Beruflich Dokumente
Kultur Dokumente
Ideal
bm rels and fast ignition under ham- f H
, .. : . or unting,
J , Plinking, Target &
Match Shooting .
all at lower cost than .22 L.R.
CHOICE OF 6
NEW BUGGY RIFLE-light and fast. only 51f:, lb Octagonal
cut r ifled 21" barr el. E ither .36 or .45 caliber .
MOST POPULAR "Offhand" model. 32" full octagon cut r ifled
barrel. Either .36 or .45 caliber. About 7'h Ibs.
MODEL . 45 TARGET. 32" cut rifled round barrel. favorite of
match shooters. 10 Ibs., .45 caliber on ly.
12 gao FOWLER. only 4% Ibs . 30" choked barrel.
EACH READY.TOSHOOT
You get-Flask. Powder, Caps, Patching, Lead,
Bull et Mold. Powder Solvent, Measure, In-
struction nook. Saves much time and money
since you with correct bullet mold size,
patching mate rial , powder l oads.
ORDER YOUR H&A TODAY!
Order :my H&A model now direct from this ad
and we'll send you FREE-extl'a valuable muz-
zle loading premiums. Each order, with all the
shooting equipment, sent RR Exp. (not pre-
paid). Include a statement you are over 21.
not a fugitive, drug addict or undel' indict-
ment. Additional interesting information on
Hopkins & Allen rifles. pistols and shotguns
free-just send self-addressed, stamped, long
envel ope.
4l
NOW-Long Range Rear Sight
, '" tor a ll H&A's-adj ustabl e t or both
,
windage &: e levation, complete with 3
size aperture disc. (All H&:A receiv-
ers now drilled & tapped for this
sight)-Only $3,95
.--,-5f'3-
FIRING PINS
'92 Model ____
'73_38 & 44/40
mdis. _______$3.75
'73_25 &: 32/20
mdl s. ______ $3.75
Brand new, either
right or left. State
which. $3.75 SPE-
C I AL! Pair for $6.50.
WINCHESTER EXTRACTORS
for Model '73
New ____________ .$2.50
REMINGTON MODEL 12
Firi ng pins. Our
new improved de-
- -- _ sign _ .. ___ $2. 75 ppd.
REMINGTON MODEL 24
. 22 Automatic Extractors -
Unavai l able tor Years $3. 75
A FINE
Muzzle Loading
PISTOL
Has t he "hang" and feel ot t h e early dueler s .
Ultra strong design allows extra h eavy black
powder l oads. I n eith er . 36 or .45 caliber-with
extras checkered Tenite grips
Only $26.50. (Add $3.00 for checkered Walnut
grips. ) * Send pistol permits from states r e o
quiring. Also include signed statement you are
over 21, not a fugitive , dru g addict, drunk or
u nder indictment. etc.
SNAP UP YOtlR
WITH THE N.A.C.
--'
SPEED LOCK SAFETY PIN
For All Springfield 1903 Type Rifles
One p i ece Safety Firing Pin w i th crisp speed
lock action. Seconds to install- no dr illing, tiling
or p i nning- simply turn i nto bolt bOdy and
you' r e ready to fire. True Mauser tyPe with solid
safety shoulder. ' Lock time r educed by nearl y
500/0 . Speed main spring of special steel . Over
5,000 i n use ______ . __ ______ __ _________ __Only $4. 95
BLOCKS
AT AaOUT 50-,.
SAVING
& other bolt handles
l ow for scope mounting
and smooth spoTter ap-
pearance. One set l asts
for hundreds of jobs. Our
own make & deslgn-equal
to usual 817 to 820 sets
Full guar anteed- with mstructions, ONLY $9. 95
plus 55e pp.
STANDARD DOVETAIL
With elevator. 2 for /'
$1.00; 12 for $s.OO;"'-1....I
sO for $17.50.
10 GAUGE MA ... G ..
SHOTGUNS _
*
Mechanically Perfect
32" Long Range Full Choke Barrel-
H & R Heavy Breech Action--approx. wt. 8 y. Ibs.
NEW Stocks and Forends!
Greates t bang a round Du ck a hd Goose g un ever. Each with
bran d new proof-tested Long Range barrel .. each mechani cally
perfect wit h extra la rge, extra st re ng a ction. All AMERICAN
MADE. Conditi on as specifi ed refers t o outsi de receiver
fi ni sh. Everyt hi ng e lse new. .
(Add $1.75 for ppst. & ha nd li ng 0 1' specify R. R. Exp ress.
Send " Firearms Affidavi t " sta ti ng you a re over 21 , not
under ind ict ment or a f ugitive, not a d rug add ict, e tc.)
NOW I N
.36 Caliber
(1 turn in
40") or .45
caliber (1 tur n
in 56"). 8 groove
rifling. handsome. &
smooth inside and out.
15/16" across flats. 3 2"
long, either e a !. . only $ 1 5. 8 5
pl us 8S post. 42" long, .45 cal.,
only $19. 95 p lus $ 1.50 shipping. 45/
70 caliber-l turn in 22", 8 groove. 32"
long 515. 50 plus . 9 5 .
. Add $2.00 pe r b arrel for threading for our
new breech plug and nippl e adv ertised bel ow.
BREECH PLUGS: Ma-
o' chined from Ordnance
. . .'
!Vsx 18 thread . Oct. mod-
o el 15/16" across, round
model 11/8". Made specially for use with our fine
muzzl e loading barrel but a cceptable t o any. (Add
$2.00 to barrel price for threadi ng at factory for
round or octagonal (state
ROUND MUZZLE LOADING
BARREL BLANKS
MUZZLE LOADING-llJs" straight 8 groove rifled
lengths-l turn in 56"-super accurate 32'
long $10.95 p l us 95. Above barrel. only full 48'"
bench r est model .. . $ 18. 95 plus $1 . 50 (Add
$2. 00 per barrel l or breech plug threading . )
HI POWER BARREL BLANKS
11/s'" o .d
.44 CALIBER round blanks, 27" long x 15/16"
dia. U .44 Special Magnum, 44 / 40. Six
groove fine steel . $9. 50 pl us 80. 12
n
length use-$5.95 plu s 40 post.
. 357 . 38 Special &: 9mm Luger) blanks.
1 turn gI.oove dia . 26" long 940 o.d.
- Many uses including conversion of Winchester
and Marlins in .357 Magnum rifles $9. 50
plus 85 pos t. 1 2" l ength for pistol use-$5."
p lus 40 pos t.
EXTRA HEAVY .22 barrel blanks. FuIl l1/s" d ia,
6 J:"roove banel suitable for center or rim fire
actions, 27" l ong. 1 turn 14" Only $8.95
. plu s 90 pos t.
INSTANT MUZZLE LOADERS
FOR SPRINGFiElD 45/ 70 or SO/ 70 RIFLES
pecusslon barrel drops into stock- ready to shoot.
Free, i nlerch angeable percussion hammel' sent
with each barrel.
Return to ori ginal by simply replacing original
pans.
.45 cal., 8-gr oove, (1 turn in 56"). Blued with
sight dovetails, nipple, etc.
Th i s conver sion barrel is the same match quality
as u sed i n o ur H&A muzzle loaders-taper-turnecl
out o ld barrel and receiver-i nstall our new b arrel
and change h a m mers-gun is ready to s,hoot. Or igi-
nal U. S. Springfield percussion hammer incl uded . _
it replaces your cartridge hammer w ithout fi tting.
P r i ce complete and ready to use-$26. 50 pl us 85e
pp, (Bull et mold-.45 cal. for above-anly $2. 25.
GAINTWIST RIFLING
Now Available on our Barrels
s s: < s
,Ve can now reproduce on a cust om bas is
the GAI N TWIST rifling as used in the super
accurate p e r c u ssion match rifles oC yesteryear .
Gain-Twist r ifling i n any of our m.l. b lanks
o r H&A riOes cost s but $7.50 a dditional .
Our unit reduces l ock time (the great accuracy 1m.
prO\'elO) up to 72 % cocks rifle on the up turn of
the bolt just as in 'Vlnchester, Remington, Spring.
fleld, Mauser and others. Simply insert In your
bolt. Regular safety works as usual. Normall y a
$15 t o $ 18 conversion. OUR UNIT, READY TO
INSTALL IN YOUR BOLT IN 2 MINUTES AT THE.
UNBELIEVABLY LOW PRICE OF $5.95 PPD.
(For 1914 or 19 17 Eddystone. Remington or Wi n ..
Models only - state which- not f or Britlsb
.. " .
our ru ll r<>mmcITi:l 1 IInc o f "';. , f
s:-un!<l . in ... lud lnl.: "ur 1!l:?7 . "
C1l.rhl nc. ctc" . Pro
f usely ao nng-es. " ".
Sl . 95 pod_ ::-
Me ei re tht' 301e .. "Inn/ae_
g UII# Qn" "" _"
tJiWi4
1tl
fl if = I it 9 ?i
aN to use li quid not a "Gooey" paste
NEW HIGH S PEED FORMULA t akes
seconds t o apply beaut ifies
p r ot ect s. Deep blue permanent finish
actu a ll y penet rat es the steel. Us ed
by gu n smiths and gun factories every-
whe r e. Gua r a nteed to be the best
co ld blue you e ver u sed-or your
money back.
3 GUN SIZE-SEND ...... $2.00 ppd.
INDUSTRIAL-GUNSMITH SIZE
PINT-SEND . . .... $7.50 ppd.
SOLD THE WORLD OVER
43
44
HVA Lightweight with fulllength, carbinestyle stock. Thrill
to t he balance, accuracy and power of this Lightweight
Monte Carlo. Truly oldworld craftsmanship at its best. Write
for literature on this and other Husqvarna hipower rifles,
Calibers: .243, .270, .3006, .308, 6.5x55mm, .358mag., 7nim mag,
TRIlDEWINDS,IIIC. P.O. Box 1191, Tacoma " Wash.
LUGERS AND P-38's
Model ' 08, 4" barrel, 9 mm,
fi nely reblued, like new grips,
NRA good throughout.
Selected 'OS's, (finely reblued, like new grips)
NRA very good, bores guaranteed NRA good, most
numbers match, some all match ........ $51.95
Model '08, arsenal refi nished, NRA very good
with brand new barreL ... .... $61.95
WALTHER P-38, 9mm, 5" barrel ,
NRA good throughout.
Select ed model, NRA very good condo throughout,
with mat ched numbers except clip .... $38.95
BRANO NEW WALTHER PRODUCTION P-38's com-
pl ete with extra clip & cleani ng rod ..... $99.50
6-INCH BARRELED, NRA excellent 9mm Luger. Ideal for high velocity, long- range shooting. Each pistol
fitted with brand new 6-inch barrel and refi nished to arsenal standards, $69.95.
Some available with new 8-INCH barrel , refi nished as above, $79.95. Both 6&8-inch barreled lugers
availabl e with grip safety $10 additional.
Model 1900/ 06, 7.65mm, 43f4-inch barrel , grip safety, NRA very good with 80% origi nal blui ng, some
sl ight ly retouched, $69.95.
Model 1900/ 06, Portuguese 7.65mm, ' 43f4-inch barrel, grip saf et y, matched numbers, NRA good to
very good. Each clearly displays Portuguese Royal Coat of Arms on the toggle, $84.95.
DISTRICT MERCHANDISE CO. 1207 King Street, Alexandria, Virginia
illlroR,
U
tb
i
ir
i;lg
See your gun dealer or write for color catalog.
ROYAL ARMS, INC., 10064-G Bert Acosta St., Sa ntee, California 92071
Greater Recoil Control
Wi th COisti tl cti ve g
* TRADITIONAL WALNUT
For comfort and beauty.
* CHECKERED FRONT STRAP
For non-slip holding _
* EXTENDED BUTT
For cor rect hand placement_
* RIGHT OR LEFT HANDED
HerroH".
ledged ..leadership jl)
Stocl Making t . ( h
niq".' no H.,. to
tho ,.,i o.,. , . yoly.r
,hoot., _ Shooting
5'0" . _ .t pric . ..
which Inyito ' ."'por ...
I,on_
For combat shooti ng. AVAI LABLE FOR YOUR GUNS FROM YOUR DEALER.
(Continued from page 42)
decoys are enough! A pit or fancy blind is
rarely required; a crude weed blind, or just
l ying down in a di tch or in corn stalks will
usually suffice. If snow is on the ground, a
whi te sheet over the hunter is usually as good
as a pit.
When Roger and Mark Delaney of Hasty,
Colorado, two of the best goose hunters I
know, told me that the geese were coming
back to a big permanent set north of J ohn
Martin Reservoir after avoiding it completely
for two weeks, I couldn't wait, and Mark and
I were in the pit in the middle of this set
early thc following morning. By 9 o'clock
the geese were headed for the fields, and
we watched long strings, many with hundreds
of honkers in them, passing a few miles east
of us. A half dozen flocks broke off and came
our way. Mark called to them convincingly
and the big birds would hover just out of
gun range, but they wouldn't decoy. Instead
they turned east, let down to almost ground
level, and passed over a high prairie hill.
Mark remarked, "I'm going to dig a pit on
the top of that old bald hill! Just look at
those birds." I laughed. How could anyone
dig a pi t on a bald prairie?
Mark and Roger Delaney really did dig
a pit on the top of that bald prairie hill-
and Roger and I took our limits out of it
the first time we tried! This hill lay between
feeding areas. It was wide open except for
clumps of prairie grass, and the honkers
flying over it had never been shot at along
this route_ We found that a few decoys on
the open prairie would help pull even the
curious wide flyers within range.
Often, late season honkers will fly low over
open, uncultivated land. Watch for such low
flyways! It's usually much easier to get
permission to hunt these areas than to hunt
cultivated fields! When you find such a "hot-
spot," even a pit is not usually necessary.
Just lie down and be still until the low
flying honkers are within range-then sit
up and shoot!
Of course, late season honker hunting is
never a cinch, even for the expert who knows
all the tricks discussed-but I'm convinced
that knowing these tricks will help anyone
to kill more late season honkers around any
sanctuary in the country. .
After all this sage advice, I must admit
that I killed my two honkers on the last day
of the season last year by sheer accident and
with the aid of a cooperative cow! I was
making my way through a big maize field in
a blinding snowstorm, with my gunny sack
of half-shells over my shoulder. Visibility
was not more than 50 yards. Suddenly, I
thought I saw some pheasants running through
the maize stalks, then realized they were
geese trying to take off! I dropped my
decoys, threw the safety off my gun, and
nailed a big gander just as he left the
ground. I put out my decoys and the snow
grew lighter. Then I saw an old white faced
Hereford chasing a goose on the other side
of the field! The goose would fly about 50
yards and try to feed again, but the per-
sistent cow would keep flushing the honker!
On the fourth try, the Hereford flushed the
big honker right over my decoys and I
downed him with a load of # 2's At that
point, I couldn't have been surprised if that
hunting Hereford had tried to
retrieve my goose- but she didn't !
GUNS AUGUST 1964
RUGER'S RIM-FIRE RIFLE
(Continued from page 21)
this at the NRA show by taking the maga-
zine, dropping it on the floor, and then
jumping up and down on it_ The retaining
lips and ramps which guide the cartridge into
the chamber are made of solid alloy steel,
hence wear and tear would either be minimal
or completely absent. The test gun-a pre-
production model-had to be returned to
Ruger, and consequently it was impossible to
give the magazine extensive function tests;
all in all, we fired 225 rounds, and found no
evidence of wear and would not anticipate
any unless the total n umber of rounds fired
were on the order of 10,000 or more_
There was considerable fouling accumula-
tion since the gun was fired with a number of
brands of ammunition, but even fouling did
not appear to effect the functioning of the
gun. Disassembly of the magazine, though not
difficult, is a bit on the touchy side. Proper
re-assembly depends largely on the hexag-
onal nut and its detent for the magazine
rotating spring which must be aligned to
give the spring the tension required for rota-
tion of the cartridge carrier.
Removal of the magazine from the carbine
is from below, is accomplished easily with
thumb and forefinger. The trigger housing
contains the entire ignition mechanism, and
the 10/22 also has the now-standard bolt
hold-open latch feature. The cross-bolt safety
worked perfectly and it was not possible to
jar it into firing position. The trigger pull of
the test gun was somewhat on the hard side,
let-off was not as smooth as it could be.
Similarly, there were several instances where
the bolt hung-up on the magazine r im, and
this was readily discernible since the maga-
zine l ip did show some slight wear. Ed Nolan,
when he shipped the test gun to 10hn Amber
of the "Gun Digest," warned us that this
might occur since the gun had been assem-
bled hurriedly to make it possible for us to
meet editorial deadlines. Production guns
have not only improved triggers, but also
bolts that won't hang up.
Function tests were performed with factory
sights, using Monark, WoW Super X, Win-
chester Leader, and eel Target ammunition.
The gun is designed for the Long Rifle car-
tridge and handles standard and hi-vel ammo
without adjustments_ At first we used only
one brand of ammo, then mixed brands,
finally mixed not only brands but also ve-
locity-the Ruger 10/ 22 performed like a
well-trained circus pony! Slow and rapid
firing tests, again at first with one brand of
ammo, then mixing brands, and then mixing
brands and velocity, produced no malfunction,
though there was considerabl e fouling on the
forward part of the magazine_
Accuracy tests, fired at 100 yards and
with open factory sights, produced groups
that went slightly over four inches, but this
might well have been my fault since 100 yard
shooting with iron sights is not my spe-
cialty_ With a scope, and using eel Target
ammo, repeated groups measured 2-2 JA! " ,
with a SE wind blowing across the range at
a measured 3-5 miles per hour. 10hn and I
consider this as very good for a 10 shot
group at 100 yards.
This means that Bill Ruger's latest, the
10/22, gets the green l ight on all counts:
flawless function, good looks, good accuracy,
and price-which is set at $54.50. Still other
developments arc in the works in the South-
port plant and I'll report on them
when test guns become available.
THE BSA RALOCK
(Continued from page 33)
and chambers a fresh cartridge.
The magazine, located in the buttstock,
holds twelve Shorts or eight Long Rifle car-
tridges, depending on the model.
The .22 Long Rifle model is 43.13 inches
over-all, the _22 Short model is four inches
shorter. The pistol grip stock and a semi-
beaver-tail forearm makes it a real man-size
gun. The sight radius is 18 inches.
The sliding safety is l ocated on the top
rear of the receiver_ When set on safe, the
word "SAFE" appears correctly. When the
gun is ready to fire, the letters "AF" on the
thumbpiece are moved forward, out of line
with the "S-E" on the receiver, and a red
dot appears.
Takedown on the Ralock is very simple,
and takes less than five seconds. The barrel
retainer is l ifted, t he barrel is pulled straight
GUNS AUGUST 1964
forward out of the receiver. This also releases
the body of the action, which may be re-
moved from the bottom of the receiver_
Either model of the Ralock sold for the
U. S. equivalent of about $35.28. The cost
of manufacture proved to be considerably
higher than anticipated, and the volume of
sales was ' inadequate to warrant continued
production_
Another tbar prompted i ts demise
involved a difficulty in maintaining a reasona-
bl.e trigger pressure. Probably the main
factor for its discontinuence was the fact
that it was impossible to see if the rifle was
loaded, unless either the barrel or the action
mechanism were removed. Thus, one of the
most promising rifle designs of the post war
era blossomed and withered in the .--t
br ief span of four years.
YOUR
CLUB
can now have its own
custom-designed
EMBROIDERED
EMBLEM
. . . direct from America's
most respected manufact urer
SWiSS-TEX@
Your c l ub insignia or club
colors can now be hand-
somely designed into a
smart ly styled embroidered
emblem at substant i al sav-
ings by ordering direct from
the manuf acturer!
Hund r eds of other Clubs
order t hese emblems for re-
sale to members, to be worn
on jacket s, caps, sweaters,
et c., and add the earnings t o
their club t reas uries.
The Leonard Corporation and
its SWISS-TEX cust om design
division have been supplying
quali ty emblems for more
than 50 yea r s to leading
organizations including the
Boy and Girl Scouts, Military
branches, Federal, Stat e and
Municipal governments ...
and just r ece nt ly was se-
lect ed t o pr ovi de t he em-
blems for the 1964 White
House Shooting Match.
For full details on how your club
can now have its own emblem,
p l us a free sports emblem, write
today on your club st ationery.
division
The Leonard Corp.
323 E. Allegheny Ave., Phi/a. 3<1, Pa.
45
5000
FIREARMS
BARGAINS
Are you a gun trader? Gun collector? Or are
you just plain interested in guns? If you are,
you'll profit from reading the bargain-filled
columns of SHOTGUN NEWS, now pub-
lished twice each month. It's the leading
publication for the sale, purchase and trade
of firearms and qccessories of all types.
SHOTGUN NEWS has aided thousands of
gun enthusi.asls locate firearms, both mod-
ern and antique - rifles, shotguns, pistols,
revolvers, scopes, mounts all at money-
saving prices. The money you save on the
purchase of anyone of the more than 5,000
lislings twice a month more than pays your
subscription cost. You can't afford to be
without this unique publication.
Free trial offerl
Money Back Guarantee.
