Sie sind auf Seite 1von 3

PG

PG serial proportional control type Gas burner


General Introduction
NGLNGLPG

The natural gas burner uses the NG, LNG, LPG, CNG as fuel, the control system is
automatic proportional control type. According to equipment load control to achieve
combustion output smoothing, proportional control, and satisfies the requirement of
high precision load control.

The natural gas burner widely used for boilers, heating furnace and dryer drum
equipments etc.
Features
Safety and reliable automatic control
1.
Automatic program control, can set up to extend the pre-blow
and after blow, and ensure safety of fuel operation control;
2.

According to the dryer drum temperature or pressure needs to set a control
parameter to realize automatic burning amount proportional control, and can
easily achieve external chain control, ensure running safety.

3.UV

Using UV ultraviolet flame detection device to realize reliable flame monitoring
and flame-out protection, guarantee the security and stability of the flame
burns

4.
Configuration the gas pressure and air pressure safety protection
switch, can easily achieve external chain control at the same time, to ensure
safety operation



The best burning and adjusting function
1.


Using proportion servo control device to realize the combustion as well as the
combustion air automatic proportional control, output control in achieving
accurate load at the same time, can guarantee to achieve a good burning within
any point of the work.
2.
High wind pressure and gas pressure adaptability to ensure the wide
burner can adapt to more complex combustion conditions.
The structure is easy to maintenance
1.
Burner head and stabilize flame device assembly, can easily remove the
internal component to maintenance.
2.
Large burner can provide configuration sliding type mounting
base, sliding push-pull mode allows for easy installation and maintenance.
3.
Can provide non-standard length according to the combustion cylinder
model, meet the requirements of different furnace structure size.
Technical Parameters:
Model PG300 PG350 PG450 PG550

Output Power
KW 696-3480 812-4060 870-4840 1044-6200
Ten thousand
calorie/h
60-300 70-350 75-450 90-550

control mode

Automatic proportional control (accept other scale signal way)
Gas natural gasNG/LNG

Kpa 10
Mm H2O 100

Applicable scope of
pressure
Kpa 8-15
Mm H2O 800-1500
MJ/NM3 35.538500Kcal/Nm3


Design of burning
low calorific value
Working
Temperature

Degrees
Celsius
-15~60
Electricity AC380/50HZ

motor power
KW 5.5 5.5 7.5 11

Protection
grade
IP
40
40(Can rise the protection grade according to order requirement)

The flange installation form

Fixed flange (Can accept a non-standard length combustion tube
order)

Combustion air conditioning

Synchronous servo electric adjustment

Flame monitoring way
UV
UVtype

Gas inlet connection size
DN65 DN65 DN80 DN80
Remarks
The magnetic vale: America Honeywll
Control components: Siemens
Motor: Japan Shanwu

Das könnte Ihnen auch gefallen