Beruflich Dokumente
Kultur Dokumente
a
g
e
1
WR ANGL E R
P
a
g
e
5
4
(1) Do not attempt water fording unless depth is known to be less than 508 mm. Traversing water can cause damage that may not be covered by the new vehicle warranty. Always off-road responsibly
in approved areas. (2) Based on Wards Small Sport/Utility Vehicle segmentation. (3) Be sure to follow all instructions in Owners Manual for removal of top and doors, and lowering of windshield.
Driving with doors off and windshield down is for off-road use only. (4) Phone must support Bluetooth Phone Book Access Profile (PBAP). (5) The Advanced Front Air Bags in this vehicle are certified
to the new U.S. federal regulations for advanced air bags. Children 12 years old and younger should always ride buckled up in a rear seat. Infants in rear-facing child restraints should never ride in the
front seat of a vehicle with a passenger front air bag. All occupants should always wear their lap and shoulder belts properly. (6) No system, no matter how sophisticated, can repeal the laws of physics
or overcome careless driving actions. Performance is limited by available traction, which snow, ice and other conditions can affect. When the ESC warning lamp flashes, the driver needs to use less
throttle and adapt speed and driving behavior to prevailing road conditions. Always drive carefully, consistent with conditions. Always wear your seat belt. This brochure is a publication of Chrysler
Group LLC. All product illustrations and specifications are based upon current information at the time of publication approval. Chrysler Group LLC reserves the right to make changes from time to time,
without notice or obligation, in prices, specifications, colors, materials and to change or discontinue models, which are considered necessary to the purpose of product improvement or for reasons of
design and/or marketing. Chrysler, Jeep, the Jeep Grille, Rubicon, Sahara, Wrangler, Go Anywhere, Do Anything, Command-Trac, Freedom Top, Pentastar, Rock-Trac, Sentry Key, Tru-Lok and Uconnect
are registered trademarks of Chrysler Group LLC. Alpine and the Alpine logo are registered trademarks of Alpine Electronics, Inc. All rights reserved. Bluetooth is a registered trademark of Bluetooth SIG, Inc.
Dana and Trac-Lok are registered trademarks of Dana Corporation. Garmin and the Garmin logo are registered trademarks of Garmin, Ltd. or its subsidiaries and are registered in one or more countries,
including the U.S. Goodyear is a registered trademark of The Goodyear Tire & Rubber Company. Sunrider is a registered trademark of Bestop, Inc. 2013 Chrysler Group LLC. All rights reserved.
14C5JWRAE1425 (11.875M)
P
a
g
e
3
EXPLORE WI TH THE UNI QUE
CAPABI LI TY, COMFORT
AND TECHNOLOGY OF
J EEP
.
I TS GUTS ARE BUI L T TO DE L I VE R ON THI S PROMI S E .
P
a
g
e
9
P
a
g
e
9
TRACTI ON
ARTI CULATI ON
MANEUVERABI LI TY
GROUND
CLEARANCE
WATER FORDI NG
1
P
a
g
e
1
3
GRABS THE GROUND
AND DOESN T LET GO.
P
a
g
e
1
2
TRU-LOK
LOCKING DIFFERENTIALS.
Front and rear electronic-locking diferentials balance
speed between left and right wheels, maintaining forward
momentum for the ultimate in traction. An instrument
panel-mounted rocker switch can lock either the rear or
both axles. (Standard only on Rubicon.)
ROCK-TRAC
TRANSFER CASE.
A 4:1 low-gear ratio allows Wrangler Rubicon to crawl at a
low speed for greater control and increases the amount of
torque available at the wheels. (Standard only on Rubicon.)
ROCK RAILS.
Extra-tough body-mounted rails provide additional rocker
panel protection. (Standard only on Rubicon.)
TWO-PIECE STRUCTURAL OIL PAN.
A two-piece oil pan provides a steel lower portion for
impact resistance with an upper aluminum section for
improved weight savings.