As a special introductory offer, we'll send
you the next issue of SHOTGUN NEWS free
of charge with your one year subscription.
That means you get 25 big issues. What's
more, if you're not completely satisfied, just
tell us. We'll immediately refund your
money in full and you can keep the issues
you already have_ Fair enough? You betl
Fill in the coupon below and mail it todayl
THE SHOTGUN NEWS
Columbus, Nebraska
G8
Yes, send me the next issue of SHOTCU N
NEWS fREE and start my subscription for one
year. $3 enclosed-to be refunded if I' m not
completely satisfied.
Nom ........ _ .. _
Addre ........... _._. ___________ .
City & 5tot ........ _ .... ___ .. _ .. ______ . __
l _________________________ _
EARLY GUN TRADE OF THE WEST
(Continued from page 23)
Schoyen. Possibly Lower and Schoyen learned
too quickly under Gove's tutelage for both
soon branched out in competitive gun busi-
nesses of their own. Gove took his sons and
son-in law, Frank Church, into the business
about 1875, a year before Colorado ceased
to be a territory and became a full-fledged
state of the Union.
The advent of the metallic cartridge
brought with it radical changes in the gun
trade. Most of the gunmakers became gun
merchants and their business gradually
changed from manufacturing to merchandis
ing and altering or repairing the products
of the eastern gun manufacturers. Carlos
Gove and some of the others were not al-
ways satisfied with the products of the
eastern manufacturers-they often rebarreled
them or altered them to suit their own ideas.
One of Gove's better known alterations was
a method of repl acing the thumb "rolling
block" operation on a Remington single shot
rifle with an under lever.
As great as Gove's prominence was, John
P. Lower's gun store in Denver was destined
to become the best known establishment
beyond the Missouri. Here you might meet
Lower's personal friends Bill Cody, George
A. Custer, Jim Bridger, or even the Grand
Duke Alexis of Russia. Or you might have
found a store full of Indians including
chiefs Ouray, Coloraw, and Persoon of
the Utes.
Lower learned the gun trade in Philadel-
phia, working for the well-known establish-
ment of Joseph C. Grubb & Co. at the age
of 18. He was with the firm as gunsmith
and salesman for 21 years, but the West
lured him across the plains in 1866. After
his brief association in business with Gove,
he struck out for himself. In addition to
his name jn big letters across the entire
front of his BlaJ-e Street store, an awning
bore the lettering !'Sharps' Rifles and Colt's
, pistols." Certainly these were two of the
most popular lines of Lower's stock in those
early days. A vast quantity of correspondence
between the Sharps Company and Lower has
been preserved; these letters reveal the pur-
chase and delivery of hundreds of the various
Sharps rifle models. Lower had known Col.
Colt personally and sold great numbers of
Colt pistols.
John Lower devoted 65 years to the gun
business. A great credit to the gun trade,
Lower had known the business as gunmakllr,
target shooter, salesman, and merchant. Most
important of all, he had been a man with
many friends.
Men who know fine target rifles will tell
you that George C. Schoyen was one of the
best craftsmen who ever placed a gun in a
customer's hand. Schoyen was a native of
Norway who carne to America soon after the
Civil War. He lived in Chicago for a time,
but migrated west in the early 1870's, find-
ing employment with Gove in Denver. Schoo
yen stayed longer with Gove than Lower,
but in the 1880's, he too struck out for him
self. Schoyen seemed to prefer partnerships,
devoting himself to producing fine guns and
letting his partners take care of the business
details. His first partner was D. W. Butt,
and in 1887 F. A. Burgen. Some years later
the famous Schoyen & Peterson partnership
was formed.
Axel Peterson, like Schoyen, was a Scan-
dinavian. Arriving in Denver in 1879, Peter-
son's reputation as a skilled gunmaker soon
became known throughout the western terri-
tory. Schoyen and Peterson did not gain
fame only for their accurately barreled target
rifles; they were skilled in all forms of gun
making. Fancy pistols, an unusual over/under
gun, and deluxe hunting rifles also carne
from their workbenches. Axel Peterson de-
signed a telescope sight which was one of
the first to offer internal adjustments.
There were other skilled men in the gun
trade in Denver and throughout Colorado,
but the "big four"-Gove, Lower, Schoyen,
and Peterson-are the names most frequently
remembered.
In 1868 the arrival of the railroad as far
west as Cheyenne, Wyoming Territory, 103
miles north of Denver, marked the arrival
also of one of the West's best remembered
gunmakers, Frank W. Freund. In this new
bustling town at the railhead, Frank and
his brother George put up a sign over their
little shack to indicate that this was the
"Wyoming Armory," operated by "Freund
Bros." From this small beginning, and later
in new, enlarged quarters the business grew
until the lettering on the Freund shop
boasted that they carried a stock of from
GUNS AUGUST 1964
500 to 1000 breech-loading guns and from
500,000 to 1,000,000 rounds of ammunition_
For a time they operated a cartridge-making
plant in Casper, Wyoming_
The Freunds were natives of Heidelberg,
Germany_ Arriving in America, Frank went
to work at Ilion, New York, for K Reming-
ton & Sons for a short time before the War
Between the States. He served eighteen
months in the Union Army, and after the
war, the West beckoned. With his brother
George, Frank set out for Nebraska City
where they operated a gunsmithing business
from 1866 to 1868. When the tracks were
laid as far west as Cheyenne, the Freunds
closed their Nebraska City shop and moved
to Cheyenne, where a Freund gun store
served the trade for the next 17 years_
On May 10, 1869, the first transcontinental
railway was completed when crews working
eastward from California met those working
westward from Cheyenne at Promontory
Point_ The Freunds were now "on the main
line" and their location became an important
outfitting point for gold seekers, teamsters
and emigrants; later buffalo hunters flocked
in to decimate the great northern herd.
Of the two brothers, Frank was apparently
the more ingenious. Twenty patents bear
his name; George's name appears on but
four. These patents covered many things
from primers, cartridges, and sights to pistol
and rifle designs. The best known of Frank
Freund's innovations were his improvements
on the Sharps breech-loading cartridge
rifles. Many famons people were among the
Freunds' customers, including General Phil
Sheridan, General George Crook, and Theo-
dore Roosevelt. Another important customer
was General George W. Wingate who, on
April 25, 1893, fired the first shots on the
famous Creedmoor target range where, under
the auspices of the National Rifle Associa-
tion of America, international rifle matches
were born.
Sharps and Remington rifles were the
favorites in those early Creedmoor matches,
so Freund's improvements on the Sharps
rifles gained not only western popularity but
also wide national recognition.
The partnership of Frank and George was
dissolved about 1881. George moved to
Durango, Colorado, where he established the
"Colorado Armory," a shop where guns and
accessories were sold, traded, and repaired.
A few years later, Frank returned East,
settling in Jersey City.
To the south of Colorado lay the Terri-
tory of New Mexico. Vast deserts and moun-
tains were encompassed in our acquisition
of this land in 1848 through the Treaty of
Guadalupe-Hidalgo which ended the Mexican
War. At first what are now the states of New
Mexico and Arizona was all New Mexico
territory, Arizona not becoming a separate
territory until 1863. Indians and Mexicans
were the principal occupants of tlus little-
known land. Yet it had been visited by the
white man before the Pilgrims landed at
Plymouth Rock. Santa Fe was the center
of trade, but the trade goods did not include
any great amount of firearms_ Early white
settlers depended principally on the military
for their arms. The Mexicans were usually
too poor to buy good guns, and every effort
was made to keep firearms from the Indians.
This was a poor market for the gun trade,
although a few gunsmiths and traders did
GUNS AUGUST 1964
All
NEW
CONTINUOUSLY VARIABLE POWER,
3x TO 6x, FOR .22 RIFLES
$14" 95 complete with N
or Tip-Off Mount
For all kinds of hunting and shooting, at
long or short ranges, with .22's and
other light recoil rifles . . only the V22
gives you ALL these features in a .22
variable power scope:
ffi red diameter scope tube, providing
'\J7 larger lenses for better illumi nation.
Sharp, clear image at any magnification.
Quick, easy power change-just 'h turn
of the eyepiece covers the entire power
range, 3x to 6x.
6 feet of adjustmen ts for windage and e/e
vation at 100 yards. Adjustments are in
ternal and guaranteed accurate.
an split-ring Tip-Off Mount installs in
seconds, without tools, on factory-grooved
rifle receivers. Type N Mounts also available.
ffi Centered, constant -size reticle fOT fast.
'\J7 accurate aiming (see illustration below).
ffi
always
centered
.. like this
~
~ never
. off-center
like this
Any change in magnification does not change size of
the crosshair.
For versatile .22 shooting, see the Weaver V22
-at your dealer. @J964 W, R. Weaver Company
----------------------__ Be
W,. ~ WEAVER CO. DEPT, 43 / EL PASO, TEXAS 79915
FREE!
lull-color
1964
catalog
Name' ______________________________ __
Address ______________ _
City ______ --"State' ____ LZip ___ __
MADE SETTER BY AMERICAN CRAFTSMEN
47
Deer at 500 yards!
with a HORNADY 6mm/87
.... was amazed at the damage your 1/ 5 oz. pill
did to t his distant muley . . . best long range
deer bullets I've ever used," writes Joe
Adams of Dubuque, la. He took this spent
bullet from a deer dropped in one long shot
with his 243. The 6 mm 87 gr. Hornady Spire
floint was pushed by 47 grs. 4831 and hit at
well over 500 yards. On near or distant shots,
you can depend on the deadly expansion of
Hornady Bullets.
68 bullets for handloading
- send for brochure
o:r:n..ad.y
B'ULLETS
HORNADY MFG. (0. DEPT. G GRAND ISLAND, NEBR.
It's EASY! With
Gunberth* Plans ,.. Kifs
All details on Plans, Kits and
Hardware are listed ' io big,
fully illustrated. "
"Handbook" -Catalog,
which a lso contains tips on
design and construction.
Send NOWI Only $1 .00 ppd.
(Refunded first $10.00 order>
COLA DONATO BROS.
Dept. G-84 Hazelton, Po.
serve those in the territory who coul d not
obtain their arms or have their repair work
done at the army posts. Our National Ar
chives contain recor ds of the issuance of
arms from Federal stores to emigrants and
early settlers.
A different sit uation existed in Utah Terri
tory where many members of the Mormon
Battal ion (which had built a wagon road
through New Mexico and Arizona under Col .
P. St. George Cooke in 1846) now resided
in Salt Lake City or in the outlying towns.
Gunmaker Jonathan Browning settled in
Ogden in 185l.
Browning was not satisfied to produce only
the standard caplock guns of his time, but
experimented with multishot systems. One
was a gun with a multichambered block
which could be moved sidewise at the
breech, thus making it possible to discharge
five fast shots. Another mul tishot gun at
tributed to him was a more conventional
revolving cylinder weapon somewhat like the
Miller, Billinghurst, and Bigelow pilllock
r epeating rifles. A Dragoon type revolver
resembling the Colt is also claimed as a
Browning product.
Jonathan Browning's sons John Moses and
Matthew Sandefur wer e born in Ogden. As
they grew into manhood, Matt showed an
aptitude for business while J ohn took to
gunmaking like a duck to water. It may
seem odd that J onathan Browning's search
for better multishot weapons did not im-
mediately influence his son John. We must
r emember, of course, that by the time J ohn
was old enough to design a gun, metallic
cartridges had replaced the old loose powder,
CARVES: Gun stock designs magazines; receivers; barrel
throats; gun sights; muz-
zles; safet ies; lockwork;
floorplates; res izi ng dies;
rough tool marks; rusted
parts.
and fittings; pistol grips;
inletted fl int locks; stacks
around pistol gri p caps;
spindles; powder horns;
slots for stock accessories;
replacement parts for an
tique firearms.
GRINDS: Trigger sears; alu-
mi num fitti ngs; case-hard-
ened gun lock parts; brass
pistol fittings; sight blades;
rifle bolts and cams; re-
ceiver wells and throats;
magazines; feeding ramps;
c hamber mouths; scope
blocks; bolt faces for belted
cases; barrel bands; extrac
tors for Magnum cartridges;
bolt handles; screw heads,
ri vet pins, broken taps;
cutting tool edges.
ENGRAVES: Name plates;
gun barrel designs; si lver
inlays; t rigger parts; ham
mer cutofts; pistol clips;
powder horns; antique gun
scrollwork; inletted a reas;
trophies.
CUTS: Small wood and met-
al inlays; spring stock;
small clearances; accessory
trigger slots ; r eceiver
notches for altered bol t
handles; cartridge case sec-
tions; new screwhead slots.
POLISHES: Trigger guards
and sears; bolt faces and
cams; shotgun ribs; rifle ac-
tions; revolver cylinder
chambers; primer pockets;
POWER
TOOL
YOU'LL
Model No. 2 MotoTool Kit with steel
storage case and 23 most popular
accessories for performing operat ions
listed here. MotoTool weighs 13 'bz. ,
produces 27,000 RPM. Speeds up
t ime consuming hand work - gi ves
fini shed job a professional look. A
"must" for gunsmiths and the ever
t inkering gun bug.
No. 2 MotoTool Kit,
as illustrated . . ... . ... . .. $29.95
No. 2 MotoTool only . . . . . . .. 19.95
Heavy Dut y No.3 MotoTool.
with steel case, less
accessories . . . . 29.95
SEE YOUR DEALER OR WRITE FOR CATALOG
SHAPES: Gun stocks; small
metal parts; fore ends; in-
lays; pistol grips; embossed
lock parts; replacement
parts for antique arms.
ROUTS: Slots for stock ac-
cessories; grooves for side
locks; bolt handle recesses;
fore ends; barrel channels;
stock inlays; new trigger
clearances; undercuts for
glass bedding in stock.
DRILLS: Vent holes in re-
loading dies; spring holes
in cylinder hands; screw
holes in stocks and grips;
tap and rivet holes; ob-
structed hole clearance.
DEBURS: Welds; burrs on
trigger sears and hammers;
roughedged hand 1i led
parts; drilled holes; rough
bolts and slipes; firing pins;
ejector and extractor slots;
new replacement parts.
SANDS: Gun stocks and
grips; inside small open-
ings; flutes on revolving
cylinders; barrel channels;
lifters; slots and recesses
for close-fitting stock parts.
SUGGESTED USES FROM
MOTO TOOL OWNERS 3691
DREMEL MFG. CO . DEPT .... RACINE, WIS.
48
ball, and caps of his father's earlier days.
J ohn's fi rst gun design was a single shot
breechloader with a dropping breech block,
something like the Sharps but more stream-
lined. I have in my collection one of J ohn
Brownings earliest models of this rifl e. The
gun is dated 1878, a year before t he issuance
of Browning's first patent of October 7, 1879.
The barrel is marked ".44-77" and "J. M.
Browning, Ogden, U. T.," t he side plates
bear the marki ng "J. M. Browning, U. T. ,
1878." Shown with this gun, for comparison,
is the standard single shot rifle of a later
design patented by the Brownings. Of these,
600 were made by hand. A distinct differ
ence between the Model 1878 and Model
1879 Browning is the action of the lever.
The lever on the 1878 model is pulled down
and back toward the shooter, while the 1879
model employs the rather standardized sys-
tem of being worked down and forward.
With this single shot rifle and a small
stock of other merchandise, the Browning
gun shop was launched under the name
J. M. Browning & Bro. Lettering across the
front of their little brick shop told the
world they sold "Guns, Pistols, Ammunition,
& Fishing Tackle." J . M. Browning and his
brother were then in their twenties.
The Browning fame spread far beyond the
small gun shop in Ogden. J ohn Browning's
contributions to the design of l ever action
rifles, shotguns, and automatic weapons are
well known. If the Browning local gun trade
was somewhat insignificant, in the overall
picture of far westcrn production or mer-
chandising, more guns of Browning design
probably were shipped into the West for
other dealer s to sell than those of any gun
designer; thi s would be particularly true of ,
the Winch esters which owed their design to
Browning, from the single shot "high wall"
through the '86, '92, '94, and '95 lever
action models.
Those early years in the gun trade from
1850 to 1900 were fillcd with the fast moving
tempo of exciting news, new developments,
dramatic changes, tragic wars, but from out
of all this came the building of a strong and
unified nation. No longer were our coasts
separated by untrod areas without means of
transport or communication. In all t his great
movement, few services were more important
than those services which supplied the arms
and ammunition to secure needed food,
bring an end to Indian warfare, protect new
homes, and estab-
lish law and order.
Makers of
Famed Californian
Announce t he New ..
" CLASSIC" - " THE ROLLOVER"
"2 i n 1" - 114 in 1." Prices
begin at $24.50. Complete information in
Color Brochure.
PETERSON GUN STOCKS P . o . Box 7'5, Sun Valley, Call! . 91353
GUNS AUGUST 1964
HANDLOADING BENCH
(Continued from page 10)
the .45 for both center fire and .45 matches.
Mr. Woodford chronographed his loads at
754 to 769 fps, a variation of only 11 fps.
In another test they varied only 10 fps. A
30 fps variation is called "Match Grade" .45
ammo.
CCI is credited with eliminating hang fires
(that can't be detected) and misfires, notori-
ous in 1955 Target S & W guns. A prominent
match shooter wrote, "All pistol primers are
too hard." He changed his mind after it
was proved that CCI's had proper sensitivity
in our own drop test. Sensitivity is uniform.
Early lots perform today exactly like current
prod uction.
The Texas Dept. of Public Safety recently
called in all .357 Magnum factory ammo,
due to misfires and primers flowing in the
firing pin holes of S & W guns to lock the
cylinder. Cylinders had to be hammered
open, or turned with two hands to shear off
primer extrusion. I described this in the
Jnly 1962 GUNS, and the current edition of
"The Book of Pistols and Revolvers," and
notified the factory. On March 28, 1963 the
factory admitted the complaint was justified.
To quote: "Investigation shows set back of
primers occurs in guns with tight headspace.
Considerable work with modified primers has
been done and the problem is under active
study. A solution is expected."
No doubt they will solve the problem
soon. The mills of the ammo makers grind
STAINLESS STEEL BARRELS
NOW AVAILABLE THROUGH .30 CALIBER
ULTRARIFLED
MUZZLE LOADER BARRELS
We are now able to make very good deliveries on muzzle
loading barrel blanks. These blanks are made in 32, 36,
40. 45 and 50 caliber. They are all CUT RIFLED with a
twist of one turn in 66" and grooves .010" to .01217 deep.
Lands and grooves are of approximately equal width.
The material used is specially processed for our purpose,
cold drawn to octagon shape with an especially fine finish
that will require little or no polishing. These are avail-
able in 1%6", 1 ~ . 1%8", 1" and 1%" at $27.50 each. We
also supply 1%" barrels at $32.50 each. These blanks are
threaded for breech plugs and the DOUGLAS name and
caliber is branded on the top flat. Finished length is 42".
You may order these barrels with a twist of one turn
in 48" 57", or 75" at an additional charge of $5.00 each.
These prices are subject to our regular gunsmith's dis-
count. Write for complete information or order from
this ad.
GUNS AUGUST 1964
STOP FLINCHING-IMPROVE SCORING!
slowly, but they grind exceedingly fine.
We'll report on the solution promptly in this
magazine. We have nine S & W .357 Mag-
num revolvers that all gave trouble with some
lots of various brands of factory ammuni-
tions. All functioned perfectly with CCI
primers in reloads. I believe S & W reo
volvers would be more dependable with a
firing pin built in the frame, similar to
Ruger S.A. and Colt D.A. revolvers. We
never had a misfire or primer set back that
locked the cylinder of Colt D.A. or Ruger
Blackhawk revolvers, with any factory ammu
nition.
A major cause of poor handgun loads
with good bullets is an under charge of slow
powder, or primers that give under-ignition.
A soft primer locks a S & W cylinder, so it
won't function until the extrusion is sheared
off. Hard primers give misfires, especially if
a S & W mainspring is weak, the strain
screw short, or if it has loosened a bit.
Acclaimed by champion shooters and recommended by
Ear Specialists as the best protection against harmful
noise. lee Sonic EAR-VAlVS let you hear everything
normally while they eliminate the harmful effects of
gun blast noise. A precision engineered, patented
mechanical hearing protector. NOT EAR PLUGS. Only
$3.95 apr. w;th money back guaranlee. ORDER TODAY
or write for FREE Medical Proof and literature.
SIGMA ENGINEERING COMPANY
1608 Hillhurst Ave., Dept. K, Los Angeles 27, Calif_
liMO DEL of 1960
11
A major advantage in handloads is they
can be tailored for your particular gun.
Gene Austin, a top bench rester, has an
Apex tube in a Fajen stock. In his .243 Rock
Chuck using 6mm Rem. brass, a 75 gr.
Sierra H.P. backed with 47.0 gr. 4350 and
CCl 250 Magnum primers gave 100 yard
groups of about 2.0". Upping the charge to
47.5 gr. screwed groups down to about 0.5"!
I've long preached that a bit less or more
powder will tighten groups, sometimes a lot.
Prices start at
$56.50
for a-inch barrel.
Immediate delivery .
. 400 mold-$3.95
TINGLE MFG. CO., INC.
