Beruflich Dokumente
Kultur Dokumente
Under Zeton Default 2015 Mixed Metric project is a drawing located: RS-1 under folder Pipe Supports:
In this drawing I have placed several Blocks (3D models) off supports:
From 3 off this blocks I created plantparts with the command: PLANTPARTCONVERT.
The plantparts have eatch 1 connection port on the pipe line center in direction off the centreline.
See below.
After creating these plantparts, there are created automatically several (3) .png-files in the same pipe
support folder, see below:
With plant3DSpeceditor, I created a new support spec (copy from the autodesk PipeSupportSpec):
- ZetonSupportSpec.pspc
- ZetonSupportSpec.pspx
In the Catalog Editor I selected CREATE NEW COMPONENT. See below:
with SELECT MODEL I added the plantparts to the catalog. See below
Result:
After this I placed the catalog parts (RS-1-SS-P-100) in de spec:
At same time a drawing is placed (automatically) under folder AutoCADPlant3DContent with the support
blocks. See below:
In drawing test in the project I open the support spec with the spec viewer.
In this spec viewer I see the 3 added pipe supports (RS-1-SS-1/2-P-100, RS-1-SS-3/4-P-100, RS-1-SS-
1-P-100)
I cant select the Autodesk PipeSupportSpec. Why not? Its in the same project spec sheet
folder.
I ad one support to a pipeline with spec viewer : insert in model
Support is placed but not connected to the pipeline:
Teardrop (disconnect marker)
For example: Simple Pipe Support from TOOLPALETTE :
Is oke.
Simple Pipe Support from spec viewer (insert in model) results also with a teardrop.
Problem: adding from spec viewer results in a disconnected support.
After this I placed the custom supports in the toolpalette.
I can see the model (picture) in the toolpalette but I cant select the support (no reaction)
What could be the solution to fix this problem?
Location standard autodesk pipesupportspec:
zetonSupportSpec at same location as pipespec.s.
In Plant3D I see the ZetonSupportSpec, but not the autodesk pipesupportspec in spec viewer:
See spec viewer:
Next page
Support placed with spec viewer:
Left: support placed spec viewer, Right: support in toolpalette (its visable in toolpalette, but cant select
or placed).
Next page
Zeton support properties: autodesk support properties
PipeInlineAsset in stead of
support
Location autodesk supportspec under Plant3DContent folder:
Location autodesk support spec under default project:
Verschil tussen pcat en acat files.
.pcat en .acat-files could this be the solution?