HEAVY-DUTY SUSPENSION.
Solid axles with locating arms, coil springs, track/stabilizer
bars, front steering damper and tunable monotube shock
absorbers that are rmat low speeds and more relaxed at
higher speeds. (Standard on Rubicon.)
DANA
SOFT TOP AND SEE THE WORLD FROM A POINT OF VIEW THAT
ELIMINATES ALL BOUNDARIES BETWEEN YOU AND THE OUTDOORS.
P
a
g
e
2
1
REMOVABLE FULL-FRAMED DOORS AND
FOLD-DOWN WINDSHIELD.
3
Every Wrangler
arrives ready for a full-on open-air experience.
SUNRIDER
ENGINE IMMOBILIZER.
A unique embedded key code matched only to your
vehicle helps keep your Wrangler safely where it
belongs. Standard.
HILL START ASSIST (HSA) AND
HILL DESCENT CONTROL.
HSA works to prevent Wrangler from rolling when
starting on an up-hill gradient. Standard. Hill Descent
Control is packaged with the available 5-speed
automatic transmission and diligently works to help
Wrangler navigate steep declines at a steady and
consistent speed.
ELECTRONIC STABILITY CONTROL (ESC)
6
.
This advanced system utilizes hydraulic brake assist,
traction control, Electronic Roll Mitigation (ERM) and
Trailer Sway Control (TSC) to constantly monitor driver
input against the vehicles actual course. If needed, ESC
automatically brakes and/or reduces engine torque, while
ERM estimates the potential for wheel lift, reducing
engine power and applying brakes if needed. TSC
engages the brakes to slow the vehicle, increasing brake
force to one side of the vehicle to help counteract the
sway from the trailer. Standard.
HEATED POWER EXTERIOR MIRRORS.
Keep sideview mirrors fog-free as you warm up your
interior. Available.
ENERGY-ABSORBING FRONT RAIL EXTENSIONS.
Collapsible, hydro formed front rail tips offer low-speed
protection and can be serviced after impact events of up
to 12.875 km/h. Standard.
HALOGEN HEADLAMPS AND FOG LAMPS.
These bright sources of light improve down-road visibility
at night or during inclement weather.
WHEN THE WEATHER GETS
TOUGH, SO WI LL YOU.
P
a
g
e
3
2
P
a
g
e
3
5
RISE TO THE ADVENTURE.
P
a
g
e
3
4
P
a
g
e
3
6
1
2
1 Sedosa cloth/Rivet cloth Black with Light Slate Gray accent stitching (Standard)
2 Sedosa cloth/Rivet cloth Black with Dark Saddle accent stitching (Standard)
> Pentastar 3.6 V6 engine
with 6-speed manual
transmission/5-speed
automatic transmission
(available)
> Rock-Trac 4WD system
> Tru-Lok front/rear
locking differentials
> Front sway bar
disconnect system
> Dana 44 heavy-duty front/rear
axles
> High-pressure monotube
shocks with tunable valves
> Heavy-Duty suspension system
> Electronic Stability
Control (ESC)
> Hill Start Assist (HSA) and
Electronic Roll Mitigation
(ERM)
> Sentry Key antitheft engine
immobilizer
> Rubicon embroidered seating
> Skid plates for fuel tank and
transfer case
> Tow eye brackets
> Removable front air dam
> Rock rails
> Premium Sunrider
Soft Top
> Uconnect 135
CD/MP3 radio
> Alpine Premium
Sound System
> Full center console with locking
storage
> Leather-wrapped
steering wheel with
speed/audio controls
> 17-inch polished aluminum Gray
wheels
IN
T
E
R
IO
R
T
R
IM
S
T
A
N
D
A
R
D
P
a
g
e
3
7
THIS WILLING ADVENTURER ARRIVES FULLY ARMORED TO CONQUER THE MIGHTY RUBICON TRAIL. WRANGLER RUBICON AND
UNLIMITED RUBICON ARE BORN WITH TRU-LOK ELECTRONICALLY LOCKING DIFFERENTIALS, HUGE TIRES, SKID PLATES AND THE
LEGENDARY ROCK-TRAC TRANSFER CASE.