1125 Smithland Rd., Dept. G.
Shelbyville, Indiana
For the BEST
in production made
RIFLE BARRELS
. . .
Highest Quality
Low Cost
Best Discount to Gun-
smith
with these features
Most Calibers 22 to 458
Chrome-Moly Steel
Button Rifled since
1953
Finest Inside Finish
Record Holding Barrels
Straightest Sporters
The Douglas ULTRARIFLED* "button rifled" barrel is the finest produc-
tion made barrel obtainable today. Day after day these barrels insure
the attainment of highest accuracy for its owner, are the least trouble and
the most profitable for the dealer-gunsmith. You can depend on Douglas
barrels. W'I'ite for free descriptive data.
PATENTED 'r. M. REG. MADE EXCLUSIVELY BY G. R. DOUGLAS.
.. From the rifle barrel capitol of the world"
G. R. DOUGLAS CO., INC.
5504 BIG TYLER ROAD CHARLESTON 2, W. VA .
49
STOP STRUCiCiLINCi
WITH YOUR
OBSOLETE LOADER
Save Postage--don't even send the complete press.
it 's obsolete anyway-just break a piece off the
frame, tie a ma iling tag on it, a nd send to us for
a full $8.00 credit on the Fabulous New 5-Star
AUTO-LOADER.
BEST OF All-We will send you FREE, a new 5-Star
shell holder for each caliber shell hold er you send
with your " Piece of Press". An Allad in
Presses for Old? Sure, we want our great 5STAR
PRESS on your loading bench-Your Friends will see
it-AND to see it once is to buy it.
CHECK
THESE 5
FEATURES
ALL AMERICAN MADE
EACH PRESS GUARANTEED
Send order
with 'junk
part' and
remittance
direct to
c>
OPEN
WORK SPACE
Wide open work
area makes loading
wit)1 either hand fast &
si mple. Takes all slalldard
Ys" x 14 dies.
REALLY AUTO
PRIMER FEED
Never handle a primer again
-primers come from box through
machine, into primer pocket with
out handling. Saves time, tempers
and lost primers-keeps primers cleat'
-prevents misfires & velocity changes.
COMPOUNDED POWER
Exclusive linkage design makes this press
SIIper pot/'er/tll. Swages bull ets. full
length sizes cases-even the tough
magnums-easily. smoot hly. effortlessly.
OVERTHROW FEATURE
Exclusive overthrow feature withdraws
20 YEARS!
case from die on power stroke-automati cally
resizes L'ach case tu';ce-climinatcs brass
spring back. gives a perfect
case each time.
ALL TOOL STEEL
Made of tool steel. with hardened
No castings to spring. crack and break
-so slroug we guarantee each press.
for 20 fllll years.
Add 95< pos'. alld
bu. east of ,\fiss.,
51.95 ",esl
50
Probably 9 out of 10 handloaders don't get
maximum accuracy from their rifles, due to
lack of testing. A gun you think is mediocre
may have superb accuracy with the right
powder charge or bullet weight.
Charles Quinn, my Houston, Texas friend,
has bagged 36 head of big game with 37
shots from his .300 Apex with 6X Lyman
scope, up to 450 yards. A deer hit high in
the shoulder got a finishing shot. He uses
Speer's 165 gr. backed with 70.0 gr. 4350
and CCI 250 Magnum primers, at 3216 fps.
Charles and I agreed long ago these rifles
were ideal for most game. They are, but the
.300 Winchester practically killed them. This
bullet is fine in a .30-06 to the hottest .30's.
It has advantages over 150 or 180 gr. bullets
for most game, with long sustained velocity,
plenty of punch and fine accuracy.
My favorite .357 load for game up to deer
is a Speer 146 gr. H.P. with 16.5 gr. 2400
and CCI 550 Maguum primers. Speer lists
16.0 gr. maximum. In my 6" Colt Python
velocity is 1376 fps, a bit faster than in a
larger bore, slower twist 6" S & W. Varia-
tion is only 43 fps. Shack and I bagged 35
assorted varmints one afternoon with my
Python, taking turns shooting. All were clean
kills. This was a day we were both "hot,"
when we hit nearly everything we shot at.
\Ve have our "off" days too, like most hand-
gunners.
C-H Cup Nose dies swage potent looking
bullets that look reversed in loads. Locally,
it's called the "Ascender," a nickname for
an airplane with wings at the rear. Our tests
prove the CH Semi-Wadcutter H.P. expands
faster and is more potent, with better Hi-V
accuracy. It can be driven faster due to less
bearing surface.
Hollow Points that are too large and deep
look potent. Our tests prove the nose will
collapse to one side, for much l ess expansion,
unless they hit exactly nose first, which is
seldom. They nearly always tip a bit, or
strike at an angle. Best expansion is ob-
tained with Vs" drilled cavities about 14"
deep. Accuracy equals a solid nose, and
they are far more apt to give a classic mush-
room for greatly increased shock, and terrific
tissue destruction.
Bullets in any caliber have nearly no
"knockdown." An Army General said f01'
adequate "knockdown" the diameter should
be 3" or more! A fast expanding .22 is
more effective than a non-expanding .45 It's
even more effective in a nonvital spot. Bul-
lets kill by shock and tissue destruction
more than by caliber. If heavy, Lo-V bullets
are used for deep penetration on very large
game, they kill only by penetrating a vital
spot. For faster, cleaner kills on thin skinned
game use a fast expanding bullet, or one
that explodes on varmints.
Shooter's Supply, 202 S. 124th, Seattle 68,
Washington, sell assorted "Stick On Aper-
tures" for shooting or eye glasses at $1 plus
a stamped, self addressed envelope. They in-
crease the depth of field so iron sights and
targets are both sharp. Stopping down a
camera lens (using a smaller aperture) gives
greater depth of field. Apertures can be re-
moved and stored on your glasses rim. You
can check these by holding this page too
close to your eye to read. Through a small
aperture the type is sharp and clear. Try it
with a pinhole in a piece
of black paper.
GUNS AUGUST 1964
WAIT 'EM OUT!
GENUINE
PEARL, 5 TA G
IVORY &
(Continued from page 31)
there was an unseasonably dry fall in 1962,
and hunting was hard everywhere-in some
places practically petrified. Game was high,
foliage and brush cracked like exploding
popcorn, and it took skilled, hard hunting
to get within shooting range of the wary
animals.
It was the same at the Spring Creek
Ranch. Everyone had spotted deer, most
had a shot or two at fleeting bucks, but
the lack of snow, even in early December,
had driven the big bucks downwar d into
the relatively sparse cedars and plateau
country.
Despite this, we took some dandies, after
exceptionally hard hunting. Willie Peyton
took a t wofooter; I busted a 28 inch
muley buck the second day, and Don
DeHart (Alaska outfitter down there after
trophy muleys) almost got a shot at one
in the 30 inch class.
One of the hunters, however, became in
creasingly discouraged. He was used to
hunting heavy concentrations of Texas
whitetails from a stand; and despite several
days of hard hunting, he couldn't adapt his
technique to the prevailing tough hunting
conditions.
The evening before his hunt ended, he
gave up. I overheard him phoning another
outfitter, making arrangements to meet him
at noon the next day, 50 miles away, and
make another try in a different area.
Dearing was most unhappy about it. He'd
done everything a man could do to help his
hunters connect. As a final, extra offer, he
said, "Well, let's try again at daylight.
That'll still give you time to meet yom
" man.
At daybreak, as Dearing took the fellow
in the jeep up toward new and more distant
country, a great buck broke out into a tiny
valley below them. The "give up" hunter
piled out, and in three shots from his .300
Weatherby, had downed the buck-a perfect
typical six point head with an outside
spread of 30 inches!
There are more practical and measmable
reasons for the policy of hunting a little
longer and harder than the Horatio Alger
ratio of rewardtoeffort.
First, the hunter who works at it a bit
harder and a bit longer will find his com
petition less tough. He will usually be
among the same over-all 20 per cent of
hunters who consistently score. The 80 per
cent who won't climb the extra hill; stay
the final hour; or who give up too easily
GUNS AUGUST 1964
with an "- aw to hell with it," will quit
and take off for home, or camp.
This fact not only improves the deter-
mined hunter's chances immeasurably, but
also allows the game a chance to settle
down more to normal patterns of field be
havior, and return to natural habitat. Time
after time, a canny old buck or cagey bull
has gradually returned to his normal baili-
wick after the first shooting of the season,
thinking to find things safe . and has
been met by the hunter who stuck with it .
There is also another benefit for t he
hunter who hunts a wilderness area, and
with a professional outfi tter and/ or gui de.
Time after time, I've heard a top outfitter
say to a hunter, who'd worked his head off
under adverse hunting conditions, "Well, it's
been tough going. Your time's up, but if
you can spare the time, you're wel come
to hunt another day or so."
I heard Glidden McNeel offer t wo Wyom-
i ng elk hunters some extra time, after dry
weather had made elk hunting tough ; and
one of them scored on the "bonus" day.
I've heard Don DeHart make the same
generous offer to several Alaska hunters,
after rain had kept them camp-bound un-
duly. On a polar bear hunt in the Arctic,
blizzard and "white-out" kept our party
grounded in Kotzebue for nine days. Since
no plane could get through to Point Hope,
we were stuck; and nine days of our three
week trip were wiped out through no one' s
fault. But DeHart, knowing we'd stuck
through thick and thin on other tr ips, sim-
ply extended our hunt for those extra nine
days.
The outfitting and professional guiding
business is growing enormously, basically
because most prized trophies are found in
the remaining remote areas which can't be
reached with the average hunter's equip-
G R I P 5
Improve the
appearance of
your Revolver
or Automatic
with a new
pair of Selected
Stag.
Zebra
or
Per Pair Pearl, Rose ..
COLT Stag Ivory wood
Bisley .. . ... . .. .. . .. . $9.00 $1 7.00' $8.50
Single Action Army .. 7.00 16.00 6.20
Single Action Scout . ... . . 7.50 17.00 6.50
New Service .......... 6.75 15.00 6.20
Army Special . ......... 6.25 9.00 4.80
Official Police .... . ...... 6.25 9.00 4.80
Police Positive N.M .. . ..... 5.25 7.75 4.80
Bankers or Detecti ve Special 5.25 7.75 4.80
Police Positive O.M ........ 4.50 6.50 4.50
Pocket Positive ... .. .. . ... 3.50 4.50 3.10
.22 Woodsman, old model. . 6.25 15.00 4.80
.45 Auto. Government . . 6.25 15.00 4.20
.38 Super .22 Ace ..... . 6.25 15.00 4.20
.32 or .380 Auta. .. .. .. 4.50 7.50 4.20
.25 Pocket Auto ... . . . . 3.50 4.50 3.15
SMITH & WESSON
Magnum Style Grips
.357, 1905, 1908 .... .. 9.00
K.22, K.38, new model . . . . 9.00
Chief Spec, H. E. Rd Bult ... 9.00
" " Kit Gun (Sq. Buttl 9.00
17.00' 6.20
17.00 6.20
12.00 6.20
15.50 6.20
Standard Style Grips
Regulation Police ......... 8.00 11 .50
.44, .45 Model 1917, 1908 .. 8.00 9.00
K.22, .38 Sq. Butt, 1905 O.M. 5.50 8.00
1902 Rd. Butt ............. 5.00 7.00
Chief Spec. Kit Gun Sq. Butt 5.00 7.50
Chief Spec. Kit Gun Rd. Butt 4.25 5.25
.32 H. E. , .38 T.B ......... . . 3.50 4.50
.32 N.D. , .38 N. D. ..... . . . 3.50 4.50
(DERRINGERl-Remington,
Gt. West. and Germans .. 3.50
RUGER Single Six . 7.50
4.50
17.00
8.00
18.00'
17.00
Ruger Bearcat' 6.00
Ruger Automatic . . . 10.00
Hi Standard Double 9 7.50
7.20
4.80
4.80
4.20
4.20
3.20
3.15
3.15
3.15
6.50
4.50
6.50
Carved Ivory & Pearl Grips are Again Available
* Not Available in Pearl.
To insure prompt delivery we carry in stock
over 1000 Genuine Pearl, Ivory and Stag Gr ips
GRIPS W I LL FIT YOUR GUN as t hey were
made and fitted for standard factory frames.
Sold by Dealers, Gunsmiths or Direct
MAI L SOc FOR NEW GI A NT 56 PAGE
GUNSMITH SUPPLY CATALOG
FRANK MITTERMEIER INC.
Gunsmith Supply Headquarters (Est. 1936)
3577 E. Tremont Ave. New York 65, N. Y.
QtaLitv Shot
THAT IS:
Graded-Better
Polished-Better
Meets or surpasses all association
speci fi cations.
The Murdock shot will .produce a bett er
pattern. It is made hard enough by
, the additi on of ti n to the alloy wh ich t ends
to eliminate lead muzzle deposit.
For the name of your nearest distributor write:
tIi\ MURDOCK P. o. Box 5298
\U.1 LEAD COMPANY Dallas, Texas
51
PISTOL SHOOTERS'
Handbook - Catalog # 16 Ready Now!
Don't miss this new HandbookCat alog! Bigger and better than ever . . 214
jam-packed pages devoted exclusively to the pistolman . over 775 illustrations
. . . articles by top shooting and reloading authorities, Blankenship, McMillan, Joyner,
Clark, Reeves, Weinstein, Toney, Cartes, White, Weston, Shockey, Gibbs, Hebard,
and U. S. Army's Coaching Manual unabridged . These alone worth many dollars
if published in book form ... National Records .. . all latest products an<t prices
. . . hundreds of score improving items and tips . . . Clark. t Pachmayr
Custom Guns ... Ruger, Hammerli, Hi-Standard, S&W, Colt, Sig, Browning, !ver
Johnson, Crossman Target and fieJd guns.
The pistols Shooters "Bible" and standard references book. No catalog
A MUST for competitive pistolmen or anyone interested in handgunning.
PostDaid (3rd Class Mail)
Mailed immediately in PostDald (Air MaiD
protective envelope _ . . Postpaid (Hardbound Library Edition)
like It 1
$1.00
$1.90
$5.00
GIL HEBARD GUNS
KNOXVILLE 3, ILLINOIS
. . comes to you proposing fra nkly to give nothing but the
highest quality to y our moments. _ ." WALTER PATER
J"he Danish 'Handcrafted
SCHULTZ &; LARSEN
From the handfitted, carefully crafted parts,
t o the glowing beauty of the richly grained walnut
stock and the slim, graceful taper
of the barrel, t he Schultz & Larsen bears
t he unmistakable stamp of a Danish masterpiece.
Now avai lable in 7 x 61, .308 and .358 Norma
Magnums, .243, .270, .30-06, .308 Win.,
.264 Win. Magnum and 7 mm Rem. Magnum cali bers.
You wi ll pay two hundred and forty-five dollars
f or the distinction of owni ng this
superlative hunting rifle.
NOW AT BETTER SPORTING GOODS DEALERS EVERYWHERE.
no,.lnll-
p,.ee;s;on SOUTH LANSI NG, NEW YORK
New Ideas In Top Quality Holsters
THE HIDE-A.WAY HOLSTER
1144 BLACK BEAUTY GUN BELT
Handcrafted
for YOU; fits
Inside trousers
band; conceal-
ed but availa-
ble; protects
against grease,
rust. Wt. oz.
top grain soft
cowhide, rivet-
ed nickel clip .
. . ... $2.95 PP.
Fast draw type holster with soft glove leather white
lining. Belt and holster In black cowhide only. $8.99 PP .
Send waist size, caliber, model and barrel length of gun
when ordering. Double gun set available @ $13.95 PP.
"RAP ROUND"
HOLSTER
For 45, 38, 32 Col t Automatics or custom
made for any other automatiic weapon. In
black or natural, genuine leather, lined
for extra wear. Free, easy draw. State size
and type of gun when ordering. $2.98 PP.
52
1127-SWORD-CANE. RIDING CROP
Beautifully made, hand plaited, g!!nuine leather
patio. $5.00 PP. "
Send IO for descriptive literature
WHITCO
P. O. DRAWER 1712
BROWNSVILLE 18, TEXAS
ment. Trips int o such areas are costly, and
time is the big element in success.
I know, from over 30 years' big game
hunting experience, that professional out
fitters' bacon and beans depend upon the
satisfied, "repeat" hunter. I know that many
elements can often sour any hunt; but for
the hunter who sticks with the job of
getting his trophy to the very end, any
reputable outfitter will make special plans
to get him to game; to extend his time if
necessary; and to make his trip successful.
Oppositely, I don't recall any time when
an outfitter made special effort to help the
hunter who growled about the weather;
the l ack of game, the mosquitoes, or the
hardshi ps about camp. The hunter working
wilderness country, who sticks uncomplain
ingly to the job of getting his game, will
come out both money and trophies ahead,
simply because professional hunters will
like him, and will, themselves, make that
extra effort.
The small, trifling "extras" which the
average hunter disregards, applied wit h
stick.toitiveness, combine to bring home the
prized trophies. Here are some:
1. Adopt an attitude of success; plan, if
at all possible, for an extra day's hunting.
2. Keep in good physical shape. The
prized ram or grizzly is often just over the
next rise, where most hunters are too
pooped to climb.
3. Make your rifle capable of taking ad
vantage of the long shot-it's sure to come
in trophy hunting. Tune the rifle so it's a
bit more accurate. Keep stock and scope
mount screws tight. Develop the most ac
curate loads.
4. Sight in, at least one shot, before every
trip afield. This single shot, from a cold
bore, will indicate where the first hunting
shot will go.
5. Hunt a bit farther back in, aud
higher, than the average hunter will go. The
biggest heads are usually at the upper
periphery of the game's range.
6. Hunt a halfhour earlier, and a half
hour later than most hunters will. Game
moves more at these periods; hunter com
petition is less, meat cools better.
7. When a proved hunting technique fails
in an area, or with one species, reverse it.
That is, if climbing the ridges at daybreak,
and coming back to camp via the canyon
doesu't work, then work up the canyon
bottom, and take the ridges at dusk. Many
a wise old trophy has met his end while
watching his backtrack-the hunter coming
upon him from the unsuspected direction.
The constant application of such "trifles"
in the hunting field works a magic all its
own. The seasoned biggame hunter, who
has learned such factors to the extent he
does all of them without conscious thinking,
would have a hard time describing his
hunting technique. But he's the guy who
keeps lugging in the liver and horns. And
you can bet your bottom dollar that he's
also the one who keeps at it
when the going gets toughest.
FLOORPLATE
"...-
RELEASE BUTTONS
for Springfield 0 3, Enfield 1 4
_....T & 1 7 , Mauser 93, 9 4 , 9 5 , 96,
98 & 09-allows rapid, safe
;.....- unloading wit hout racking. In-
S
. fi Id d E fi Id stalls easily - No drilling or
I
pnng Ie an n 18 tapping. Serrated, hardened &
Rioht or Left Hand bl ued. Please specify rifle.
$ 1.50 postpaid Dealers write.
COUGAR & HUNTER
GUNS AUGUST 1964
THE CASE FOR THE CONVERSION UNITS
(Continued from page 29)
a steel one on the rear. This provides posi-
tive alignment with the original bore. The
muzzle end of the tube is threaded ahead of
the bushing and a knurled brass nut and
leather washer are provided to lock the insert
to the barrel. At the rear of the tube is a
U-shaped steel block, contoured to fit around
the top strap of the Webley revolver, and
slotted laterally across the top to allow the
insertion of the rear sight blade, which is
adjustable for elevation.
The cyli nder is quite interesting from a
design standpoint. Although bored for the
smaller cartridge, it is the same diameter as
the original .455 cylinder, but considerably
,horter, being just long enough to contain
the .22 Long Rifle cartridge. The sixshot
cylinder is un fluted and, in keeping with
British proof laws, has proof marks stamped
over each individual chamber. Like the origi-
nal, the .22 cylinder is fitted with a cam-
operated extractor which withdraws the fired
cases when the top-break action is opened.
To solve the ignition problem, that is, to
permit the nose of the hammer to strike the
rim of the .22 cartridge, the designer moved
the rear of the .22 chamber outward toward
the rim of the cylinder. But, if bored straight
forward, the chamber would not line up with
the bore, so the clever (?) designers merely
hored the chamber through the cylinder at
an angle of five degrees! This quite obviously
means that when the weapon is fired, the
bullet must make a five degree change in
direction while passing from cylinder to
barrel. This rather abrupt turn is made some-
what easier by the forcing cone being fun-
neled out to .295" at the extreme rear. It
then tapers rather slowly to bore diameter,
reaching .22" about an inch down the insert
barrel.
The Parker-Hale unit is easily installed in
the Webley. The two screws holding the
cylinder clamp are removed and the clamp
dropped toward the bottom of the weapon.
Now, with the action opened, the .455 cylin-
der can be easily withdrawn. It is not neces-
sary to remove any more of the original
parts in order to install the kit. The .22
insert barrel can now be easily installed,
keeping the open side of the Ushaped block
toward the top of the weapon. The insert
tuhe is then locked into the barrel, the .22
HYSCORE means SUPER ACCURACY!
cylinder is dropped into place, and the cylin-
der clamp is replaced. All that remains is to
fire the weapon and adj ust the sigh ts.
