. The welded meshes should be well tied with the vertical and horizontal spacer bars on both the
sides.
4. In addition to this the inside card boards can be well tied with the external welded meshes to
get the well support for the concreting action which can be done by gunniting gun or manually.
5. Also to increase the internal support for external concreting/ plastering the cavity should be
completely filled with sand by providing one top and bottom opening which will provide the
facility to fill and remove the filled sand respectively.
6. The openings can be used to fill the water in the cavity of wall to provide the facility of curing
as well as to improve the earthquake performance of the structure after the construction of
cavity wall.
7. The openings can be made simply by using bigger diameter pipes so that sand can be filled
easily from the top openings. And filled sand can be removed after the plastering/concreting the
both sides of the wall. The end cap can be used for the top and bottom openings of the pipe so
that sand or water can be stored and removed as and when required.
International Journal of Advanced Research in Engineering and Technology (IJARET), ISSN 0976
6480(Print), ISSN 0976 6499(Online) Volume 5, Issue 6, June (2014), pp. 121-124 IAEME
124

SALIENT FEATURES AND CONCLUSIONS

1. Ferrocement provides the facility of water tightness.
2. Ferrocement cavity wall can be constructed on self-help basis.
3. Ferrocement cavity wall provides sound and thermal insulation property.
4. Ferrocement cavity wall provides faster construction along with economy.
5. Ferrocement cavity wall reduces the dead load of the structure along with the better earthquake
performance.
6. Ferrocement cavity walls save the life of people during earthquakes.
7. Ferrocement cavity wall filled with water improves the earthquake performance of the building.
8. Ferrocement water tanks designed and constructed in the cavity walls in high rise building
improves the better earthquake performance.

REFERENCES

1. SidramappaDharane & ArchitaMalge, Experimental Performance of Flexural Behavior of
Ferrocement Slab Under Cyclic Loading, International Journal of Civil Engineering and
Technology (IJCIET), ISSN 0976 6308 (Print) ISSN 0976 6316(Online) Volume 5,
Issue 3, March (2014), pp. 77-82.
2. SidramappaDharane & ArchitaMalge, Experimental Performance of Flexural Behavior of
Ferrocement Slab Under Gradual Loading, International Journal of Civil, Structural,
Environmental and Infrastructure Engineering Research and Development (IJCSEIERD)
ISSN(P): 2249-6866; ISSN(E): 2249-7978Vol. 4, Issue 2, Apr 2014, 97-102.
3. SidramappaDharane & ArchitaMalge, Experimental Performance of Flexural Creep Behavior
of Ferrocement Slab, IJRET: International Journal of Research in Engineering and
Technology eISSN: 2319-1163 | pISSN: 2321-7308, Volume: 03 Issue: 04, Apr-2014,
PP 635-639.
4. Dr. T.Ch.Madhavi, Shanmukha Kavya.V, Siddhartha Das, Sri Prashanth.V and Vetrivel.V,
Composite Action of Ferrocement Slabs Under Static and Cyclic Loading, International
Journal of Civil Engineering and Technology (IJCIET), ISSN 0976 6308 (Print),
ISSN 0976 6316(Online), Volume 4, Issue 3, March (2013), pp. 57 - 62.
5. Mohammed Mansour Kadhum, Effect of Dynamic Load: Impact of Missile on Mechanical
Behavior of Ferrocement Infrastructure Application, International Journal of Civil
Engineering and Technology (IJCIET), ISSN 0976 6308(Print), ISSN 0976 6316(Online),
Volume 4, Issue 2, March (2013), pp. 295 - 305.
6. Aaqib Mir, Yasir Sofi, Waleed Qari and Prof Dr. A. R.Dar, Revival of Traditional Earthquake
Resistant Technique in Kashmir Valley, Replacing Timber with Bamboo in Dhajji Dewari
(Bracing System), Comparing Cost and Strength Aspects, International Journal of Civil
Engineering and Technology (IJCIET), ISSN 0976 6308(Print), ISSN 0976 6316(Online),
Volume 4, Issue 6, March (2013), pp. 1 - 11.
7. Misam.A and Mangulkar Madhuri.N., Structural Response of Soft Story-High Rise Buildings
Under Different Shear Wall Location, International Journal of Civil Engineering and
Technology (IJCIET), ISSN 0976 6308(Print), ISSN 0976 6316(Online), Volume 3,
Issue 2, March (2012), pp. 169 - 180.

Das könnte Ihnen auch gefallen