R U B I C O N
P
a
g
e
3
8
S A H A R A
AUTHENTIC CAPABILITY, REFINED WITH BODY-COLOR FENDER FLARES AND TUBULAR SIDE STEPS, GIVES SAHARA AND
UNLIMITED SAHARA THEIR UNIQUE APPEAL. RIDE THE PAVED ROADS AND THE RUGGED TRAILS ALIKE, IN STYLE WITH
STANDARD 17-INCH WHEELS.
P
a
g
e
3
9
1
2
IN
T
E
R
IO
R
T
R
IM
S
T
A
N
D
A
R
D
1 Sedosa cloth/Rivet cloth Black with Light Slate Gray accent stitching (Standard)
2 Sedosa cloth/Rivet cloth Black with Dark Saddle accent stitching (Standard)
> Pentastar 3.6 V6 engine with
5-speed automatic transmission,
standard on Sahara Unlimited.
6-speed manual standard on
Sahara/5-speed automatic
transmission (available).
> Command-Trac
4WD system
> Dana 44 heavy-duty
rear axle
> Dana front axle
> Electronic Stability
Control (ESC)
> Skid plates for fuel tank and
transfer case
> Hill Start Assist (HSA)
and Electronic Roll Mitigation
(ERM)
> Sentry Key antitheft engine
immobilizer
> Tow eye brackets
> Removable front air dams
> Tubular side steps
> Body-color fender flares
> Premium Sunrider
Soft Top
> Full-framed removable doors
> Uconnect 135
CD/MP3 radio
> Alpine Premium
Sound System
> Sahara embroidered cloth and
leather seating
> Full center console with locking
storage
> Leather-wrapped
steering wheel with
speed/audio controls
> 17-inch cast
aluminum wheels
P
a
g
e
4
0
1
1 Sedosa cloth/Jeep Hex cloth Black (Standard on Sport)
> Pentastar 3.6 V6 engine
with 6-speed
manual transmission
> Command-Trac
4WD system
> Dana 44 heavy-duty
rear axle
> Dana front axle
> Electronic Stability
Control (ESC)
> Hill Start Assist (HSA)
> Electronic Roll
Mitigation (ERM)
> Sentry Key antitheft
engine immobilizer
> Skid plates for fuel tank
and transfer case
> Tow eye brackets
> Removable front air dam
> Halogen headlamps and
fog lamps
> Sunrider Soft Top
> Uconnect 135
CD/MP3 radio
> Six-speaker audio system
> Cloth seating
> Full center console with
locking storage
> Reversible cargo mat with
Jeep logo
> Wash-out interior with
removable carpet and
drain plugs
> 16-inch slot-spoke steel
painted wheel
> 17-inch 5-spoke cast
aluminum wheel
(Sport S)
IN
T
E
R
IO
R
T
R
IM
S
T
A
N
D
A
R
D
P
a
g
e
4
1
AIM FOR PARTS UNKNOWN WITH WRANGLER SPORT AND UNLIMITED SPORT. THE POWERFUL 3.6 PENTASTAR V6 ENGINE,
PAIRED WITH COMMAND-TRAC 4WD, GIVES YOU THE GOODS TO GO FORTH WITH CONFIDENCE. YOULL FEAR NO MUD
WITH A WASHABLE, HOSE-OUT INTERIOR.