My first attempt to test fire the .22 Webley
was doomed because of an atrocious trigger
pull that went no less than nine pounds. An
application of a stone to the sear produced
a much more acceptahle pull, and I re-
turned to the range to see how this conversion
would group. The results were little better
than my first attempt, though I used a rest
and a two-handed hold. The shots went con-
sistantly high, and could not be brought
down into the bull, even with maximum
sight adjustment. The group, if you could
call it that, was a scattered three inch circle
in the four, five, and six rings. At first I
thought that this was a product of my own
poor shooting, but a competition shooter got
practically the same resul ts.
Examination of the target gave us a clue
to the possihle cause of this rather poor
shooting. Some of the ten shot "patterns"
showed that several of the bullets had key-
holed, hitting the target while practically on
their side. We took the Wehley home, where
we fired several rounds into cotton batting,
recovering the bullets. You didn't need to
take a close look at these bullets to see that
they had acquired a shape somewhat akin to
a banana. It seemed that the five degree turn
made by the bullets as they traveled from
cylinder to barrel was the culprit.
To further substantiate this, we loaded the
Webley with RWS .22 BB Caps and 10,
there was an honest group in the target.
Apparently the little round balls negotiated
the curve with no trouble, and were chuck-
ing into the paper in measurable groups. As
yet, I have found no way to keep that sloping
chamber from taking its toll when regular
.22 ammunition is used.
The .22 caliber Luger conversion kit,
manufactured by Erma Werke, of Munich,
Germany, is distributed in this country by
Interarmco, Alexandria, Va. The Luger kit
lists for $39.95 and comes packed in a
sturdy, attractive carton which is flock-lined
and compartmented for the various parts of
the converter. Also, included is a cleaning
rod of appropriate length.
The Luger kit is considerably more com-
(Continued on page 56)
Consistent accuracy through constant 10 RiflES &
muzzle velocity. Ideal for year 'round PISTOLS PRICED
inexpensive indoor and outdoor shooting. FROM $12.95 to $1
A safe means of acquainting the
beginning shooter with firearms handling, MOST ACCURATE & POWERFUL
but, with accuracy that will satisfy AIR GUNS MANUFACTURED
the serious target shooter.
SEE YOUR LOCAL DEALER WRITE FOR FREE CATALOG
H
'" SCOREARMS CORP.
'IT - 2SG LAFAYETTE
GUNS AUGUST 1964
takes care of tile
last 300 yards
No bullet does the j ob better
than the new Norma-Nosier.
Now you can buy these t wo
great names together i n a fac-
tory loaded round. Avai lable in
most popular cal i bers, f eat ur-
Ing Norma Vi rgin Brass cases,
Norma smokeless powders and
t he distinguished Nosier Bullet.
When performance counts,
count on Norma-NosIer.
Write f or your copy of the new " Gun-
bug's Gui de"; Send 25 to Dept. GM 8.
no,.",.-
OIV of Generol Sporllng Corp
SOUTH LANSING, NEW YORK
__ - For the First II
T . h - II nne In t e _
= N.Y. Area II
_ BLU-BLAK II
II RE-BLUING II
I SERVICE II
Unquestionably the world's finest. The only I:
II -
II a beautiful II
Discounts to Dealers and Gunsmiths
CUSTOM S HOOTER'S CE NTER Dept. G-3 II
II 3743 White Plains Rd .. Bronx 67, New York _
.. -----------.,
640 ACRES OF
W I LDLIFE - $20!
$20 plus $6.50 taxes yearly gets you your own
640 acre wildlife hunting paradise near Canadian
border. One of the last accessible big game refuges
in North America. These are abandoned timber
leaselands (now re-forested), many readily accessi-
ble by original logging roads. Thousands of exclu-
sive lakeland campsites. Heavy second growth
timber teems with every imaginable kind of wild-
life. Including bear, moose, elk, caribou, timber
wolves, lynx, wolverines, deer, geese, ducks, mus-
kies, huge northern pike, walleyes, pickerel, rain-
bow and steel head trout, maskinonge. One of these
secluded hunting paradises can be yours to enjoy
for the rest of your life. No other hunting lodge
may be erected within at least one mile of yours.
Many are over 20 to 50 miles away. Send $1 (re-
fundable) for maps, pictures, Govt. regulations,
official application blank. Director, O.S.C.A.,
Room 462, 56 Church, Toronto I, Canada. (En-
closed is one dollar) (refundable) Add SO for msl.
air mail.
Name . .. .. .... .. .
Address ..... . . . .. ..
City .. .. ..... .. ... . ... . .. State ..... ..
53
DON'T MISS YOUR ONE BIG CHANCE.
of
or Iron Sights
COMBINES TWO IMPORTANT ADVANTAGES IN ONE
MOUNT-provides instant use of open sights and
a scope mounted as low as possible on your rifle.
Don't let foul weather or a damaged scope spoil
what may be your only big chance. As some
hunters will testify, this swing-off feature can
make the difference in a life and death situation.
The upper rings of the Lo-Swing mount makes
detaching your scope easy-ready to replace
upon arrival at your hunting site. Uncondition
ally guaranteed to ma intain zero sighti ng align
ment. LoSwing TOP Mount (shown) $20_ LoSwing
SIDE Mount $15. See your favorite dealer. Write
_ for FREE 16-page product fo lder.
P ACHMAYR GUN WORKS,INC. , DEPT. G-S
1220 South Grand Avenue. Los Angeles 15, 'California
HOLSTERS by DON HUME
rdan HoIster-Constructed from heavy
Ie Leather. Metal in holster extends
into belt loop. Welt and plug are hand.
stitched with waxed linen thread. For
double -ac Uon only .. . $9.8 5
River Belt-Heavy skirting. Solid brass buckle.
Width 2" only. Give waist size .. . $7.20
.. 2:'.
CATALOG 3 5c. Refunded on First Order. Postage Paid.
Bona Fide Deale r Inquiries Invited. Okla. Resid. Add
2 0/0.
54
DON HUME LEATHERGOODS
Rout e 1 , De pt . Of Park Hill, Oklahoma
PACIFIC
WAD COLUMN
INDICATOR
Simple, fast, accurate
No more guesswork or con
stant chart reference to de
termine proper wad column
in new or fired cases. Just
insert indicator atop powder
charge. Reading a t case
mout h gives exact wad col
umn for any recommended
load - regardless of base
wad condition. Also has shot
level indicator for determin
ing proper crimp depth.
Available in 12 gauge only
- other gauges soon.
PACIFIC
.. _ .. GUNSIGHT
COMPANY
Box 4495, Dept. GS
Li ncoln, Nebr_
PACK FRAME gaining rapid acceptance by
climbers, hunters, and hikers is the Large
Cruiser No. 202, made by Camp Trails, Dept.
G-B, 3920 W. Clarendon Ave., Phoenix 19,
Arizona. This is the pack selected by the
American Everest Expedition in 1963. The
back straps are wide and comfortable, and
the shoulder straps are swivel mounted for
personal adjustment. Price, $10.95.
CATCH-PELLET trap feat ures a pyramidical
design and patented inner slide which abso-
lutely prevent ricochets. Made of special
heavy steel, the Catch-Pellet trap handles all
BB's and air or C02 pellets. Retail price,
only $4.95, at your dealer, or write National
Cartridge Co., Dept. G-B, 1314 Avenue L,
Brooklyn 30, N.Y.
NEW EXPERT series of gun caddies, made
,by the Mastra Co., Dept. G-B, 2104 Superior
Avenue, Cleveland, Ohio, is available in eight
sizes, ranging from a pistol case to a case
for two scoped rifl es. Prices range from
$17.95 for the pistol case to $34.95 for the
two-gun rifle case. These cases have many
outstanding features to protect your guns.
Complete details on the Mastra line are
available on request.
THE FAMED .30 caliber M-l Carbine, of
fered by District Merchandise, Dept. G-B,
1207 King St., Alexandria, Va., has all newly
manufactured parts, and a highly accurate
six-groove barrel. Two stock choices are
available; GI, or sporter type without sling
cut. The carbine is warranted without time
limit, and is priced at $BO.95 postpaid.
FOR A LIMITED TIME you can purchase
three rare old gun books at half price. The
First Edition Gun Digest, regularly $2.95 is
reduced to $1.50; "Fourteen Old Gun Cata '
logs" and "Ten Old Gun Catalogs," by L. D.'
Satterlee, priced at $3.95 are reduced to
$2.00 each, postpaid. Take advantage of this
special offer at your dealer, or direct from
the Gun Digest Association, Dept. G-B, 4540
W. Madison St., Chicago 24, Ill.
TIllS MAYBE YOUR last chance to get
one of the handsome bullet displ ay boards
from Speer, Inc., Dept. GB, Box 244, Lewis
ton, Idaho. The stock of these cartridge
boards is nearly depleted, and they are ex
pected to be sol d out by December. The
board is 21 inches long, printed in four
col ors, and handsomely framed in mapl e
finished hardwood. Available at your dealer ,
or direct from Speer at only $B.50 postpaid.
GUNS AUGUST 19'"
MAGNA LEATHER COMPANY, Dept. G-8,
Box 12487, Fort Worth, Texas, has many fine
holster and belt combinations shown in their
free 1965 catalog_ Shown here is the Larado
outfit which features a low cut holster with
safety strap. Choice of black or brown, in
choi ce saddl e leather. Priced from $16.95,
plain, to $24.95 for the flower carved design_
IVER JOHNSON's new Model 67 Viking
revolvers again have the famous " I-Iammer
the Hammer" feature, fitst registered in 1904.
Thi s important safety feature will be found
on all of the .22, .. 32, and .38 caliber Vikings.
See them at your dealer now or write to
Iver Johnson Arms & Cycle Works, Dept.
G-8, Fitchburg, Mass. for brochure.
VIC'S FOR GUNS, Dept. G-8, 2413-D, Gal-
veston, Texas, is fast becoming the nation' s
foremost source for surplus commercial and
mil itary rifl e and pi stol ammunition. They
have over 600 calibers in stock, and offer
same day shipping and prepaid shipping
charges on orders over $50. A stamp will
bring you a compl ete li st of calibers avail-
able.
HIGH QUALITY AND LOW PRICE are
features of the new 20 power spotting scope
made by Bausch & Lomb Inc., Rochester,
N.Y. The Bal scope Twenty appeals to any-
one who wants a durabl e general purpose
scope. It is 15% inches long, and weighs
only 22 ounces. Available at your local
dealer under $25.00.
GUNS AUGUST 1964
THE COMFORT OF a true Indian moccasin
with the snug fit of a laced shoe are yours
in this Alaskan Tracker, by Alaska Sleeping
Bag Co., Dept. G-8, 334 N.W. llth Ave.,
Portland 9, Ore_ Priced at $9.95 per pair,
they feature double stitching and tough tan
elk leather. Sizes 6-12, E width only.
LYMAN GUN SIGHT Corporation has re-
leased the 43rd edition of their famous Re-
loading Handbook. The new edition is ex-
panded to 226 pages, covering every phase
of ammunition reloading. For beginners, the
Lyman Handbook is a must. For the experi-
enced reloader, it has much new material on
loads, methods, and techniques. The price is
$2.50, and it is available at your local dealer.
SHOOTING S'JAR is the latest pistol stock
design by Steve Herr-ett. of Herrett's Hand-
gun Stocks, Dept: G-8, Box 741, Twin Falls,
Idako. This stock is made for all shooters,
it's not too large and not too small. Both
right and left panels have a raised line that
permits right or left hand shooters to fire
single or double action_ Sixteen line check-
ering extends almost all around the grip.
Available for eleven different handguns, the
Shooting Star sells for $9.95. Your df'aler
will have these soon.
Work with the latest
equipment-in modern shop
and classrooms
Day or Night Classes
Advance rapidly-based on
personal aptitude
New classes starting every
week
Grad uates located in 48 state s and
foreign countri es! V.A. approved for
ALL classes of veterans. T his is not
a correspondence course.
OUR INTEREST IS GUNS ONL Yl
Write for fr(.'c cata l og .. nd i n f Ol'mation on
SCHOOL
Q?) OF TRADES, INC.
1535 Hoyt Street,
Denver IS, Colorodo
U. S . and Canadian Pat.
Complete job hown
for' Most guns $30
Anti-recoil Gun Barrel
The de-kicker de luxe that is precision
machined into your rifle barrel, avoiding
unsightly hang-onl. Controlled elcape for
highest kinetic braking, minimum blast ef-
fect and practically no Jump. All but pre-
vents iet thrust (secon ary recoil). Guar-
anteed workmanship. Folder. Dealer dis-
counts.
PENDLETON GUNSHOP
Famous
Name Brand Mdse.
at Wholesale Savings!
LOOK AT THESE
Owlie's
DISCOUNT SAVINGS: Retail Price
Forster trimmer
$11.40 complete . ...... $14.25
Ohaus Scale .. .. 19.50 13.65
lyman #55 Powder
11.97
Measure .. ... .. 16.00
an Single Cavity
Bl ocks.... 6.50 4.88
Mould
2.65
l es ....... 3.50
12.00 9.30
Redding Sca le ... 14.00 10.43
l yman # 45 Sizer
and Lubri cator
14.43 (less dies) ... . . 19.50
lube and Size dies
for #45 Sizer
4.50 above ........ . 6.00
SHIPPED SAME DAY. SATIS.
GUARANTEED! Add $1.00 t o cover
handling and shIpping costs . Send
check or Money Order. Sorry, no
C.O.D.'s.
Free CatalOG
HOT OFF THE PRESS!
Wi th the lowest prices anywhere
TENTION GIVEN CLUBS!
OWLlE'S SHOOTER'S DISCOUNT STORE
6311 Yucca Street. Dept. G-8
Hollywood 28, California
55
New, Exciting, Illustrated
iMWlMili Catalog Every 8 Weeks-
.. Now 84 Pages Each Issuel
II'! Thousands of anti que Colt
revolvers, Kentucky ri fles,
.. 1Ii .... pistols, mus kets, swords,
r.' daggers from a II over the
world : uniforms, helmets.
gun books, etc . . all differ
ent each issue. Widest se
lection ava ila bl e anywherel
Subscription Just $ I . 00
per Year. Send now to:
N. Flayderman & CO.
Squash Hollow, Dept. G-B
New Milford, Conn.
TOP CASH PRICES PAID-
For your Antique Guns and
Military Equipment.
MAGNUM SHOOTERS
CUTS
CLEANING
TIME
90%
Stops
Rusting
UNEXCELLED ACCURACY
Proven at ... used by Military Centers
Kit $7 ppd. inel. 4XF, 4 swabs
Ask your dealer for refills
RICE P d cts
Box 2531 G
, ro U Palm Beach, Fla. 33482
Kf You Like 10 NRA
fOveEto?iJI i:
..Att 2}/'eje NRA MEMBERSHIP
BEN E FIT S /0,. Ollt,! 5i(!{! ;])offarj
A Year's Subscription to
THE AMERICAN RIFLEMAN MAGAZINE
The world of guns and shooting is thoroughly covered in The
American Rifleman, sent to you each month as one of your NRA
membership services. You'll keep abreast of shooting and hunting
activities: relive firearms history; learn the practical use of guns
for more fun the year around. You' ll read about rifles, pistols,
shotguns; hunting and target shooting; gunsmithing and gun col.
lecting; reloading and related subjects every month. Especiolly
valuable are impartial product evaluations, based on practical field tests of new
products reviewed. Other subjects fully covered include articles on how to buy,
shoot and care for guns; where and how to hunt; amateur gunsmithing and reload.
ing methods; firearms legiSlation proposals, the top authority on guns and shooting.
Annual Membership in the
NATIONAL RIFLE ASSOCIATION
Over 600,000hunters and shooters-the members of NRA-invite you
to join the National Rifle Association and enjoy the many benefits
reserved for members. You' ll get prompt answers from our firearms Information
Service; gun law bulletins; information on how, when and where to hunt and low.
cost gun insurance; an opportunity to purchase from the Army such firearms, spare
ports and military targets a s are made available for sale to NRA members at cost-
t o government prices. You can participate in year around shooting programs and
be eligible fo r marksmanship instruction. In addition, NRA will introduce you to
a rifl e a nd pistol club in your community, or help organize an NRA club. And your
support wi ll help preserve the right .of f ree Americans to own and use firearms for
la wful purposes.
. Please enter my subscription
to THE AMERICAN RIFLE.
MAN, en roll me a s a n NRA
MEMBER a nd send my lapel
button."
o $5.00 Endosed
o Bill me please
56
NAME .................................................................... : .... AGE .......... ..
ADDRESS ...................................................................................... _
CITy-STATE ................................................................................... .
NATIONAL RIFLE ASSOCIATION 603-08
1600 Rhode Island Avenue, Washington 6, D. C.
Confirming application & details will also be mailed.
J oin NOW! and receive
this golil-filled NRA memo
bership la pel button. Sells
r egularly f or $1.50yours
at no extra cost.
MAIL THIS
APPLICATION
TODAYl
(Continued from page 53)
plicated than the Webley and consists of
three maj or components; the insert barrel,
the breechblock assembly, and a tenshot, .22
magazine. As the insert barrel for a standard
four inch Luger measures seven and one
quarter inches over .. all, a sl eeve or spacer
to cover this additional length is included .
The insert barrel of the Luger has a steel
bl ock at the breech end, as an integral par t
of the tube. The block is slotted at the top
to take the .22 extractor claw and ahead
of the block the tube is turned to dimen
sions which exactly fill the 9mm chamber.
The next three and one half inches of the
insert tube are a snug, sliding fit in the 9mm
barrel, thus insuring positive alignment. The
remainder of the tube is covered by the
barrel sleeve when the kit is installed, and is
threaded to take two knurled steel lock nuts.
The breech mechanism, quite similar to
t he original Luger action, incorporates the
same toggle principle, and contains its own
lighter recoil springs. There are two of these
coil springs; the larger acts sol ely as a
recoil spring, absorbing the recoil and closing
the action after a shot is fired; the smaller
absorbs a portion of the recoil on t he open
ing part of the cycle, is retained by the sear
when the action is in the full back position,
then is used to drive the striker foreward
when t he trigger is pulled for the next shot.
The installation of the Luger kit, t hough
somewhat more complicated than the Webley,
is still relatively simple. First, t he Luger is
"fieldstripped" in the normal manner. While
it is not imperative that the ejector be reo
moved it makes insertion of the .22 tube
easier, and the unit does seem to work better
with the ejector removed. The insert t ube is
installed in the 9mm barrel, keeping the
extractor notch to,ward the top of the weapon,
and locked in place. The .22 breechblock
assembly is slipped into the receiver and the
original connecting pin replaced. As the .22
unit contains its own recoil springs, t he
original connecting link is eliminated, and
the receiver can easily be slipped onto the
frame. Replace the sideplate, insert the .22
magazine, and the conversion is complete.
One point of interest is the striker pin,
which protrudes from the rear of the toggle
assembly, when cocked, and serves as ' a
positive indication that the pistol is ready
to fire.
As soon as the Erma conversion kit was
installed in one of my Luger pistols, I was
off to the local range to see how it would
perform. Loaded with high velocity ammo,
the first shot produced an unexpected resul t
-the magazine fell completely out of the
gun, landing on the ground. The magazine
was wiped clean and put back into the gun,
with a double check made to be sure it was
properly latched. When the next shot was
fired, the magazine stayed in the gun, but
the spent cartridge case hung up between the
breechblock and the receiver. This could
only mean that t he breechbl ock had not been
driven completely back to a full open posi.
tion, or the case would have been kicked out
by the ej ector.
The magazine showed rub marks on the
feed lip, and when it was latched up into
position, this caused the action to bind. The
lips were filed down to where they would no
longer rub, the magazine was agai n loaded,
and no malfunctions occured. However, this
GUNS AUGUST 1964
was with hi gh velocity ammo. The i nstruc
tion booklet said that the unit would work
wit h standard velocity also, so a cl ip load
of this was tried. Only about three or fou r
rounds functioned sati sfactoril y. I'm sure
that taking a few coils off of the r ecoil spring
woul d correct thi s, but I haven' t worked up
enough courage as yct t o do t his.
The accuracy of the Luger conversion is
not too bad, but it isn't exactly aweinspiring,
either . My groups, as well as t hose of sev-
eral of my more experi enced shooti ng friends,
averaged about two inches. This may be
good cnough to keep you in the bl ack on a
standard slowfire target. it certai nl y does
not compare with the better .22 target hand
guns available. Not only were t he groups
rather large, they were high, and to t he l eft
of the bullseye, using the normal six o'cl ock
hold. Because the sights are not adjustable,
the only alternati ve is the use of 'Kentucky
windage," which leaves a lot to be desired.
One other small i tem worth mentioning is
case distor tion. Inspection of the fired cases
showed that each had a bul ge on one side,
corresponding t o the position of the fced
ramp cut into the bottom of the chamber. I
must say, though, that I did a lot of firing
with this unit and have neyer had a split
case.
