ISA Certified Automation Professional (CAP) Program
These questions are from the %'# study guide, #erformance Domain III, )ystem Design. Definition& Design, specify, and procure the hardware*software used in the system. CAP uestions 1. 'n application includes a varia$le frequency drive 5<:D7 that implements a <*=> method of torque control while maintaining a fi"ed <*=> ratio. The motor has a nameplate rating of ?@4 volts and @4=>. If the drive is operating at 4=>, what percent of rated torque will the motor /0)T likely develop, '. 2/I (. /0I %. 500I D. 200I 2. To minimi>e electrical interference when '% power and D% signal wiring meet in a control panel, it is (-)T to& '. Use a !ifferent si-e wire. (. Cross the wires at =0 !egrees. %. :un the wires parallel to each other. D. +wist the C wires aroun! the DC wires. CAP ans!ers 1. +he correct answer is %' 500I. +he volts per hert- ratio $@8H-& controls the torque of a motor. s long as this ratio is in proportion with the nameplate rating' the motor will !evelop rate! torque. +he only answer that represents rate! torque is 500I rate! torque. :eference3 Pol(a' Motors and Drives Practical !ec"nolog# Guide. IS Press' 2007. 2. (' crossing the wires at =0 !egrees is the correct answer. +his minimi-es the exposure of the wires to each other' an! therefore minimi-es the effects of interface. Using a !ifferent si-e wire will have no effect on the electrical interference. :unning the wires