S P O R T
P
a
g
e
4
2
1 Bright White
2 Anvil
3 Black
4 Ampd
5 Billet Silver
Metallic
6 Flame Red
7 Granite
Crystal Metallic
8 Hydro Blue Pearl*
9 Copperhead Pearl
10 Dune
*Late availability
E
X
T
E
R
I
O
R
C
O
L
O
R
S 2
4
6
8
9
10
5
3
1
7
P
a
g
e
4
3
1
2
4
5
6
3
1. 16-inch Slot-Spoke Styled Steel Painted Argent (Std. on
Sport) 2. 17-inch Moab Cast AluminumPainted Sparkle Silver
(std. on Sahara; opt. on Sport) 3. 18-inch Polished Sparkle
Silver (Opt. on Sahara) 4. 18-Inch Polished Aluminum(Opt. on
Sahara) 5. 17-inch Polished Mineral Gray (Std. on Rubicon)
6. 17-inch Polished Black (Std. on Rubicon X)
1. 16-inch Slot-Spoke Styled Steel Painted Argent (Std. on
Sport) 2. 17-inch Moab Cast AluminumPainted Sparkle Silver
(std. on Sahara; opt. on Sport) 3. 18-inch Polished Sparkle
Silver (Opt. on Sahara) 4. 18-Inch Polished Aluminum(Opt. on
Sahara) 5. 17-inch Polished Mineral Gray (Std. on Rubicon)
6. 17-inch Polished Black (Std. on Rubicon X)
W
H
E
E
L
S
P
a
g
e
4
4
FREEDOM TOP HARDTOP
Strong and secure ride. Enjoy the best of both
hardtop and soft top worlds when you choose
the Dual-Top Group. (Available on Wrangler and
Wrangler Unlimited in Black.)
AVAILABLE BODY-COLOR FREEDOM TOP
HARDTOP
Now you can match the color of your hardtop
to the body-color of your Sahara, Sahara
Unlimited, Rubicon or Rubicon Unlimited.
AVAILABLE BODY-COLOR FENDER FLARES
Opt for color-matched ares to complete the
package on your Rubicon or Rubicon Unlimited.
SUNRIDER SOFT TOP is watertight and easy to
fold away.
PREMIUM SUNRIDER SOFT TOP adds an extra
level of durability and sound dampening for a
quieter ride. (Available on Sport model; Standard
on Sahara and Rubicon.)
T
O
P
S
P
a
g
e
4
5
FULL-FRAMED DOORS
Removable, with roll-up windows and available power
windows and door locks. Map pockets with mesh net
to ensure wash-out capability. Aluminum-forged hinges
are used on both Wrangler and Wrangler Unlimited.
(Optional on Sport model; Standard on Sahara
and Rubicon.)
HALF-FRAMED DOORS
Removable and feature manual locks. You
can remove the doors completely for the
ultimate in open-air freedom. (Standard
on Sport model.)
D
O
O
R
S
P
a
g
e
4
6
FOUR-WHEEL-DRIVE SYSTEM (transfer case)
NV241 GII Command-Trac (includes off-road skid plate),
part-time, 2-speed, with shift-on-the-fly, 2.72:1
low-gear ratio _______ Std. All 4x4 models, except Rubicon
NV241 OR Rock-Trac (includes off-road skid plate),
part-time, 2-speed, with shift-on-the-fly, 4.0:1
low-gear ratio ______________________________Std. Rubicon
BODY/SUSPENSION/CHASSIS (2-door/4-door)
Body Design _Boxed steel frame with crushable, hydroformed
front rail tips
Suspension ________________Live solid axles, 5-link front/rear,
coil springs, leading arms, track/stabilizer
bars and front steering damper
Steering _______________Power, recirculating ball with damper
Turns (lock-to-lock) ____________________________ 3.22/2.54
Turning Diameter (curb-to-curb, with
P225/75R16 tires) (meters) ________________________10.4/13.1
Brake System ________ 4-wheel disc hydraulic, power-assisted,
302-mm front/316-mm solid rear
POWERTRAIN
Engine 3.6 Pentastar V6
Engine capacity (cu cm)________________________________3604
Horsepower (Hp (DIN) @ rpm) _________________285 Hp@ 6350
Torque (Nm @ rpm) _______________________ 347 Nm @ 4300
Axle Ratio (:1)
6-speed manual ______3.21 Std., 3.73 Opt., 4.10 Std. Rubicon
5-speed automatic _____3.21 Std., 3.73 Opt. (Std. on Rubicon)
Fuel System ____ Sequential multipoint, electronic fuel injection
Transmission
6-speed manual with overdrive, synchronized in all gears,
multi-rail shift system with top-mounted shift lever ______Std.