The Colt conversion unit is available
through any Colt dealer for $49.95. This
unit can also be used wi t h the Colt Super
.38 automatic or any surplus GI .45 Auto
such as those made by Ithaca, Remington,
etc. It will not howevcr, fit the Colt Com-
mander . Like the Lu ger unit, the Col t kit
consists of threc maj or components; the
slide, .22 barrel, and the .22 magazine. Also
included is a lighter . r ecoil spring and
another slide latch to fit the conversion slide.
This kit differs from the other two in that,
whi le it does r ed uce the caliber of the pistol,
it retains t he recoil of a much heavi er car-
tridge. This is accompli shed through the use
of a fl oating chamber which util izes the
expanding gases to mul tiply the recoil of the
.22 cartridge approximat ely four ti mes. While
this may not be an inducement to use the
conver ted pistol for competition or plinking,
it does allow one to practice much less ex-
pensivel y while retaining the r ecoil charac-
teristics of a heavier celiber. Whether this
additional recoil is desirable in a conver sion
kit will depend solely on the opinion of the
user.
The Colt kit, having its own slide, exposes
more sur face than either of the other two
so it may do well to comment on the finish,
which is equal to any of the commercial
grade Col ts. The sides of the sli de are done
in a polished blue while the top is a dull
finish to prevent glare. The slide al so boasts
target type sights, the front being undercut
while the rear is click adj ustable for both
windage and elevati on.
As with the Luger, the Colt must be fi eld-
stripped in order to install the adapter. The
original .45 r ecoil spring guide, plug, and
barrel bushing are used with the conversion
kit. Complete reassembly of the pistol, using
the three original parts previously set aside,
plus the light recoil spr ing that comes with
the kit is easily accomplished by following
the instructions furnished.
The Colt conversion unit gave no problems,
j ust as it came from the factory. It r equired
no t inkering, and has yet to produce its fi rst
malfunction. It did require a mi nor sight
GUNS AUGUST 1964
adjustment t o get it shooting in the black,
but once it was zeroed, it gave consistantly
good accuracy, even in my inexperienced
hands. We tried several groups using a
tighter barrel bushing from an accurized
target .45, but there was no noticable im-
provement. The unit could, I suppose, be
accurized, but I doubt that the expense
woul d be warranted.
All three of the conversion units men-
tioned had one thing in common : they pro-
vided an economical means of shooting a
gun t hat was designed for r ather expensive
ammunition. But, all had one or more draw-
backs. The Webley gave r easonable accuracy
only when using pipsqueek loads; the extra
three inches of barrel l ength with t he Erma
conversion made the Luger far t oo bulky
to be used as a plinking or hunting gun; and
the Colt, while fi tted with excellent sights
and offering perfect f unctioning, is priced
rel at ively higher than the other s.
I can, perhaps, see the .22 conversions as
military training aids, and even as an in-
t erest ing thing with which to exper iment,
but I personally feel that anyone desiring
a .22 handgun at minimum expense would
do better to select one of the less expensive
Colt, Ruger, Hi-Standar d, or other available
handguns.
I'll keep my Colt uni t for shooting; the
Luger kit will join my modest Luger col-
lection; and the Webley, well I guess I'll
just keep it around. And, when I need some-
t hing to dwell on, I'll just sit quietly and
cont emplate that five degree bend the bullet
takes as it wiggles its way through
the chamber and barrel.
READ
TARGET TURN 50 DISTANCE
IS DOUB" IMAGES MERGE ON DIAL
I NSTANT MARKSMANSHIP! J ust focus this pr e-
deadly accuracy every shot. TerrifiC for va rmint
llunters. J ust 12 Inches long. Deluxe set including
Rangeflnder. Leather Holster Case. and 5x Telescope
EYepiece for easiest long- range focussing- S29.95 com-
plete. or you may order the Rangefinder alone for
$19.95. (Also a vailable 250-yd. models f rom $9.95. )
Ideal gift. 30 Day Money-back guar. Send check to:
l
oeal e .. : I FEDERAL INSTRUMENT CORP., DEPT HC-8
114-06 Rockaway Blvd., JAMAICA 20, N. Y.
THE ORIGINAL PLASTIC GUNSTOCK INLAYS
Hand Cut on Precision Machinery from Fi nest
Quality Sheet Plastic. Send for New Catalog
of Latest Designs. Complete Instructions.
>- c. D. CAHOON, Boxford, Mass.
New precision loading press for $27.50
If you want X- ring accuracy, you're
the man to own a Savage Straight-8
Press. There is no give or spri ng
in this fine centerfire reloading
press because its frame is a solid steel
drop forging. (And it's practically
i ndestructible.) Straight-8 design gives
extra bearing surface that supports
the ram under maxi mum pressure. And
because there is such perfect alignment of
the ram with the die, you get the utmost
preCision in reloading, resizing and bullet
swaging. So-for accuracy, strength,
dependability and economy-get the
Savage Straight-BPress for onl y $27.50.
Takes standard 'l's" x 14 dies, converts to right or
left-hand use and to bullet swaging in mi nutes.
Sold only by retail sporting arms dealers.
Free color cat alog of Savage firearms and accessor ies.
Writ e: Savage Arms, Westfi eld 67, Massachusetts.
PRI CES SUBJECT TO CHANGE. SLI GHTLY HIGHER I N CANADA.
SallBge
57
OF THE FINEST BRITISH MANUFACTURE
A simple, life-saving accessory
that no boat, whatever size it
may be, should be without! Genuine
Webley flare pistols used by the
British Navy. Choose from 25mm or
37mm. Priced below manufacturer's
original cost-only $9.95.
2Smm FLARES ____________ $ .2S ea.
37mm Magnum FLARES 1.SO ea.
...::s:
---
New DEM-BART Checkering Tool.
Engineered to satisfy exacting demands of precision
craftsmen. CUts shallow, deep, straight, around corners,
parallel lines or cross-hatching, with or against grain,
No back-tracking! Steel cutter blades in 6 styles. 8
sizes are machine-cut steel, hardened, heat treated.
.001 of an inch tolerance.
DEM-BART, 3333 N. Cove St., Tacoma, Washington
58
Loads rifle, pistol
or shotshells
Full length resizes and
swages bullets with ease
Lathe bed cast iron
frame not aluminum or
aluminum alloys_
Ib .Complete with primer
s. arm, insert and shell
9S holder of your choice
New I
HERTER'S .22 CAL. WESTERN
SINGLE ACTION REVOLVER
5 inch micro-precIsIon barrel. Ad-
justable rear sight. Heavy, custom,
full sized frame. Tenite checkered
grips. All working parts made of
the finest weapon steel. Send
Firearms Permit No. for dealers
prices. Send 25 for huge
500 page catalog.
GUNSTOCKS AND GUNSMITH SUPPLIES
Micro-precision
$7.50 and up.
THE PRO-GUN LAW TAKES SHAPE
(Continued from page 15)
in Washington could weigh heavily in our
favor. These battles will have to be fought
sooner or later_ The sooner the better!
Many of the letters we have received con-
tain suggestions for improvement of the
rough draft of the pro-gun law which we
published in our May issue. It needed im-
provement; has been improved since that
publication. Every suggestion received has
been given careful consideration. We cannot
possibly discuss all of those suggestions in
print, but here are a few that show how
closely our efforts are being studied_
Unanimous and unqualified approval has
been expressed by our readers for our in-
tention to write into our bill a correct, official
interpretation of the Second Amendment.
Anti-gun forces have found just one word
in that Amendment from which they could
draw confusion as to its meaning- the word
"militia_" The following excerpt from one
letter refutes that confusion and provides
hard-hitting ammunition for every defender
of the right to keep and bear arms:
"As a professor of English, with
some reputation in the specialty of
semantics--and a shooting hobbyist-
I have just completed a careful and
I think thorough study of the word
'militia' as used in the Second Amend-
ment_ Words change in meaning as is
indicated by the very definition of
'semantics.' But any written word must
be accepted in the meaning it had
when it was written ... _
"Every source contemporary with
the writing of the Bill of Rights which
I have consulted agrees that 'militia'
meant 'a body (group) of citizens en-
gaging in military activities.' One
source adds the phrase, rather telling
from the pro-gun point of view, '_ ..
not applicable to professional soldiery_'
"My fairly current Webster's Inter-
national Dictionary (Unabridged) ap-
proximates this in one of its several
definitions (. . . 'A body of citizens
enrolled as a regular military force
for periodical instruction, discipline,
and drill _ . _ etc.'), but then goes on:
'In the United States the term militia
as used in the Constitution refers to
the forces (National Guard)
formerly known as the State Militia.'
"The words 'as used in the Consti-
tution' are appalling to any scholar,
who must know that there was no
'National Guard,' nor 'State Militia'
either, at the time the Constitution
was written. Webster's confounds its
own definition, in fact, by further
stating that the militia, as it defines
it, was created by 'Act of Congress
(32 Stat. 755)' in 1903!
- "A word written-in 1789 cannot pos-
sil:!ly have meant something not cre-
ated until 114 years later!
"But even accepting the fact that
jurists (even at Supreme Court level
-and to say nothing of legislators)
are not necessarily scholars in the field
of semantics, it should be obvious to
even the lay reader that the phrases
'A well-regulated militia, being nec-
essary to the security of a free state,"
are merely prelude to what comes
after. They merely tell you why 'the
right of the people to keep and bear
arms, shall not be infringed.' This is
the meat of the Amendment; and it
does not say 'the right of the militia
to keep and bear arms'; it says 'the
right of the people.'
"'The people' means exactly the
same thing now that it meant then;
and if we are to remain a nation of
free men, that meaning must never
be changed, either in semantics or in
politics."
We suggest that this be memorized and
freely quoted!
Two letters beg us to rephrase our law
regarding ownership of arms by persons con-
victed of felony. Both writers confess convic-
tion on charges of felony, many years ago_
But they have lived blameless lives since (in
one instance, for more than 20 years), and
they ask: "We paid our debt to society, long
ago. Weare respected citizens in our com-
munities now; we think we have earned the
right of forgiveness. And there are many like
us; more than you would think." (The letters
were from far-separated sources; the plural
pronouns here merely combine the pleas.)
Others, a few, protested our footnoted
statement that we "will not attempt to legal-
ize 'pen guns,' 'belt-buckle' guns, or other
such odd-ball weapons, except for the pro-
tection of collectors." On the advice of every
person consulted (excepting the writers of
those letters), we must stand on that state-
ment. Sympathetic though we truly are to any
argument against any firearms restriction, it
seems to us too difficult to make a case for
the practical desirability of such weapons-
and the criminal and accident case against
them is too strong- to warrant wasting any
part of our strength on them .
Similarly, we must reject the writers (per-
haps a half a dozen) who have berated our
lack of courage in not fighting for the right
to carry without license. We believe that, if
we can obtain the stipulation that police
authorities must issue carrying licenses at
modest fee unless the police can and do
prove that the applicant has a criminal rec-
ord or is otherwise incompetent, we will have
solved 99 per cent of the problem. True,
there would still be a "restriction," but
surely not an intolerable one-especially
when it is weighed against the practical
realities of what you can't possibly achieve
and what you can reasonably hope to ac-
complish_
The Pro-Gun Law is taking shape, on
paper, and in the minds of many political
leaders. It is not yet perfect; problems of
procedure remain to be solved; legal mazes
have to be threaded. But it is far advanced
from where it stood last December. It is an
untried colt as yet, but it shows promise.
We must not saddle it with more weight
than it can carry; but we suggest that you
should not under-rate it, eitheL The colt will
run; this is your invitation to back him- an
open invitation to every shooter in America,
regardless of which shooting sport he favors,
regardless of which magazine he reads or of
which group he is a member_
Are you with us, or against us?
GUNS AUGUST 1964
GUNS AUGUST 1964
PRESERVE YOUR RIGHT
TO USE AND ENJOY GUNS
JOIN.
AMERICA MEANS TO YOU!
YOUR MEMBERSHIP!
r--------------------------------------
THE SHOOTERS CLUB OF AMERICA / 8150 N. CENTRAL PK. AVE. / SKOKIE, ILLINOIS
Please enroll me as a member of the S.C.A. in the category checked below:
o Full membership including subscription to GUNS Magazine and all other
benefits described above. Payment of $7.50 for one year enclosed.
o Associate membership including all benefits described above except sub-
scription to GUNS Magazine. Payment of $3.00 for one year enclosed.
o Junior membership available to those 17 years and under. Includes all
benefits except subscription to GUNS Magazine. $2.00 payment for one year
enclosed.
______________________________________________ __
AD DR ESS; _________________________ _
CITY ZONE ___ _____ _
o I wish to receive only GUNS magazine at the yearly rate of $6.00. G-8
59
The New Sensational
GUN RACK
"PEN GUARD"
(Continued from page 12)
TEAR GAS DEVICE
Larger, 400/0 More
Powerful
Shell
Additional super shells $.95 each
You're always "on guard" against robbers, mashers
and other criminals when you carry this innocent-
looking TEAR GAS Device. Nickle plated, spring-
steel clip. Not a firearm. No permit needed.
SEND CHECK OR MONEY ORDER_ NO COD'S
Not MAILABLE, Sent by Express. charges collect.
This product is not intended for sale in states or
localities which have laws forbidding their sale.
PUBLIC SPORT SHOPS Est. 1918 .
DEPT. G 11 S. 16th ST., PHILA. 2, PA.
l eft hip for the off-hand position, and found
the rubber padding on the elbows ample,
yet supple enough for easy movement. The
coat comes to you packaged in a plastic
zipper box, and all in all, the Top ~ o t
coat is not only a highly serviceable coat,
but also a handsome one. Best of all is
the price, only $29.95, directly from Bob
Allen's shop.
Redfield M 94 Scope
Ever since the use of scopes on hunting
rifles has become popular, there has been
one long and loud lament from those of us
who enjoy the Winchester Model 94-how
the heck do you get a scope on that gun?
Several attempts had been made in that di-
rection, but nothing really jelled in produc-
tion until Ed Hilliard of Redfield Gun Sight
Co. got to work on the project.
Most scope manufacturers, when sub
mitting scopes for tests, neglect to send
along rings and bases. Last time we tried
a scope for a 94, we had the devil's own
time with it, and finally abandoned the
project. Ed, or some other genius in Ed's
shop, got a brainstorm-they shipped not
only the bases and the scope-they also
shipped us a brand-new Model 94. All we
had to do was to slip the scope on the dove
tails, lock her up, clean the grease out and
off the gun, and run the collimator test. By
gosh, the scope was even zeroed in!
in trap, in skeet, in the field! Seventy-five years of superb gun making have finally produced the
sensational new Charles Daly line of custom-crafted shotguns. Take the over-and-under. It's
incredibly fast and light, soundly designed yet elegant in appearance. The man who knows will
appreciate its remarkable "fit," automatic ejectors, single selective trigger and perfectly tapered
ventilated rib. From $255 in 12 and 20 gauges. The Charles Daly "five-hundred" side-by-side is a clas-
sic. Straight to the point it's the perfect field gun with a balance to defy comparison. From $129.95
in 12 and 20 gauges. Both guns are available in the full selection of barrel lengths and chokes
at your favorite dealer, or write the Charles Daly Corp., 88 Chambers St., N.Y.C. Dept. SI 8.
60
The new scope, known as the M-294 offers
a very low line sight, does not interfere with
brass ejection, has an integral mount that
is securely attached to the barrel, has an
eye relief of 6"-10", and the 2X power is
more than adequate for the type of hunting
you'll do with the M 94. We gave the Red-
field scope the freezer, shock, and drop tests,
then remounted the scope, and the WoW
ammo shot into exactly the same group as it
did the week before. If you don't want to
use the scope, just slip it off the rifle, and
you can use the l eaf rear sight. If you have
the know-how, you can install the base for
this fine little scope yourself, or your gun-
smith can do it in a couple of minutes. Now
the M 94 has a new lease on life (as if it
needed it), and we have a scope on one of
our old favorites.
Crow Records
Not too far away from my home, there is
a very active crow roost and birds trade
right over my place. When Wightman Elec-
tronics, Inc., Box 989G, Easton, Md., sent
us their new crow calling r ecord, I could
not resist the temptation. I set the el ectric
game caller up, and when the first black
robbers made their appearance, I turned on
the caller. That record sounds like a first
rate crow fight, and the birds came piling in
fast and furious. The record, WC-3, r etails
for $2.50, and Wightman's have a great
many other records; they also make the
"Call of the Wild" record player.
Canadian Ammo
Canadian Industries Limited, Box lOG,
Montreal, Quebec, Canada, shipped us some
test ammo after we had a session with one
of their ballistics men not long ago here in
our offices.
We gave the C-I-L trap and skeet loads a
good going over for the past several weeks,
and found that they compare favorably with
our domestic ammo and the stuff that we
handload. Pressure-sealed crimps hold up
very well, and autoloaders and pump guns
were used to check the Canadian shells.
Perhaps the most severe test for paper hulls
is the wear test. A magazine is filled with
live rounds, and the rounds are being
ejected manually after feeding into the
chamber. This test is repeated with each
shell 20 times, and the C-I-L stuff came
through this one as well, if not a bit better,
than domestic paper hull loads. They pat-
terned ok, and we were completely satisfied
with their performance.
When we talked to the C-I-L man here
and he showed us some of the new center-
fire rifle ammo, we had to look twice, then
blinked once, and then we looked again. The
GUNS AUGUST 1964
bullets had nylon tips ! The Canadians dis-
covered, just as we did, that t he soft lead
tips on bullets can get an awful beating,
and that this beating can either ruin an
otherwise perfectly good round, or that the
bullet will do some pretty crazy things when
the point of it is bashed around. The
"Sabretip," wi th its thick jacket and a
nylon tip, combines mushrooming properties
and excellent ballistics of the SP bullet for
smooth functioning, yet it can be handled
just like a military load. The Sabre tip does
mushroom very well, and presently it is
available in '06, .300 Savage, .303, and .308
Winchester. We checked the accuracy of
the 180 grain '06 loads, and in our G&H
custom rifle, groups averaged a bit under 2"
at 100 yards from a solid rest.
C-I-L makes ammo for most of the stand-
ard calibers, and their .243 loads in the
super-accurate Winslow rifle, did as well as
some of the factory ammo we have tried
the gun with. The Canadian brass is boxer
primed and fully reloadable, and in six re-
loadings of the brass, I have not been able
to detect any metal changes, split necks, or
case head separation. Some sporting goods
stores are now stocking this imported ammo,
and C-I-L hopes to have complete distribu-
tion by the time the hunting season rolls
around once again.
The Daisy CO
2
200
This semi-automatic pistol, operated with
a Daisy C02 J ett cylinder, has several note-
worthy features. Let's take a look at some
of the gun's statistics. The Model 200 shoots
. 177 B.B.'s, the magazine holds 175 B.B.'s in
the main storage magazine, while the shoot-
ing magazine holds five .B.B.'s. With the C02
Jett cylinder in place, the gun weighs 26
oz., barrel length is 7lj2", over-all length of
the gun is 11%2 inches. The Patridge type
target rear sight is fully adjustable for
windage and elevation, while t he front sight
is an undercut ramp type sight. Since this
gun does qualify as a practice target gun, it
should be noted here t hat the sight radius
is 9% inches, that the trigger is fully grooved
and breaks cleanly at 3112 Ibs.
Daisy makes available a large and a small
Jett C02 cartridge, and in case you want to
use the small one, a special plastic adaptor
comes with gun. The B.B.'s have an average
velocity of about 400 fps, and the small J ett
will fire abont 100 B.B.' s, while t he large one
will fire about 150. Grips, and what normally
would be the slide in an automatic, are
made of pl astic, while the barrel is a seam-
less steel barrel. The entire styling of t he
Model 200 is that of a target pistol, right
down to the thumb rest stock. And-let me
add right now-the gun does shoot like a
target gun. First shooting was done from
15 feet, and once the gun was sighted in and
I was familiar with its operation, I backed
GUNS AUGUST 1964
off to the 25 foot line. Shooting from a rest,
the best five shot group measured exactly
%, of an inch, the worst group went 1112
inches, and I rather suspect that I pulled
one shot which then would account for the
vastly enlarged group. And even if this shot
was not yanked, accuracy is still excellent.
The gun retails for $17.95, complete with
B.B.'s and a J ett C02 cylinder.
Herrett's Shooting Stars
Steve Herrett, Box 741G, Twin Falls,
Idaho, has a new handgun stock, and he
dubbed it "Shooting Stars." We got one
for our snub-nosed Python, and before
putting them on the gun, we fired a cylinder-
full with the factory grips. Then swapped
grips, and fired another r ound. The differ-
ence was quite amazing, and the most
amazing thing is the fact that these are
not custom stocks. Steve has them for almost
all makes and models, and we showed our
gun with the Shooting Stars stocks to a
REMINGTON
$18
95
ROLLING BLOCKS
Cal. llMM
Acclaimed the World' s finest rifle in
1867. A prized "shooter" and collector's
item, also the ideal "decorator" for mantlepiece
or den. Made by Remington nearly a century ago, com
plete with cleaning rod. Shipping weight 12 lbs. over-
Only $18.95-add
MODEL 91 MANNLlCHER SPORTERS
ONLY
$19.95
A genuine Mauser, professionally converted
to a Mannlicher-type sporter. NRA Good Con
dition; it must be seen to be appreCiated. Add $2.00
for prepaid pp delivery.
