q dtxr - detail text reference to know details of any component norma lly used to know rating of flange ,valve,gasket q abore - another method if not using q param (arrive bore size details ) q lbore - another method if not using q param (leave bore size details ) q mtxx - to know material text of component q spref - to know spec reference of pipe ( be on component) q pspec - to know the spec reference of pipe ( be on branch or pipe ) q ispec - to know the insulation spec of pipe ( be on branch or pipe ) axes at ph - to know head of branch axes at pt - to know tail of branch mark ce - to know head and tail of branch ( be on branch) unmark ce - to remove marking conn and p3 is up - change reducer flat side down to flat side up bop6 onto id sctn@ - to keep 6mm bop between sctn and bottom of pipe q att - to get attributes in command q name - to change name clea 200 - to give spool using command q atle - arrive tube length q ltle - leave tube length q tule - total tube length ( be on branch) q clle - total centre line length (be on branch) q clle - tule - total component and fitting lengths add href - to add head reference add tref - to add tail reference add cref - ( be on tee) add all pipe with in vol ce - ( be on any place) add all pipe with in vol ce 500 - ( be on any place)
add all pipe with in vol ce 1000 - ( be on any place) add all with in vol ce add ce auto ce - to add pipe & to zoom q noff of bltr of spref - to know no of bolts in a flange choo all - to reselect a component q pa bop wrt/* - to know the bottom of pipe coordinate values ( arrive) q pl bop wrt/* - to know the bottom of pipe coordinate values (leave) own - to navigate to owner (owner) q p1 p2 - to know end connection of a component ( two way ) q p1 p2 p3 - to know end connection of a component ( three way ) claim ce hier - to claim un claim all - to unclaim q user mod - to know last user modified q last mod - to know time & date it is modifed
STRUCTURAL COMMANDS q spref - to know specification of steel q bang - to rotate about the same angle q jusl - to change TOS to NA & from NA to TOS q drns - cut the section at any angle at start q drne - cut the section at any angle at end q cutl - total length with the cut angle length q derlen - total length without the cut angle length
Technical Writing A-Z: A Commonsense Guide to Engineering Reports and Theses, Second Edition, British English: A Commonsense Guide to Engineering Reports and Theses, U.S. English
Second Edition