5-speed automatic with overdrive clutch hydraulic actuation,
Hill Descent Control, electronically controlled converter
clutch _______________________ Opt. (Std. on Sahara Unlimited)
Electrical System
Alternator _______________________________________ 160 ampere
Battery __________________________ 600 CCA, maintenance-free
Fan _______________ On-demand, pulse with modulated electric
GEAR RATIO/CRAWL RATIO
Model
First
Gear
Transfer
Case (4LO) Axle Crawl
Rubicon 4.46 4.00 4.10 73.1
Unlimited Rubicon 4.46 4.00 4.10 73.1
Sahara 4.46 2.72 3.21 38.9
Unlimited Sahara 4.46 2.72 3.21 38.9
Sport 4.46 2.72 3.21 38.9
Unlimited Sport 4.46 2.72 3.21 38.9
S
P
E
C
I
F
I
C
A
T
I
O
N
S
P
a
g
e
4
7
TOWING DATA
Max Towing Capacity (kg)
When properly
equipped _________ 1000/2000
CAPACITIES/WEIGHTS
(4WD) (2-door/4-door; pounds unless
otherwise noted)
Fuel Tank (liters) __________ 70.4/85.17
Max Cargo (kg) ______________ 28/35
Gross Vehicle Weight Rating
(when properly
equipped) __________2268 kg/2540 kg
EXTERIOR
(2-door/4-door Rubicon; mm unless
otherwise noted)
Wheelbase _______________2268/2947
Overall Length ___________ 4223/4751
Overall Width _____________1873/1877
Track _________________________1572
Height __________________ 1825 to 1865
Ground Clearance (at curb weight) ___
223/220
Approach Angle ________________ 35
Breakover Angle ____________ 22/18
Departure Angle ________________ 28
Water Fording Depth ___________ 508
INTERIOR
(2-door/4-door; mm unless
otherwise noted)
Seating Capacity: 2-door front/rear
2/2 adults
4-door front/rear ______ 2/3 adults
Head Room: front ______1069/1074.5
rear _________________1035.3/1059.3
Leg Room: front _______________ 1039
rear ____________________ 880/920.8
Shoulder Room: front ________ 1414.7
rear _____________________1514/1448
Hip Room: front ________ 1394/1393.2
rear ___________________ 1100/1389.6
Cargo Volume (2-door/4-door, liters):
rear seat folded ________1052/2009
behind rear seat ________365.2/897
P
a
g
e
4
9
WRANGLER
WRANGLER
UNLIMITED
S
P
O
R
T
S
A
H
A
R
A
R
U
B
IC
O
N
S
P
O
R
T
S
A
H
A
R
A
R
U
B
IC
O
N
B S G R C S G R
INTERIOR
Air Conditioning
Automatic temperature controls
Heated Front Seats Included with leather trim P P P P
Lighting Rear cargo with on/off switch
Seating Leather-trimmed O O O O
Rear Fold and Tumble seatback, removable
Split-folding with self-articulating outboard head restraints
Steering Wheel Leather-wrapped, with speed control
(included with Connectivity Group)
P P
SAFETY AND SECURITY
Air Bags Supplemental front-seat-mounted side O O O O O O
Hill Descent Control Included with 5-speed automatic
transmission
P P P P P P P P
UCONNECT
135 CD/MP3
Uconnect