0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
77 Ansichten1 Seite
This document contains 7 fluid mechanics and machinery assignment problems related to topics like flow through pipes and venturimeters, power lost in bearings, and velocity profiles in laminar flow. The problems provide specific values and ask the student to calculate things like piston rpm, flow rates, power lost, diameters, and velocities using equations from fluid mechanics.
This document contains 7 fluid mechanics and machinery assignment problems related to topics like flow through pipes and venturimeters, power lost in bearings, and velocity profiles in laminar flow. The problems provide specific values and ask the student to calculate things like piston rpm, flow rates, power lost, diameters, and velocities using equations from fluid mechanics.
This document contains 7 fluid mechanics and machinery assignment problems related to topics like flow through pipes and venturimeters, power lost in bearings, and velocity profiles in laminar flow. The problems provide specific values and ask the student to calculate things like piston rpm, flow rates, power lost, diameters, and velocities using equations from fluid mechanics.
Approved By AICTE, New Delhi and Affiliated To Anna University DEPARTMENT OF MECHANICAL ENGG. ASSIGNMENT 1
SUBJECT : FLUID MECHANICS AND MACHINERY SUBMISSION DATE: SUB. CODE : CE 6451 YEAR/ SEM : II/III
1. Inside a 60 mm diameter cylinder a piston of 59mm diameter rotates concentrically. Both the cylinder and piston are 80mm long. If the space between cylinder and the piston is filled with oil of viscosity of 0.3N-s/m 2 and a torque of 1.5 N-m is applied. Find the rpm of the piston and power required. 2. A pipe of 300 mm diameter inclined at 30 0 to the horizontal is carrying gasoline (specific gravity = 0.82). A Venturimeter is fitted in the pipe to find out the flow rate whose throat diameter is 150 mm. The throat is 1.2 m from the entrance along its length. The pressure gauges fitted to the Venturimeter read 140 kN/m 2 and 80 kN/m 2 respectively. Find out the coefficient of discharge of Venturimeter if the flow is 0.20 m 3 /s. 3. The dynamic viscosity of an oil, used for lubrication between a shaft and sleeve is 6 poise. The shaft is diameter 0.4 m and rotates at 190 r.p.m. Calculate the power lost in the bearing for a sleeve length of 90 mm. The thickness of the oil film is 1.5 mm 4. The dynamic viscosity of oil, used for lubricating between a shaft and sleeve is 10Poise. The shaft rotates at 200 rpm. The power lost in the bearing for a sleeve length of 100mm is 25 Watts. The thickness of the oil film is 1.5mm. Calculate the diameter of the shaft and the sleeve. 5. A horizontal venturimeter with inlet diameter 20 cm and throat diameter 10 cm is used to measure the flow of water. The pressure at inlet is 17,658 N/cm2 and the vacuum pressure at the throat is 30 cm of mercury. Find the discharge of water through venturimeter. Take Cd = 0.98. 6. Find the discharge of water flowing through a pipe 30cm diameter placed in an inclined position where a venturimeter is inserted, having a throat diameter of 15 cm. The difference of pressure between the main and the throat is measured by a liquid of specific gravity 0.6 in a inverted U tube which gives a reading of 30cm. The loss of head between the main and the throat is 0.2 times the kinetic head of the pipe. 7. A laminar flow taking place in a pipe of diameter 200mm. The maximum velocity is 1.5 m/s. Find the mean velocity and the radius at which this occurs. Also calculate the velocity at 4 cm from the wall of the pipe.