100%(2)100% fanden dieses Dokument nützlich (2 Abstimmungen)
442 Ansichten2 Seiten
This document describes a typical formulation for a waterborne polyvinyl acetate (PVAc) wallboard adhesive. The formulation consists of 43.67% polyvinyl acetate emulsion, fillers like calcium carbonate, a thickener, plasticizer, surfactant, stabilizers, and preservatives. The adhesive has a solids content of 77-79%, density of 12.2 lb/gal, and viscosity of 60,000-70,000 cps. It provides an open time of 5-10 minutes and sufficient shear strength to bond gypsum wallboard after 10-40 minutes of drying.
This document describes a typical formulation for a waterborne polyvinyl acetate (PVAc) wallboard adhesive. The formulation consists of 43.67% polyvinyl acetate emulsion, fillers like calcium carbonate, a thickener, plasticizer, surfactant, stabilizers, and preservatives. The adhesive has a solids content of 77-79%, density of 12.2 lb/gal, and viscosity of 60,000-70,000 cps. It provides an open time of 5-10 minutes and sufficient shear strength to bond gypsum wallboard after 10-40 minutes of drying.
This document describes a typical formulation for a waterborne polyvinyl acetate (PVAc) wallboard adhesive. The formulation consists of 43.67% polyvinyl acetate emulsion, fillers like calcium carbonate, a thickener, plasticizer, surfactant, stabilizers, and preservatives. The adhesive has a solids content of 77-79%, density of 12.2 lb/gal, and viscosity of 60,000-70,000 cps. It provides an open time of 5-10 minutes and sufficient shear strength to bond gypsum wallboard after 10-40 minutes of drying.
Applicable Type Waterborne Adhesives Applicable Base Polymer Polyvinyl acetate emulsions & derivatives (PVAc...) Applicable Industrial Sectors Buildings & constructions
Adhesives and Sealants Starting Point Formulation
PROCESSING Vinyl acetate emulsion polymers and their additives can be compounded via simple mixing processes. For optimum processing the following should be followed: 1. Add VAE emulsion to mixer. 2. Mix in plasticizer and other liquids until a homogenous mixture is obtained. 3. Add remaining ingredients. 4. Add water to adjust viscosity as desired. APPLICABLE BASE POLYMER PROPERTIES Waterborne vinyl acetate adhesives for construction applications have relatively good flexibility and low temperature properties (by virtue of added plasticizers) and excellent adhesion to wood and paper. These adhesives provide a low to medium performance relatively inexpensive adhesive that dries quickly. A typical formulation consists of VAE latex, filler (if greater viscosity is desired), plasticizer (for improved flexibility), and water. RESULTING PROPERTIES This adhesive formulation has improved wet tack in which the adhesive joint remains firm immediately after the bond has been established. This adhesive formulation tends to have thixotropic properties that eliminate stringiness and provide good consistency. The adhesive also provides high solids content to lower cost and faster drying times.
The adhesive can have an open time greater than about 5 mins and a green strength sufficient to support a 4 foot by 8 foot wallboard on a wall frame without fasteners within 15 mins of applying the adhesive to the wallboard and wall frame. TIPS & TRICKS Emulsion vinyl acetate adhesives can be difficult to apply due primarily to their low solids content and foaming characteristics. Often fillers and antifoaming agents are employed to solve this problem. With emulsion adhesives, the water carrier provides excellent penetration into porous substrates. Penetration can be controlled by the concentration of particulate additives