0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
39 Ansichten3 Seiten
180deg overturning machine including two sets every group is mainly used to overturning H-section steel finish welding one face. Main body is composed of double 90deg rocking arm, base frame, moving wheel group, moving motor speed reducer and track.
180deg overturning machine including two sets every group is mainly used to overturning H-section steel finish welding one face. Main body is composed of double 90deg rocking arm, base frame, moving wheel group, moving motor speed reducer and track.
180deg overturning machine including two sets every group is mainly used to overturning H-section steel finish welding one face. Main body is composed of double 90deg rocking arm, base frame, moving wheel group, moving motor speed reducer and track.
Operation instructions for 180 overturning machine
. Structure principle The 180 overturning machine including two sets every group is mainly used to overturning H-section steel finish welding one face, it through 2 hydraulic cylinder drive 2 L type rack turning synchronization, overturning the H-section steel after assembling and then conveying to rollers, rollers transfer them to next process or other working. On the rack installed speed reducer and moving wheel to make the rack have moving function. This overturning machine is composed of main body, hydraulic system and electrical control system. Main body is composed of double 90 rocking arm, base frame, moving wheel group, moving motor speed reducer and track (see drawing A).
. Main technical parameter Suitable weight of workpiece: 15T Moving speed reducer power: 1.5KW Moving speed: 6m/min Diameter of overturning oil cylinder: 140mm Max pressure of hydraulic system: 20Mpa
2 . Working principle and operating procedure 1. check the input voltage should be 3 P 380V (allowed fluctuate range 105). 2. Push power on button, the indicate lamp light. Push: oil pump start button, the indicate lamp of oil pump working light, Adjust the oil pump working pressure to 6-10Mpa. 3. Through heavy-load conveying roller, transfer H-section steel above 180 overturning machine. 4. Push working/adjust button, then push move left or move right button, adjust one of hydraulic overturning rack; push working/adjust button again,
3 button loose, begin working, at this time, the two hydraulic overturning racks working synchronously. Push move left or move right button, adjust to needed position. 5. Switch the rotating direction to forward position, push NO1 arm 90, then push total 90 button, when turning arm to 45 , after transfer the section steel to suitable position, push total 90 button, to make section steel overturning 90, then push NO2 arm 90 to reset. 6. Switch the rotating direction to reverse position, push NO2 arm 90, then push total 90 button, when turning arm to 45 , after transfer the section steel to suitable position, push total 90 button, to make section steel overturning 90, then push NO1 arm 90 to reset.
. Maintenance and fault remove 1. The moving part should turn flexible, no block, chain wheel should have lubrication oil; piston rod should clean frequently to keep lubrication. 2. Check hydraulic oil pipe, oil cylinder and hydraulic system in a certain period, if find anything abnormal, should inspect oil pipe. 3. Check the track of overturning rack, clean sundries block moving. 4. After finish working, the piston rod should back to oil cylinder to avoid pollution of dust and scalethe overturning rack should stop at the outside of conveying roller.