MODEL 93 MAUSER SPORTER
$ J 6.50 .TlP
_ T: popular. lightweight sporter Is a real
bargain while hmited supply lasts. Cahber 7MM,
with turned down boIt and sling swivels. NRA Good
Condition. Add $2.00 for prepaid PP delivery.
BRAND NEW BARRELS-IN THE WHITE
E
NEW COMMERCIAL MANUFACTURE
ONLY
$14.95
pi us 8 0 ppd.
Made by one of the world' s largest
" Button Rifle" barrel "makers.
For MAUSER 98 in t he foll owi ng cal i bers :
. 2 64 WINCHESTER MAGNU M .30 8 WINCHESTER
. 270 WINCHESTER . 308 NORMA MAGNU M
. 243 WINCHES'"PER 3 006 SPRINGFIELD
7 MM REMI NGTON MAGNUM
Also a few bar rels t hreaded for SAKO a c t ions
in caliber .243 an:l ' .30 8 Win. same pr ice .
Button Ri fled Ne w Man ufacture Guarant eed
, NEW " BUTTON RIFLED" BARREL BLANKS
12 Groove. Outside diameter 1.125". Cal . 44 Barrel
Blanks Carbine (.44 Mag.) Length 183/4" . .... $ 7 . 50
(Add 80 for PP prepaid delivery)
Pistol (.44/40, etc. ) Length 9" ......... . ..... $ 4.50
(Add 40 for PI' prepaid delivery)
Cal . . 22 Barrel Blanks. Length 22" .. . .. . . . .... $3.95
(Add 40 for PP prepaid delivery)
FREE CATALOG
"Quick-Draw" Holsters
CUSTOM MADE
THE BEST
SINCE 1897
S. D. MYRES SADDLE CO.
P. O. BOX 9776
El PASO, TEXAS ZIP CODE 79988
JACKETED BULLETS, LOWER PRICES
Diameter Weight Type Retail Price
.337 200 grs FSP $6.25 per 100
.377 255 grs FSP $3.25 per 50
.405 260 grs FSP $3.50 per 50
.406 260 grs FSP $3.50 per 50
.407 200 grs FSP $3.25 per 50
.407 300 grs FSP $3. 50 per 50
.412 300 grs FSP $3.50 per 50
.429 200 grs FSP $3.00 per 50
.429 240 grs FSP $3. 25 per 50
.434 340 grs lEFP $3.50 per 50
.438 340 grs lEFP $3.50 per 50
.452 345 grs FSP $3.50 per 50
.456 300 grs FSP $3.50 per 50
FSP-Fl at Soft Point. for magazine rifles . LEFP-Long
Exposed Flat Soft PoInt. Send check or money order and
we will ship POSTPAID & INSURED in USA. DON'T
WAIT. If we do not receive anticipated volume, we shall
revert to the OLD Prices. 'Vrite for our fr ee brochure on
OBSOLETE CARTRIDGES, BULLETS and cross refer-
ence which lists rifle calibers, both US & METRIC in
which the above bullets may be used. OUR BULLETS
have been tested and ncclaimed by the EXPERTS.
Inspection procedure conforms to MIL STD #105-D &
MIL STU J't636.
CONNECTICUT CARTRIDGE CORPORATION
P. o. Box 354 G, Plainville, Conn.
EVERY GUN BOOK IN PRINT
UThe Bakor'. Dozen Plan"
Send SOc for year around bargain maillnp.
RAY RILING ARMS BOOKS CO
Dept. G, 6844 GorsleR SI. Philadelphia 19. Pa.
DUTCH BEAUMONT SHOTGUNS
Close out price only $12.95
Very rare 24-gauge Dutch Beaumont
military shotguns "as issued" to the
Royal Dutch and East Indies Armies in the
1870's. A single shot smooth bore, now about
90 years old. Overall length 52". Complete and func-
tional. Another prize collector/decorator item NRA good.
Now for only $ 12.95 . Add $2.00 for prepaid delivery.
Complete mechanically,
poor condition, but a real
bargain as 'decorator' or complete action.
Model 38 Arisaka rifle cal 6.5 One low close out
price $ 9 . 95. Add $2.00 for prepaid delivery.
MUZZLE BRAKE COMPENSATORS
tiIttt:.,
Altered for scope.
New condition
$3. 95. Include
40 postage. Is-
sue bolts 99
each + 40 post-
$3.95
93 & 95
MAUSER BOLTS
Light
weight
(alloy),
complete,
with fol-
l ower and fol
lower spring.
Fits '03 &' 03A3
Springfields, also '98 Mau-
sers; specify rifle.
I u. S. LEATHER SLINGS
== = ::f
I
BRAND"NEW! $2.50 each
Altered for scope. Excellent plus 25 parcel post. Can-
condition. Only $3.95 plus vas Slings, (excellent
40 postage.
75 pp.
WRITE FOR PRICE M-l CARBINE PARTS
LIST OF PARTS
Sling & oiler ....... . ...... $ 2 . 45
5-shot magazine .... . .. .. . $ 4.95
I5-shot magazine .. . .. . .. $1.95
Specify 93 or 95
ser; Japanese 6.5 or
7.7, Enfield No.1,
MK3; Krag 30/40. Adj . rear sight ... .. ...... . $2.45
LUGER FIRING PINS .................................... ea. $2.95
W POTOMAC ARMS CORP. P.O. Box 35-G Zero Prince St., Alexandria, Va. 22313
61
Guns MAGAZINE
THE BEST IN FIREARMS BOOKS
Order for yourself . .. gifts for your friends!
SMALL ARMS OF THE
WORLD by W. H. B. Smith.
Revised and enlarged by Joseph
E. Smith. The most authori -
tative reference ever pubUshed
on m!l!tary small arms. Spe-
cial emphasis on U.S. and
U.S.S.R. weapons. 711 pages,
more than 1700 !llustratlons
covering Identification, cali-
bers, ammunition, stripping,
assembly, safety and history.
$15.00
THE PISTOL SHOOTER'S
BOOK by Col , Charl es Askins.
A noted expert shares his
wealth of gun handling "sav-
vy" with you. A book that
will definitely aid you In be-
coming a better shot. perhaps
even a champion. Authorita ..
tive description of methods,
techniques, handguns of all
beginner and expert aUke.
$8.50
1964 GUN DIGEST edited by
John T. Amber,
World's finest gun authorities,
have again created a sparkling
collection of articles, facts, fig-
ures, illustrations and tables
on every facet of guns and
shooting. The only complete.
unique and up-to-the-minute
all domestic and Imported
guns and accessories.
$3.95
NEW! 2nd ANNUAL
HANDLOADER' S DIGEST
Edited by John T. Amber
Important 1964 manual for re-
loaders contains ABC's for rifle
and handgun. data on how to
start handloading, plus up-to-
the-minute articles by foremost
world authorities; new catalog
section lists components, books,
manuals, chronographs;. revised
data included in Case Dimension
Chart, Bullet Energy Table, Di.e
and Shell Holder Chart and MaXI-
mum Load Table'S.
$2.95
ENCYCLOPEDIA OF MODERN FIRE-
ARMS, edited by Bob Brownell
Over 1 600 exploded view Photos, blue-
prints, ' sketches, schematic drawings,
cutaway phOtos of ttlOusands of modem
American-made guns. The most compre-
hensive book of its kind ever published-
an indispensable guide for every avid
gun enthusiast. 1,066 pages.
Book bound . . ... . . . $20.00
THE FIREARMS HANDBOOK
Shelley Braverman's extensive catalog of obsolete gun
parts; guaranteed to fill your need.
$4.00
THE FIREARMS ENCYCLOPEDIA
famous "Pistol Atlas" and much morel
Now reduced to , $11 .25
CIVIL WAR GUNS by William B. Edwards.
A colorful and dramatic book for the Clvll War bulf
and arms man regardless of his specialty. Above all
It Is a story of America for all Americans. In 36 chap-
ters, 444 pages, this fasc!nating book brings you the
complete and exc!tlng story of all the guns used In the
Great War Between the States, Confederate and Fed-
eral. This is the first time such voluminous facts have
been brought together In one lucid, readable and un-
hurried volume.
$15.00
THE SHOTGUNNER' S BOOK
by Col . Charles Askins.
The complete picture on shot-
guns .. design, manufacture.
shooting form, ammunition ...
all in one neat package. Not a
more than 100 illustrations. A
"must" volume for the shotgUD
enthusiast.
$8.50
PISTOLS-A MODERN ENCY-
CLOPEDIA by Henry M. Steb-
bins with A. J. E. Shay and
o. R. Hammond.
$12.50
Special price for se' :
PISTOLS with RIFLES, A
MODERN ENCYCLOPEDIA
Two $12.50 books for $16.50
THE BOOK OF PISTOLS
AND REVOLVERS
by W. H. B. Smith,
$12.50
Special price for set:
BOOK OF RIFLES (W. H. 8.
Smith) and BOOK OF PIS-
TOLS AND REVOLVERS
Two $12.50 books for $16.50
CLIP COUPON AND MAIL TODAYI
Book Dept.
r
GUNS MAGAZINE, 8150 N. Cent rol Park Ave., Skokie, III. GBb
Enclosed Is $ In full payment for the books I have checked below. I understand you will pay postage.
Circle the books of your choi ce.
$15.00-SMALL ARMS OF THE WORLD
$ B.50-THE PISTOL SHOOTER' S BOOK
$ 3.95- 1964 GUN DIGEST
$ 2.95-HANDLOADER' S DIGEST, 2nd Ed.
$20.00-ENCYCLOPEDIA OF MODERN FIREARMS
$ 4.00-FIREARMS HANDBOOK
SAVE! SAVE! If you are
i
11.25-FIREARMS ENCYCLOPEDIA
15.00-CIVIL WAR GUNS
B.50-SKOTGUNNER'S BOOK
12.50-PISTOLS, A MODERN ENCYCLOPED IA
$16.50- WITI! RIFLES (Special Pri ce)
$12.50-BOOK OF PISTO.LS AND REVOLVERS
$16.5!1-"-WITH RIFLES (Special Price)
a member of SHOOTERS CLUB NAM.EIO _________________ _
62
OF AMERICA, write i n your
membership number and deduct
20% from list prices shown.
Save on your book purchases
-join the SHOOTERS CLUB
now! See ad in this issue.
ADDRESS, _ _ ____________ __ _
CITY _________ ZONE- STATt.E ___ _
Please allow 10 days for delivery
couple of the local handgunners. They all
like them, felt that they were comfortable,
and that the hand took less of a beating
from recoil than with the factory grips. And
the price is only $9.95 !
Savage-Anschutz Model 153
This is the first of the new Savage
Anschutz guns we received at GUNS Maga.
zine for testing, Chambered for the .222
Remington cartridge, the gun is very nicely
finished, has a U. S. style stock, but other.
wise closely resembles the Anschutz .222
that we reported on over a year ago. The
Model 153 has an adjustable, single stage
trigger that breaks at 3% Ibs. as the gun
comes from the factory. Hooded ramp front
sight with gold bead and fol ding leaf rear
sight are standard, and the receiver is
drilled and tapped for scope and peep sights,
but retains the slipon dovetail scope rails
of Anschutz design. The box magazine holds
three rounds and one round in the chamber,
and the overall appearance of the gun is
pleasing, The test gun, serial # 443323, has
the typical Anschutz safety at the left rear
of the bolt, a position that requires some
manipulating to get the safety off in a hurry.
The Model 153 weighs about 6% lbs. and
has an over-all length of 43" and a 24"
barrel.
Shooting with John Amber, editor of the
"Gun Digest," the gun was fi r st tested wi th
factory ammo, and then with handloads.
With Remington 50 grain bullets, I fir ed a
five shot group that measured 1
1
%6, but the
fifth shot was called, The first four shot
group measured 1%", while J ohn's group
went inch. With Sierra's 53 gr. BT,
HP Benchrest bullet and 24 gr. of Ball C,
Lot #2, groups averaged 1%" and J ohn's
best 4 shot group measured a scant 1%6
inch, Later tests wi th Federal's factory
ammo at 50 yards gave repeated 5 shot
groups that measured inch on an outdoor
range, and we understand that similar
groups have been fired on the Savage
indoor range repeatedly, The Model 153
is a handsome gun with inherent accuracy,
and the price tag of $175 is therefore
not unreasonable.
G-66 Products
The Jet-Aer Corporation has some new
items. Their G66 Gun Blue Paste has been
reported on previously in this column, but
now they have a new wrinkle in their
packaging, and one that we like a great
deal. This is a new plastic tube, and with
it, you can easily control how much of the
product you want to squeeze out. This is
the same bluing compound that we have
used for quite a while, and if you follow
the directions, you'll get a real fine job.
Really new is the G66 Spray Gun Sight
Black in the pocket-size aerosol can. This
won't harm the bluing on your gun, it can
be wiped off in a jiffy, and works so well
that we gave our old carbide lamp away. No
fuss, no muss, no bother-that aer o
sol Gun Sight Black does the trick.
SUPPORT THE U, S, OLYMPIC TEAM!
SEND CONTRIBUTIONS TO:
U, S, OLYMPIC ASSN., 57 PARK AVE.
NEW YORK, NEW YORK
GUNS AUGUST 1964
THE S&W AI MAGNUM-BALLISTICS REPORT
Smi th tr easur es his old S&W .44 Special
"Triple Lock" that ser ved him well. He says,
"It was made when S&W fitted and finished
guns better than any current gun in the
world." Today he generally uses a .357 for
hunting and defense. Cooper , who also used
a .44 Special for years, now uses a .357. " I t
takes big mule deer with one shot, bags
coyotes for bounties, and does everything a
r evolver shoul d do," accor ding to him. He
uses it for fas t and fancy exhibition shooting,
and a gr eat deal of varmint and game hunt-
ing. Another dedi cated handgunner , Caddy
McCall, who is associated with us in testing,
says a .357 is just right for any use a r evolver
is made for.
(Continued from page 18)
expands to a full inch.
Using 17.0 gr. AL8, we got a sever e sharp
crack, and seuled on 16.5 gr. with CCI 350
Magnum primers. Thi s starts at 1308 fps
f or 797 fp muzzle ener gy. Accuracy wasn't
as good as with 2400; perhaps because
velocity vari ati on was 128 fps.
Thou gh Bull seye sh oot s well with 4.0 to
5.5 gr. at 50 yards, too much gets errati c
pr onto and our most accurate l oad with this
bullet is 8.5 gr. Unique and CCI 350 Mag
num primer s, for 1108 fps. Maximum devia
ti on is only 16 fps. With superb accuracy and
569 fp muzzle energy, it's the most practi cal
cast bullet load. It holds accuracy to beyond
100 yards, and is adequate for everything
except game larger than most people hunt
with r evolvers.
For fine bl ack powder accuracy, use 26.0
gr. FFFg. I detest the messy stuff, and think
smokeless powder is a gr eat invention.
C H makes .410 semiwadcutter swaging
di es for their excellent SwagOMati c press,
and forming dies to draw .44 halfjackets to
.405. We used DIVCO .38 lead wire that
worked dandy, and because .210 gr. bull et s
gave a bit of leading, we settled on a 175
gr. These perform li ke a circus pony with
21.5 gr. 2400 and CCI 350 Magnum primers.
They start at 1521 fps for 898 fp muzzle
ener gy ! Vel ocity spr ead i s only 36 fps, the
most uniform HiV loa d we fi r ed, and well
within specs for "match" ammo.
The C H bullets are potent. Firing agai nst
a slab of r einfor ced concr ete cr eates a 5"
crater %" deep, as ' bullets destroy them
selves into fragments. Loads wer e even
mor e destruct ive after drilling the nose
deep with the Vs " dr ill in the Forster.Appelt
Holl ow Point Accessor y. Lacking a Cr uci
form P unch, that I designed for cutting an
X on bullet noses, I used a pocket kn i fe.
Potatoes tossed in the air simply explode
and disappear when hit with these bullets.
Back Lyman's .410 rou nd ball with 4.0 gr.
Bullseye for gallery loads. Lube l ead ball s
(or half jacketed bullet s) with Swagema.gic
Lube, which "dri es dry." It's made by G&Il,
Box 804, Nor th Ridge, Calif. Seat the balls
nearly flush with the case mouth and crimp
heavily. They print low, but are good for
cl ose range practice.
Shot loads for snakes or close aerial tar
gets, work well with 5.0 gr. Bullseye. Make a
. 405 wadeutter, and cut 7l, " felt wads. Seat
these with a dowel over a very thin card wad,
with about 15 pounds pressure. We fill ed the
cases nearly to the mout h with Illinois Cop
per plated shot to eliminate l eadi ng. Cut
over-sho t wads from milk carton; seat, crimp,
and seal with white glue.
For blank or wax bullet s, drill flash hol es
with a # 26 drill. File a flat on rims for
positive identi fication. And never use those
alter ed cases for regul ar loads.
For. smokeless blanks, use one-half of a
.30-06 GI Blank char ge. Press case mouths
against a very li ght card and seal li ghtly
with white glue. Blank Fire powder is not a
propellant and shoul d be used with caut ion.
I t will wr eck a gun with any type of bullet.
For black powder blanks, fi ll a case full of
FFFg and compress the light card wad,
GUNS AUGUST 1964
sealing as above. Use with care. For wax
loads, sharpen case mouths with a deburring
t ool, and press unprimed cases in %" thick
blocks of wax sold for this purpose. Best
accuracy is with CCI 350 Magnum primers,
though these loads lack the fine accuracy of
Speer's plasti c Target-38's which are not
available in .41 caliber. Be sure to clean
guns well after shooting wax bullets.
None of my law enforcement or gun-nutty
fri ends are enthused about a .41 Magnum.
My shooting buddy, Kenneth Shackelford,
expressed my views. Said Shack, "A .44 Mag-
num is best for game l ar ger than deer, and a
.357 is better for smaller game, varmints or
selfdefense. A Remington .221 Fireball with
a K-4 Weaver glass is far superior to any
r evolver for precision hits on varmints, game
or t ar gets at l ong range. The .41 Magnum is
good, bu t who needs one ?"
Exhibition shooter, D. L. Cooper, served
with the Border Patrol a nd the Highway
P atrol , is a dedi cated hand gunner and hand-
loader. So is ex-Deputy U. S. Marshall, R. B.
Smith, who served with distincti on. These
men have had 23 gunfi ghts in the line of
duty, and they won 'em all. Both have large
handgun batter ies, but they don't want a
.41 Magnum when the chips are down, or for
hunting.
Tell us t he make
and model of your shot -
gun or rif le .. type of stock or f orend
you want-semi-fini shed, 90% fi nished, st andard
An FBI Firearms Instructor says a .38
Special is ideal for pol ice ; officers need more
practice for gr eater effici ency. And they can
have i t on a limited budget with .38 Special
r eloads. The man behind the gun is far
more important than the caliber. A .38 shoots
completely through a man. That's excessive
penetration. Fast expanding hollow points
gr eatly increase the shock, and r educe pene-
tration and ricochets on city streets. They
are easily made with a Forster-Appel t Hollow
Point Accessory I desi gned for t heir excellent
case trimmer.
About all that I can add is this : I think
that we are getting t oo many slightly new
cal ibers, and most of us are not
shooting the older ones enough.
f ini shed or cust om f inished. We will send you l i t erature describi ng what we
offer f or your needs. Or, ask your deal er or gunsmi th, he al so can furni sh free catal og.
E. C. BISHOP & SON, Inc. WARSAW, MO. , U.S.A. Dept.
ATLAS ARMS GuBs of Quality
in 12 & 20 Ga. ONLY
Over & Under s ho t gun w ith Holl and & Holl and s ide pl ates
-Merkel t ype action a nd locks- F ull Vent . l tib-Au to
$ 6 7 5
-Super chrome lined bores-Fine ski p - li n e checkcl'cd and UP
walnut pistol or str aigh t stock, w i th f itted recoil pad,
ATLAS MODEL
145 in 12, 16 & 20 Ga
ATLAS MODEL
750 in .12, 16 & 20 Ga.
Over & UndC1' S h otgun wit.h Me rkel Type
Ac tion-Full y h and engrave d-De tachhble s id e
p late s-Ven ti l ated rib--Sin,gl e NON Sele c t ive t rigger
-Standard extractors-B\ll'l'els nHide of n lckcl Chl"Ollle
stccl-Supcr ch rome lined chc<.'k<'l'i n g
\ Va l n ut, P istol 01' straight stock _ ch ambcrs for
(. 2 0/.1/1 shclls.
