0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
20 Ansichten2 Seiten
LeakControl is a system that uses ultrasonic sensors to continuously monitor water flow in pipe networks to detect leaks. The sensors attach to the outside of pipes without disrupting water flow. Data is transmitted via GSM to allow remote monitoring. It allows quick detection of leaks and identification of the affected network area. Installation is simple and does not require shutting off water or building access chambers.
LeakControl is a system that uses ultrasonic sensors to continuously monitor water flow in pipe networks to detect leaks. The sensors attach to the outside of pipes without disrupting water flow. Data is transmitted via GSM to allow remote monitoring. It allows quick detection of leaks and identification of the affected network area. Installation is simple and does not require shutting off water or building access chambers.
LeakControl is a system that uses ultrasonic sensors to continuously monitor water flow in pipe networks to detect leaks. The sensors attach to the outside of pipes without disrupting water flow. Data is transmitted via GSM to allow remote monitoring. It allows quick detection of leaks and identification of the affected network area. Installation is simple and does not require shutting off water or building access chambers.
with ultrasonic sensors Data transmission for continuous network monitoring Quick allocation of a leak to a particular network area Installation without supply inter- ruption orchamber construction Special features LeakControl enables the continuous fow monitoring of a pipe network section (DMA District Metering Area) through the use of ultrasonics. Since the sensors are simply attached to the outside of the pipe, installation can be carried out without interrupting the water supply. In addition, LeakControl is completely maintenance-free after set-up. For electricity supply, cables which have already been laid (e. g. for street lighting) can be used. These charge a battery which enables measurements to be carried out even during the day. The collected data is sent via GSM modem or SMS directly to a PC or laptop. Using the provided software, the data can be easily read and evaluated. An alarm function and threshold setting function are included, so you can react quickly and effciently in emergencies. LeakControl also supports remote maintenance and remote confguration via GSM, so that once LeakControl has been installed, it can be easily controlled and maintained from the head offce. Description Simple and inexpensive installation without chamber construction Professional above-ground installation of the telemetry unit We reserve the right to make technical changes. dat_leakcontrol_en_140108.pdf ISO 9001:2008 LeakControl Technical data Operating range Up to DN 1400 Power supply 230 V external; battery operation possible Battery power 4 hours UPS 24 hours Data transmission GSM Operating temperature -30 C to +100 C Sensors M5 and Q5 Protection class Sensors IP 68 Distribution box IP 43 II SebaKMT Dr.-Herbert-Iann-Str.6 96148 Baunach/Germany Tel. +49 ( 0 ) 9544 - 680 Fax +49 ( 0 ) 9544 - 2273 sales@sebakmt.com www.sebakmt.com High-resolution monitoring of fow for better network analysis Measurement range of the sensors Flow speed 0.01 m/s 25 m/s Resolution 0.025 cm/s Reproducibility 0.25% of measured value 1 cm/s Volumetric fow 2% of measured value 1 cm/s Dimensions Distribution box without base 350 x 272 x 1300 mm Distribution box with base 350 x 272 x 1700 mm Infow measurement (stationary + continuous) Infow measurement (stationary + continuous) Tank outfow measurements Division of the supply structure intonetwork areas Simultaneous monitoring of the fows inall areas Concentration on problem zones andlarger network areas Water tank