OTHER AVAILABLE MODELS
ATLAS MODEL 65 - 0 & U - Ga. 28 and 410- D , Triggcl'S $ 1 80
AT LAS MODEL 65 / S" .. " - " 28 & 4 10-S.Non, Se1.Trig. $ 1 98
ATLAS :MODEL 8 7 " .. " - .. 12, 1 6, 20- S .:-.ron.SeI. Tr ig . $210
ATLAS MODE L 9 5 " - .. 1 2. 16. 20-S.Non.Sc1. Tri g . $ 2 20
ATLAS MODEL 2 00 S b y S - Ga . 16. 12, 2 0, 4 10 - 0. Tr ig . $ 160
ATLAS MODEL 208 .. .. t , - .. 12, 16, 20-Mag.-D. T ri g. $ 1 65
ATLAS MODEL 500 " " .. - .. 10, 1 2 . 2 0 - Ma g- ,-D. T ri g. $ I 9n
ATLAS MODEL 800 ...... - .. 1 2 , 20- Mag. S . Non- S .Trig . $240
ATLAS ARMS, INC.
2704 N. Central Ave., Chicago, 111.60639
COMPLETE LINE OF FOREIGN
A UTO PISTOL MAGAZINES
FOREIGN AUTO PS ITOL
FIRING PINS
Also ava il abl e for : Wi nch est er Mod .
12 ga, 1 2 - 1 6 ; Marlin MOd . 336;
Wi n cheste r Mod . 04; Hemington
.22 Mod . 12; S pringfield 45-70
MOd. 187 0.
G UNSM ITHING TOOLS & PA RTS
Shotgun Reamers, Sho t gun chokes,
Gauges, S h o t g un Dent Removc!' !; ,
S h o t g u n Metr ic system Tap & Dies,
ShotgUn V , typc ll1ain spri ngs,
S h otgun V. type l ever spr ings.
Comple t e l i ne o f parts f o r:
Automatic p is to ls Hcr nardc lli-Bc r
e t.ta- Armi Galcsi-Luger and r cpro
duction Mod e l!'; and ARMY.
::
PARKER & L. C. SMITH BARRELS
Ma de o f Eng li s h Vicke r s stee l Se m i-
fi n is h 9 0 0/ 0 fitte d, Gauges : 1 2 16- 20
Ba r rel s : 2 6"- 2 8"- 30", Chalnbcr s:
23/4 " r egu l a l' !'; h e ll s, Standard ex-
t ractors $ 70.00, Auto ejectors
$80.00, F i tti ng & Dluing chargcs
$ 35. 00.
Dea ler I nq ui ri e s I nv ited
63
THE GUN MARKET
Classified ads, 20c per word insertion including name and address. Payable
in advance. Minimum ad 10 words. Closing date October 1964 issue (on
sal e August 25) is July 7. Print ad carefully and mail to GUNS MAGAZINE,
8150 North Central Park Blvd., Skokie, III.
BINOCULARS, SCOPES & SIGHTS
SCOl.)E 1\fOUN'.rS-Brochure 19G will help yOU select the
IJroper mount tor your scope and riOe. Write Maynard
Buehler I nc . Orinda. Calif.
BINOCULAR SPECI ALIS'l'S. All makes repaired. Author-
Ized Bausch & Lomb. Zeiss, Hensoldt. Bushnell dealer.
Tele-Opti cs , 5514 Lawrence. Chicago, Illinois 60630.
BOOKS
ADDllESS COLONEL NEY for his NOTES on GUER-
RILLA WAll. $3.50 postpaid. Box 6303. N.W. Station.
Washington, D.C 20015.
LUGEll COLLECTORS. shooters. dealers. Illustrated
Ident.ification Key to 103 Luger variations. Easy. accurate.
First edition. $2.00 pod.1\:[. B. M:ittleman, Box 266G.
Saugatuck 8ta .. Westport. Conn.
CAUBTNE MANUALS! Copyrighted revision of Army &
AF Technical & li'icld Manuals. over 170 pages, 120 illus-
trations. 124 major topics. l{ugged manual binding. 6"x9".
Covers every aspect of use & rebuilding of all models .30
carbine. Published @ $3.98, special sale only $2.98. Nor -
mount armament. Box 21lCBGU. Forestgrove, Oregon.
Dealers inquire.
CAMPINC EQUIPMENT
SLEEPING BaGS. 100 styles; tent-camping equipment
specialist. Send for 96 page catalogue. Morsan, 810-T,
u.oute 17. Paramus. New J ersey.
COLLECTORS
NEW COLLECTOR SERVICE-Rare military books. man-
uals. war relics. weapons. uniforms. helmets.
medals. isnsignia. documents. photos. paintIngs. pr1Ots.
44 Page Illustrated Catalogue 50 refundable with pur -
chase. Peter HUnka. Historical amer icana. Dept. G, 226
East 89th Street. N. Y .. N.Y. 10028.
CIVIL WAR and Custer Period Relics. List 15. Thomp-
son's, Box 164. Havelock. North Carolina.
It'ULJ.J SI::E working model 1842 percussion pistol. All
working parts precision machined fr om steel. Side plates
solid brass. Gun comes completely assembled and working.
YOli flnish sanding stock, polish and blue parts. Comillete
$10.00 Postpaid. Stanley Morgan. Box 61, Warehouse
oint. Conn.
KENNEDY MEMENTOS. coins, medals . coat-of-arms
jewelry. Free catalog. Insignias. Box 71. Rockaway 94, N.Y.
ENGRAVING
ffiNGHAVING BY PHUDHOMME. Folder $1.00. 302
'Yard Building. Shreveport, LouiSiana.
fiSHING & HUNTING
COLLAPsmLE FaRM-Pond-Fish-Traps; Animal traps.
Postpaid. Shawnee. 39342 Buena Vista. Dallas 4. Texas
fOR SALE
CANNON FUSE 3/32" dia . waterproof. burns under
water ; 10 ft .. $1; 25 It . $2. ppd. Wllliam Zeller. Kell
Hwy., Hudson, Mich.
PISTOL LAvVS. Booklet descr ibing current pi stol
r egulalions of all states $1.00. ll'ederal Gun Laws Booklet
$1.00. Henry SchleSinger, 415 East 52nd St. , New York
22E. N.Y.
ATTENTION-COLLECTORS & SHOOTEItS: U.S. M1
Garand HHle Cal. 30-06, :Perfect-$19.95. U.S. 1\:9
Cal. 30, Original, Excel.-$69.95. U.S. Mod. 1903 Spnnl!.-
fi eld 1Ufles. Cal. 30-06, Hi gh Numbers. V.G.- $39.90.
Excel. - $44.95, Low Numbers. V.G.-S29.95. U. S. 1't10d.
1903A3 Springfield Rifies, Cal. 30-06. V. G.-$42.95. 1'er-
fect- $49.95. U.S. Mod. 1917 Enfield Rillles. Cal. 30-06.
V.G.-$29.95; Select \ Vinchester or Remlngton-$34.95.
Brit. Lee-Enfield #1 MK III Rifles. Cal. 303. V.G. -
$14.H5. Bril. Lee-Enfield #4 MK. I RiOes. Cal. 303. V.G.-
$18.95. Brit. Lee-Enfield #5 Jungle Carbine, Cal. 303,
V.G.-$24.95. Brit. Pat. 14 Enfield Rift es. Cal. 303. V.G.
-$19. 95. German Kar 98 K Mauser Rifles, Cal. 8mm. V. G.
-$2995 ' Select-$34.95. German :Hod. 11/84 Mauser
lUHcs', Cal. llmm. Good- $18.95. Hungarian Mod. 43:M:
Mannlicher Rifles. Cal. 8mm Mauser, V. G.-$34.95. Rus
sian Mod. 91/30 Moisin lUfi es, Ca l. 7.62, Good-$9.95,
V.G.-$12.95. U.ussian Mod. 38 Moisin Carbines, Cal.
7.62. V. Q. -$19.95. nussian Mod. 1940 Tokarev Semi -Auto
Rifles, Cal. 7.62. V. G.-$34.95; Select-$39.95. lt ussian
Mod. 1938 Tokarev Semi -Auto Rifles, Cal. 1.62. V.G.-
1943 (98) Mauser Hi fles. Cal. 8mm. Excel.-$34.95. Bra-
zilian Mod. 1908 (98) Mauser Short Rifles. Cal. 7mm.
Good or Better- $39.95. Persian Mod. 98/29 Mauser Car-
bines. Cal. 8mm, V.G. - $34.!l5; Select-$39.95. Persian
1\1od. 1951 Mauser Carbines , Cal. 8mm, V.G.-$34.95; Per-
fect- $49.95. Ital. Mad. 91 Carcano Rifles. Cal. 6.5mm.
Good- $9.95. Ital. Mod. 3S Carcano Rifl es, Cal. 6.5mm,
V.G.-$14.95. French Mod. 1916 Mannlicher Berthier
Rifles, Cal. 8mm, Good-$9.95. French Mad. 1908/15 Mann-
Hcher Berthier Rifles, Cal. 8mm, V.G.-$9.95. German
Mod. 98/40 Short Rifles, Cal. 8mm, V.G.-$34.95. German
Kar 98T{ Mauser Rifles. Cal. 8mm. V.G.-$49. 95. Argen-
tine Mod. 1891 :\:fauser Rifles. Cal. 7.65mm. Excel.-$19.95.
French Mod. 1886 Lebel Rifles, Cal. 8mm. Good-$15.95.
Czech Kar 98f( , Vinter Trigger Guard :Mauser Rifle. CuI.
Smm. V. G.-$26.95; Excel. - $31.95. Swiss Mod. 1911
Schmidt-Rubin Rifles. Cal. 1.5mm, V.G.-$14.95; Excel. -
$16.95. Peruvian Mod. 1909 (98) Mauser Rifles, Cal. 1.65.
Good- $24.95; V.G.-$29.95; Excel.-$34.95. German Gew
98 'VWI Mauser Rifles, Cal. 8mm, Fair-$24.95; Good
-$29.95. Dominican Republic Mod. 98 ) 'Iauser Long
Rifle. Cal. 7mm. Excel. - $59.95. Dominican Republic MOd.
98 Mauser Short Rifle. Cal. 7mm. Excel. - $64.95. Deal ers
I nquire. Send 25 for Retail List. AU prices FOB N.Y .
$1. 50 J)rel)ays any gun, $2.50 west of :M1ssissi pp1. 5-day
money back guar antee if returned prepaid in same con(U-
tion as shiooed. Globe Firearms. 30 Front St. , New York
4. N.Y.
64
GUNS & AMMUNITION
WINCHESTERS, COLTS, LUGERS plus many others.
Send 10 for I8-page li st. Chet Fulmer, Rte. 3, DetrOit
Lakes. Minnesota.
ATTEN'I'ION! M-l 30 Cal. Carbines Brand Newl New
:Manufacture complete and shipped postpai d-$14.50. Peru-
vian M35 30-06 cal. F.N. 'Mauser. like new-$49.50. Per-
sian M98 8mm Mauser Carbine. V.G. - $3S.50. Factory
New-$49.95. Order Now. Supply Limiled. Continental
Arms Ltd .. Box 72. Staten Island, N.Y. 10310.
NEW MATCH AUt RIFLES & Ammunition from
Europe; up to 750 fps. Tremendous accuracy. Walther.
Bavaria. Anschutz. others. Sample Ammunition. 40 page
Catalog Free. Air Rifle Headquarters. 132 Market. Grants-
ville. lV. Va. 26147.
U. S. 30-06 high number Spri ngfield rifles. Very Good-
$39.95. Excellent-$44.95. Perfect- $49. 50. U.S. 30-06 low
number Springfield rifles. Very good-$29.95. Excellent-
$34.95. U.S. 30-06 Enfield rifles. Very good-$29.95. Ex-
cellent-$34.50. U.S. M1 30 cal. carbines. Like new-
$69. 95. U.S. M1 30-06 Garand rlfies. Like new-$89.95.
British Mk. 3 303 rifles. Very good-$14.95. Like new-
$24.95. British Mk. 4303 rifles. Very good- $lS.95. British
l\Ik. 5 303 jungle carbi nes. Very good- $24.95. Spanish
Mod. 93 7mm )1auser carbines. Very good- $19.D5. Spanish
Mod. 1953 8mm Mauser rifles. Brand New-$34.95. Argen-
tine Mod. 91 7.65mm Mauser r ifles. Very good-$19.95.
Like New-$24.50. Peruvian Mod. 1909 7. 65mm }.fauser
rHies. Fair - $2'1.95. Good - $29.95. Excellent - $39.95.
lJoeruvian Mod. 1935 30-06 Mauser ritles. Very good-
$49.95. German 98 8mm Mauser rifles. Very good-
$29. 95. German :Mod. 1811/84 11mm Mauser rifles. Good-
$18. 95. Czech Mod. 98 8mm rifles. Perfect-$29.95.
nussian Mod. 91 7.62mm riOes. Good-$9.95. Very
7.62mm Tokare,' semi -automatic rifles. Good-$34.95. Very
good-$39.95. Excellent-$44.95. Italian :MOd. 91 6.5mm
l\fannlicher-Carcano rifles. Good-$9.95. Very good-$12.95.
Italian MOd. 1938 6.5mm & 7.35mm Mannlicher-Carcano
carbines. Very good-$14.95. French Mod. 1916 8mm Lebel
rIfles. Good-$9.95. Very good-$12. 95. ll'rench l\Iod. 1886
8mm Lebel rifles. Good- $l5.95. Swiss Mod. 1911 7.5mm
Schmidt-Rubi n rifles. Good-$13.95. Very good-$16.95.
HO-06. 303 British, 1mm Mauser. 7.65mm Mauser. 8mm
Mauser. 7.62mm Russian. 1.35mm Italian military ammu-
nition at $7.50 per 100 rds. Free gun li st. Dealers inquiries
invited. Freedland Arms Co . 34 Park ltew, New York
3S. N.Y.
GUNS. BUY ' VHOLESALE. Become a Dealer. Complete
instructions $1.00. Maillrade. Capitola, Calif.
GUN AND Gun Parts illustrated catalog. Springfields.
l\-:I"ausers. Mortars. BaZOOkas. etc . . 50. Springfield Sporters.
Inc .. RDl. Penn Runn, Penna.
SURPLUS MILITARY CARBINES $17. 50. Pistols $12.50.
Rifles $10.00. Bargain Catalog 25. Armsco, Box 44-E1.
Santa Cruz.
H rAVY" .36 Cal. Revolvers Only $34.95. Copper Flasks
$10.50. All Shipments Prepaid. Free Catalog. Walt's
\Veapons, Box 368. Avondale. Arizona.
CUSTO:\! 03-30/ 06 Springfield Rifl es-Engraving-Bro-
chure & Color $1.00. Brochure . 25t. Springfield Custom
Guns. 449 E. 14 St. 4H-115. New York 9. N.Y.
SURPLUS RIFLES $3.50. PIstols $4. 00. Guns Below
Wholesale you can buy. Learn.How! $1.00. Mailmart. Box
1129-E1. Los Gatos. Callf.
SURPLUS N.R.A. U. S. Carbines Owner s ... Here's How
You Can Make An Accurate. Useable Sporter Out of Your
M1 ... Have Mel Johnson Converl Your M1 into his
famous MMJ 5.1 Spitfire! J For complete details write,
lt1el .Johnson. Dept. SG. Johnson Guns. Inc. , 60 Connolly
Hamden, Conn.
SURPLUS RIFLES $3.50. Pistols $4.00. Guns you can
buY below wholesalc. Become dealer. Complete instructions
$1.00. i\1ailtrade. 171-El. Capitola, Calif.
SILENCERS: MAXIM and O.S. S. MOdels. Complete de-
tails of construction and operation with pictures and draw-
ings. $1.00. Gunsco. B-313-E1. Soquel. Calif.
SILENCERS : MAXIM and O.S.S. mOdels. Latest illus-
trated details with pictures and drawings $1.00.
Box 44-El, Santa Cruz. Calif.
HUNTERS. RIFLE RACK for J eeps, trucks, etc. New U. S.
Government Surplus. $6.95 plus postage. Write. Chuchua,
1695 S. Harbor. Fullerton 11, Calif.
CHURCHILL (GUNMAKERS) LTD. World famous gun-
smiths. Models from $390. 00 to $2,000. Send $1. 00 to
32 Orange Street. London, \-V. C. 2. for li sts of new and
used shotguns.
KLETN'S BIG All-Sports Bargain Cash or Credit Catalog
now Free. Klein's, Dept. G, 221 \-V. 'Washington. Chicago 6.
PREPAID. 38 Special Western WC nickel cases, once
Reloading Service, 105
JO.OOO GUN BARGAINS 1 1 1 Modern-Antique Guns. Ac-
cessories-Giant Bargain Catalog 50;. Agramonte' s. Yon-
kers. N. Y.
CASES O'NCE FIRED Postpaid 30.40' 30.06
- 308 - 30.30 - 32W - 300S - 35R - 358 - 8mm _
38Speeial - ilOCarblne :-" 45ACP - 223R - (Formed _
7.7Jap - 7.60 7mm - 257R - 244 - 243 - 22. 250 -
250S - 222R - 6.5x55) Others. RlIle 6t - Pistol _
(. Carbine - Shots hell 2 - Micaroni, 65 Taylor, East
Meadow. N.Y.
KENTUCKY RIFLES. Custom )-Iade. Send self addressed
stamped envelope for folder. Mark Matteson, Randall, N.Y.
YELLOvV 1964 of rifies, handguns.
2o. Rotting, 11029 Washington. Culver
GUNS WANTED. ANY TYPE Regardless of Condition-
Buy, sell. trade, repair; Antique & 1't1odern. Biehler' S Gun
Iteom, 1585 Bergen Blvd., Leonia. lew .Tersey.
EVERy'.rHING F OR the muzzle loading shooter. 'We have
aU the reproductions. 'I' rades invited. The :Muzzle Loader,
Merrimack, N.H.
11 PIECE MOUNTED Gun Collection: Rifi es. pistol s, Bub-
machine gun. Scale replicas World's Most Famous It' i re-
arms. All Shoot (harmless). Personalized engraved owner 's
nameil late. Enviable, fa scinating. educational gift ; den.
elsewhere. Remarkably pri ced. Free il1ustrated information.
Faron International. 7065J1 \-Valbrook Station. Baltimore
16. Maryland.
4.000 CAllTlUDGES FOR COLLECTORS: 88 page illus-
trated Catalog #4, 50t . James Tillinghast, Box 547. Mar-
low, N.H. 03456.
GUN EQUIPMENT
NEW 45-iO Cal. Springfield barrels with action. Model
1873. $25.00. 2 piece Sharps and Spencer Carbine srocks
$15.00 ea. U. S. Army. Cavalry helmets. 1880 style. $8.50.
Fine Franch saw LOath sword bayonets and scabbards.
$8.50 ea. POSlage Extra. ' V. Stokes Kirk, 3429 German-
town A'-e .. :PhUa . . Pa. 19140.
ADJUSTABLE TRIGGERS $3.50. Adjusts for sear depth
and trigger lhrow. Used by thousands. Can be installed in
minutes by anyone. Highly polished. For Mauser models
93, 94. 95, 96, 98. G33-40. G33-50; Springfield, 03. 03A3.
03A4; Jap Arisakas 6.5 and 7.7; Enfields 1914-1917 and
Lee Enfields 3, 4 and 5. D. E. Hines. 1l035-C Maplefield,
El Monte. Calif.
OVETt 50 ASSORTED SCHE\VS. pins. springs, et c. for
faster gun repair, no two alike. $2.50 postpaid. Over land's
Supply. Independence. I owa.
SILENCERS! PISTOL. B.IFLE ! Compact . effici ent attach-
ment. Aclual cooyrighted plans. plus background informa-
tion- no gypo mimeo sheets; satiisfaction or refund. $1.50
postpaid. Service Sales. Dept. GU. Box 889. Seattle,
\Vashington 98111.
GUNSMITHING
GENERAL GUNSMITHING-Repairing. rebluing. con-
version work, par ts made. I nqui r ies invited. Bald Rock Gun
Shop. Berry Creek. Calif.
GUNS)UTHING-Learn profitable hobby. Build .22
PistOl. Campers Pistol, Gun Cabinets. Blue Guns. 5c Slamp
brings illustrated information. Guns, Postoffice Box 362-G.
Terre Haute, Indiana 47S08.
FINE CUSTO),1 Rifles made to your speCifications. 1\111-
tary rifies rebuilt. Blu-Blak bluing. new barrels fitted.
Chambering for standard. improved and \-Vildcat cartridges
including Weather by line, 308 Norma, new 300 and 284
Winchester. Model 92 'Vi nchester conversions to 256. 357.
and 44 Magnums Write: Don Mott , Box 347. Douglas.
Ari?.ona.
CUSTOM STOCKING-fancy. select grades of wood. Spe-
cialist in Trap. Skeet. Target stock fitting. 1')lain and
fancy checkering. Limited Gun Service. 163A Lincoln St .
Jersey City, N. J.
SPRINGFIELD, ENFIELD, )1AUSER. and Jap Owners.
eliminate trigger slack. I mproved trigger letoff I nstall a
Cougar Anti-Slack trigger and Sear boot. Installs easily
No drilling or tapping. Hardened. tempered, and contact
surfaces micro flnished. Specify rifle. Sent postpaid with
complete instructions. 51.00. Dealers wanted. Cougar and
Hunter. 5070 Tahquamenon. Flushing. Michigan.
ALTEU. & JE\VEL bolts $8.50. Springfields, Enflelds al-
tered to 308 Norma Magnum $12.00; Enfields to 300 'Veath-
erby $24.00; 7.7 Japs to 30-06 $6.00; 300 Magnum to 300
\Veatherby $8.00. Catalog 10 cents. T-P Shop. 12 West
Branch. Mich.
GUNSTOCKS
CUSTOM STOCKS precision-machined from your bl ank or
our Fancy Yamawood. Mesquite or Walnut. Longarini,
Dana :Point. California.
INDIAN RELICS
PO'!"I'ERY, Axes. Arrowheads. 10 for
$3.00. List Free. Hydes. Rosemar Road. Parkersburg,
W. Va.
INVESTIGATORS
INVESTIGATORS. FREE Brochure. latest subminialure
electronic listening devices. Write Ace, Dept-8X. 11500
NW 7th Ave .. Miami 50. Florida.
LEATHERCRAFT
FREE "Do-It-Yoursel f" Leathercraft Catalog. Tandy
Leather Company, Box 191-P52, Fort Worth. Texas.
METAL DETECTORS
TUEAsunE, GOLD, SILVER, nELICS. Find them with
new 1964 models. Free information. Raytron. Dept. 8-D.
Box 715. North Hollywood. California.
MISCELLANEOUS
CROSSBOWS for Target. Hunting and Carp-Shooting.
Faetory-Direct-Prices. Jay Co. Box 1355. Wichita. Kans8I.
NAZI ITEMS bought & sold, or ig. only, 1 piece or col-
lection: "Usts 25c": Lenke!. 812 Anderson. Palisades. N. J.
YOUR OWN Business Without Investment! Sell adver-
tisi ng matchbooks to local businesses. No experience
needed-tree sales kit tells how and where to get orders.
Part or full time. Big cash commissions. Match Corpora-
tion of America. Dept. GE-84. Chicago 32.
GOVEUKMENT LAXD now available in 25 States.
450. 000. 000 acres low as $1.00 acre. Exclusive copyrighted
report! Send $1.00 to U.S. Land Disposal. Box 18177-GU.
I ndianapolis 18. Indiana.
PRECISION MAP MEASURER a must for vacaUoners,
yachtsmen. spor tsmen and pilots. By merely tracing your
route. you know the distance to your destination imme-
d iately. Cali brated to measure statute miles, nautical miles
and kilometer s. Satisfacti on guaranteed. $2.95 to Michael' s
Company, 304 Almond. Amarillo, Texas.
GUNS AUGUST 1964
HOPPE'S GUN BLUE
for good gun care
Deep-penetrating Hoppe's Gun Blue
allows color matching of any gun
barrel and will restore original
finish without rubbing. Not a paint,
not affected by solvents, excellent
for touch-up. 2-oz. bottle, $1.00,
includes steel wool, directions. At
better sporting goods dealers. If
dealer cannot supply, send $1.00
plus 25 for postage to factory.
FRANK A. HOPPE. lnc.
2352 Nort h 8t h St., Phila. 33, Pa.
SPEER
Cross Pi s tol s
Riflem.a n
$1.00 each
Metal design on mother-of
p earl base. Solid brass tipped
KOKEWAN KOMPANY
Box 674. Chicago, III . 6069 0
SHOOTING GLASSES
Used by marksmen and
hunters to get c lear
s harp vision on target.
FREE li t er ature on
Shooting , Vision and
informa t io n on Pre
script ion shooting glas
ses. Write di rect to-
Mitchell Shooting Glasses
Box 5806, Waynesville, Mo.
MEN- SHOP By Mail! 18 di sposable silicone-treateq car
polishing cloths, also good on guns, $1.00. Preclsion
Pedometer. scores to 100 miles. $7.79. Telephone shoulder
rest. $1.59. Bathtub safety rail, modern tubs only, $4.98.
Set of 6 safety plug locks to protect children. $2.00. Send
4 stamp for "mother and baby" gift catalog. Kaye Hall.
Franklinvi lle. N.Y.
TIME TRIED TECHNIQUE for self treatment of piles.
Folder in plai n envelope $1.00. Boyer, Box 892. Tupelo,
Miss.
FREE! Big 152-page Summer catalog. Top values coast to
coast 25 states! Farms, Ranches. Homes. Businesses,
'Vate'rrront. Recreation, Retirement properties .. United
Farm Agency. 612-liG West 47th St . Kansas CIty. Mo.
64112.
STOMACH ULCER cure quickly heals. Eaton. Box 543-U,
Hopland. California.
PATIO TABLES! Bird Baths! Made for pennies. No
ber or Aluminum 'Molds. Pattern $2.00. Black Canyon
Enterprise, Box 218, G-8. Black Canyon. Ariz. 85324.
SUPEUSENSITIVE Treasure Finder lo-
cates buried gold, silver. ancient firearms, coins. $19.95 up.
Free catalog. Relco--.A6. Box 10563. Houston 18. Texas.
RELOADING EQUIPMENT
FREE CATALOG. 208 Pages . Save on Reloading Equip
ment, CaUs, Decoys , Archery, Fishing Tackle, Molds.
':[10018. Rod Blanks. Finnysports (S8). Toledo 14, Ohio.
SCHOOLS
MI SSOURI AUCTION SCHOOL. Free catalog! 1330- 102
Linwood. Kansas City. Mo. 64109.
TAXIDERMIST
RUG SALE : Open Mouth Black Bear. 5 feet $135.00.
BOb- Cat $55.00. Tiger. Polar Bear . Leopar d, Zebr a, Puma,
Timber Wolf. We tan hides, furs. Hofmann- Taxider mist.
I a25 Gates. Brooklyn, N. Y. 11221.
GUNS AUGUST 1964
THE "P ARABELLUM"
AUTOMATIC PISTOL
(Deutsche WafJen und Munitions/abriken,
Distributed by Stoeger Arms Corp.,
South Hackensack, N.J. $1.00)
This little volume contains not only the
complete loading, stripping, and firing in-
structions for the Luger, but also offers some
interesting historical sidelights of the Luger
automatic in the United States and the deal-
ing of Stoeger's with the German concerns
who exported the Lugers to America. The
instructions are translated from the Gennan,
but are the same as those issued with the
original German non-military models. If you
are a Luger owner, collector, or just like to
learn something about this gun, then this
booklet should be in your library. -R.A.S.
HANDLOADER'S DIGEST, 2nd EDITION
Editor J ohn T. Amber
(Gun Digest Assoc., 4540 W est Madison,
Chicago, Ill., 1964. $2.95)
Vastly improved and much better organized
than the first edition, this 228 page volume
should be on or near your l oading bench at
all times. The articles, there are 25 of them,
are by the top authorities in the field, and
a great many new tables have been added for
your benefit. The equipment section is com-
pletely new and editor Amber rearranged
it to make it more useful and convenient. Get
your copy of the book soon, it promises to be
a sell-out in no time at all.-R.A.s.
HUNTING DUCKS AND GEESE
By Edward C. J anes
( The Stackpole Co., Harrisburg, Pa.,
1964. $5.95)
Edward C. J anes-better known as Ted
Janes of "Outdoor Life,"-has probahly for-
gotten more about duck and geese hunting
t han most of us can hope to learn in two
lifetimes. If you ever hope to hunt ducks and
geese, if you think you have all t he know.how
for this spor t, I'd suggest you get this book
and learn a few thi ngs- I know I have
learned quite a bit, and the only thing Ted
does not tell you is how to avoid bluebird
days. This is the best buy in duck hunting
books now on the market.- R.A.s.
REBELLIOUS RANGER
By W. J. Hughes
(University 0/ Oklahoma Press, Norman,
Okla., 1964. $5.95)
J ohn Salmon Ford came to Texas in 1863,
and began illustrious car eer which helped
shape the destiny of. that great -state. "Rip"
Ford, as he was known' in the dime novels,
remained a prominent figure in the political
and social structure of Texas until his death
in 1897.
Here is biography that is every bit as
exciting as the character it portr ays ; a biog-
raphy that is sure to become an important
part of the historical writings
of the great Southwest.-J.R.
DELUXE .22 Cal. REVOLVER
Pre.isiolt
made
6 - shot
5" revolver by Europe's
finest gunsmi ths. Pol
ishod blue steel. REAL .
NOT A BLANK. Fi res .22-cal.
short ammo. Side gate loading.
screw i n ejector rod. For pl ink-
ing, practice or protection. 10
day money-back guarantee. State
age when ordering. No C. O. D.s,
please. Shi pped F. O.B. Chicago, ex
press charges collect. Send cash, check
or money order t o:
GLOBAL IMPORT DEPT .10-1
7017 N. RAVENSWOOD, CHICAGO,
mui1!I1
PISTOL CARTRIDGE DIES
USERS REPORT OVER 1,000 ,000 GUARANTEED fOR 200,000
lONG LIFE NO SCRATCHING NO GAlLING
MANUfACTURED 8'1'
'Z)(e & ?!fh. (J4.
C!M!NTED CARBIO! CARBOLOY (UAD[ MARKI
P. O. BOX 226 COVINA, CALIF.
IMPROVE YOUR SHOOTING
I PS_ ...
Famous FRANZI TE Grips, made by Sports. Inc.,
are handsome, unbreakable, i nexpensive. 400
sizes in 7 colors. New catalog shows latest
designs for almost any gun made- Colt. Smitb
& Wesson, Luger, Ortgies. Mau ..
ser, etc. Ivory, pearl, walnut. onyx, Agate,
SPORTS,
GUN METAL
NOW MADE NEW!
-blueing gives new beauty,
natural protection!
'=======-=8t.tl. --, __ _
65
BRAND NEW! ARMY TYPE
CAMPAIGN HATS
Fine on f elt,
c o m pl ete with
l ea the r c hin
strap. Worn by
riflem en ever y
wh er e ! Sp ecify
any size.
Greatest Surplus Store!
THE OUTLET STORE
Dept. GM, 1800 Stout St., Denver 2, Colo.
DEALERS INQUIRE
Join other interested citizens to aid professional police to stop crime. It will stop
when the odds are against them. Associate membership open in this non.p.rofit
organization. Your money, property and loved ones .will be and you adll}lred.
Join today, or send for the FREE full story without obhgatl.on.
ASSOCIATION Of AUXILIARY POLICE, Police Hall of Fame, Vemce, Florida. 33595
MAIL COUPON TODAy
: IMP - Dept. C Police Hall of Fame, Venice, 335
B
95 :
'{ 1 $5.00 enclosed . send official membership kit I ,
: with ID Card, Car Emblem and magazine.
( ) Send Full Story FREE.
: NAME AGE -- Associate membership
ADDRESS
: CITY ZONE _ STATE _ _
........................................
IN PHOENIX KIDS LEARN TO SHOOT
(Continued from page 27 )
expl anation of the cour se that is to be taught.
Everyone, parents and students alike, are
addressed by an expert : on the basic rights
of every American to own, possess and bear
arms as provided for in our Bill of Rights;
the reasons for every American to know how
to handl e firearms; the nomenclature of fire-
arms, etc. The course is divided into 8 weeks,
with one night of instruction each week.
Students must first pass "paper work" and
"tests" on t he lect ures given preliminary to
actual range instruction. After they success-
fully pass these, they proceed to the firing
range, where they receive inst ruction in
shooting, and take field t rips, where advance
instruction in gun handling safety is given.
When the student has completed the course
and successfully passed all tests, he is
awarded a diploma.
The success of the program has been
astounding. All courses have been over-
subscribed every season and so many more
M
osse"l SHOTGUNS
for accuracy FEATURE
SAFETY ON TOP
"RIGHT UNDER YOUR THUMB"
f or free write Department A,
O. f. Mossberg Ie Sons. Inc . North Haven. Conn.
Most gun for the money!
youngsters have applied that many clubs
and civic organizations have taken up the
program or given support. The Arizona Game
and Fish Commission, recognizing the vlllue
of this program and noting its success, has
empl oyed a full-time man (one of the
volunteer instr uctors), to introduce the gun
safety program into outlying communities
throughout the state.
There is a lesson to be learned from Ben
Avery, who is still Rod and Gun editor with
the "Arizona Republic," the state's lar gest
newspaper. All that it takes to start a fire-
arms safety program in any community is
one pioneer to lead the way. If properly
handled, such a program will gain followers
rapidly, and will prove to be one of the
most val uable community services.
If your town does not have such a pro-
gram, why not start one ? You can use
the Phoenix approach as your blueprint.
------------------
I
I
I
I
I
I
I
I
I
I
I
FITRITE
REVOLVER AND
PISTOL GRIPS
Genuine Mot her of Pearl,
Ivory and Stag Grips
Free Catalogue
: BOB FREILICH CO. 396 Br oome St.,
IN D EX OF ADVERT I SERS
GUNS and AMMUNITION
ROBERT ABELS 40
ATlAS ARMS, INC ... 63
BADGER SHOOTERS SUPPLy 36
BROWNING ARMS CO .. . 3
CONNECTICUT CARTRIDGE CORP . . 61
CHARLES DALy ; ....... 60
DISTRICT MERCHANDISE CO .. . ... 44
DIXIE GUN WORKS ....... . . .. . 38
NORM FlAYDERMAN ANTIQUE ARMS . . 56
GLOBAL IMPORT ............... . ... 65
GI L HEBARD GUNS . ... . ... . 58
HERTER' S, INC . . . . . . . 58
HUNTERS LODGE . . . .. . . 34, 35
HY-SCORE ARMS CORP .. .... . 36, 53
KLEIN'S SPORTING GOODS ..... .. . .... 11
O. F. MOSSBERG & SONS, INC. ....... . 66
MUSEUM OF HISTORICAL ARMS .... . 60
NORMA-PRECi SiON ....... . . .. .. 52, 53
NUMRICH ARMS ............ 43, 50
OWLI E'S SHOOTER' S DISCOUNT. . . ........ . 55
POTOMAC ARMS .. ............. . ... ...... .. .. 61
PARKER DISTRIBUTORS . .... .... .. .. . .. 40
REMINGTON ARMS CO., INC . .. . . Cover 2
SAVAGE ARMS CORP ......... ... .. . . .. ....... 7
SERVICE ARMAMENT CORP .. . .. ...... . .. ... 4, 58
STURM, RUGER & CO., INC ........... Cover 3
TINGLE MFG. CO., I NC ...... . . ... .. .... ..... . 49 ,
VIC'S FOR GUNS ....... . . . . 8
WINCHESTER, WESTERN DIV ..... . ........ Cover 4
HANDLOADING EQUIPMENT
CARBIDE DIE & MFG. CO ...... .. .. . ........ ... 65
CASCADE CARTRIDGE ... .. .. . . . . . . .42
HERTER' S, INC ........... . . 58
66
HORNADY MFG. CO 48
MURDOCK LEAD CO . 51
PACI FIC GUN SIGHT CO ... 54
R. C. B. S ..... .. ..... . ......... . .. . ..... .... 41
SAVAGE ARMS CORP . 57
SPEER, INC .................. . . . . .. . . ........ 65
HOLSTERS, CASES, CABINETS
COLADONATO BROTHERS . 48
DON HUME LEATHER GOODS . . 54
S. D. MYRES SADDLE CO .. . . 61
WHI TCO . . 52
SCOPES and SIGHTS
BAUSCH & LOMB, INC ... . 14
REDFIELD GUN SIGHT CO .. 9
WEATHERBY, INC. .. . .... . . 12
W. R. WEAVER CO .. 47
STOCKS and GRIPS
BECKELHYMER' S .. 8
E. C. BISHOP & SONS, INC ... 63
BOB FRIHICH .................... 59
HERRETTS STOCKS . . .. ... .. .. . 44
FRANK MI TTERMEl ER .CO . :: .' 51
PETERSON GUN STOCKS 48
ROYAL ARMS, I NC . .. .. 44
SPORTS, INC 65
TRADEWINDS, INC . .44
TOOLS and ACCESSORIES
GEO. BROTHERS .... . .. ... . .. .46
CUSTOM SHOOTER' S CENTER .. . . . . . ..... 53
DEM-BART CO . ........... . . . . . .. . . . 58
DREMEL MFG. CO .... . . . . . 48
FEDERAL I NSTRUMENT CORP . . . . 57
FRANK A. HOPPE, INC .. .. ... . ... . ..... ....... 65
JET-AER CORP . .... .. . . . .. . . . 65
NEW METHOD MFG CO ...... 65
RICE PRODUCTS .. .. . . . . . .... 56
TIME PRODUCTS CO . . . . . .. 40
MISCELLANEOUS
AMMO PAK CO .. . . .. . . . '65
EDDIE BAUER .. . .. . ... . .. 6
C. DANA CAHOON .. . ... 57
R. J. COFFEy . . . . . . . 65
COUGAR & HUNTER . . . . 52
G. R. DOUGLAS CO ... . . . 49
INTERNATIONAL ASSOC. OF AUXILIARY POllCE. 66
KOKEWAN KOMPANY ...... . ..... . 65
LEONARD CORP ... . . ....... . .. 45
MITCHELL SHOOTING GLASSES .. .. .. 65
NATIONAL RIFLE ASSOC ....... . . . 56
ONTARIO SPORTING CLUBS ALLIANCE . . . 53
THE OUTlET STORE .. . . . ..... 66
PACHMAYR GUN WORKS ... . . 54
BEN PEARSON, INC . . .... . ..... 10
PENDLETON GUN SHOP . ... ... . . . 55
POLYCHOKE CO ... .. . . . 42
PUBLIC SPORT SHOPS . . . . . . 60
RAY RILING ...................... . .......... . 61
J. HALL SHARON . .. .. 38
SHOOTERS CLUB OF AMERiCA ... .. . ... . .. . . 59
SHOTGUN NEWS ....... .. . . . . . .46
SIGMA ENGINEERING CO ......... ... . . . 49
STOEGER ARMS CORP .. ... . . . ......... . .... . . 37
TRAVEL INDUSTRIES ........ . ................. 38
WORLD OF GUNS .. . . . . .. . .... .. .. . 13
GUNS AUGUST 1964
"-'----1'
I
I
I
The New Ruger 10/22
.22 Caliber R. F. Self-Loader
The ultimate in logical design
--1--
with a rugged 10 shot rotary magazine
The RUGER 10/22 is built on the same scale, years of research and testing were required to
with the same sleek profile, to the same big- create this distinctive all-new RUGER.
game rifle standards as the famous RUGER Our reputation for quality firearms is in-
.44 Magnum Carbine. As firearms specialists volved with any new RUGER. We believe the
we have designed, engineered and manufac- Modell 0/22, and the major advance in rifle
tured the 1 0/22 to get the best performance design which it represents, will make it the first
I
I
I
ever obtained in a .22 Rimfire Sporter. To choice of the experienced shooter and the con-
I
insure this dependability and accuracy, the . noisseur of fine firearms. ,w
_ construction of the 10/22 incorporates many $54.50
I
- unique Idoesign featureds. fl fi STURM. RUGI.'R _ _ I
The /22 is no or inary ri e - as our rst
.22 caliber rifle it had to be better than any & COMPANY., INC.
I
competitor - it had to be the best in every I
detail. And it is. Inspired invention and several 40 Lacey Place, Southport, Conn., U.S.A. @
I AT YOUR REQUEST COMPLETE LITERATURE ON THE NEW 10/22 AND ALL OTHER RUGER FIREARMS. I
_____
At dusk, in Tanganyika, professional hunter Ommanney takes lead on running eland with new Model 70-300 Winchester Magnum.
How Winchester's new "free--floating"
barrel was tested and proved on safari by
David Ommanney, our man in Africa.
We've always gone out of our way
to field-test and prove all new Win-
chester products. Last fall, we went
as far as Tanganyika.
Why? For two important reasons.
We wanted to prove the new "free-
floating" barrel on our Model 70's*
- by trying it out where game is
Notice how the fore end of the stock at
no point touches the barrel of this Model
70. No chance of uneven pressure on the
metal. Therefore, natural vibration of the
greater accuracy in shooting.
*Except on the 375 and 458.
plentiful and varied. And we wanted
David Ommanney's opinion.
benchrest shooting.
This Winchester "free-floating"
barrel is the first ever fitted to a pro-
duction rifle. We had lots of confi-
Few men know more about game
and guns than this famous profes-
sional hunter, who led
us on safari. Ifhe hadn't
approved this unusual
barrel, we'd probably
have scrapped it.
Ommanney, as we
expected, knew about
the theory behind the
"floating" barrel, and
was inclihesJ. to think it
a pretty good idea . . But,
up to now, he'd never
seen a "floating" barrel
except on very costly,
custom-made rifles, used
for International Free
Rifle Matches and
"Best Winchester I ever
owned ... and I practically
cut my teeth on them,;' says
Ommanney.New Winchester
Model 70-300, price $154.95.
dence in it, before we
took it on safari. Our
month in the bush with
it gave us all the proof
we needed.
Here's how our man
in Africa summed up:
"It warmed my heart to
watch the new Model
70's at work. The new
barrel rates A for accu-
racy. 'Float' it may-but
you can bet your life
the bullet doesn't.
"The way these new
Winchesters did their
stuff was smashing."
WINCHS'A _
WINCHESTER WESTERN DIVISION "lin